Lux Tools BKS-45/45MM Manuel utilisateur
3
12 11
2
5
3
4
1
89 7 6
10
1
19
13
18 17
20
21
16
14
15
2
temp.book Seite 3 Donnerstag, 5. November 2015 8:59 08
4
1
1819
3 4
5
18 17
6
10 8
7
22
8
temp.book Seite 4 Donnerstag, 5. November 2015 8:59 08
5
4
14
20
7
9
9
13
6
11
temp.book Seite 5 Donnerstag, 5. November 2015 8:59 08
6
3
23 24 25
12
13
temp.book Seite 6 Donnerstag, 5. November 2015 8:59 08
7
Original instructionsGasoline chain saw
Table of contents
Before you begin… . . . . . . . . . . . . . . . . . 7
For your safety . . . . . . . . . . . . . . . . . . . . 7
Your device at a glance . . . . . . . . . . . . 10
Assembly . . . . . . . . . . . . . . . . . . . . . . . . 10
Operation . . . . . . . . . . . . . . . . . . . . . . . . 12
Cleaning and maintenance . . . . . . . . . 16
Storage and transport . . . . . . . . . . . . . 18
Faults and remedial measures. . . . . . . 19
Disposal . . . . . . . . . . . . . . . . . . . . . . . . . 20
Technical data . . . . . . . . . . . . . . . . . . . . 20
Claims for defects. . . . . . . . . . . . . . . . . 40
Before you begin…
Intended use
This device may only be used with the
approved original cutting chains for sawing
wood outdoors.
This product is not intended for commercial
use. Generally acknowledged accident pre-
vention regulations and enclosed safety
instructions must be observed.
Only perform work described in these
instructions for use. Any other use is
improper. The manufacturer will not assume
responsibility for damage resulting from such
use.
What are the meanings of the symbols
used?
Danger notices and information are clearly
marked throughout these instructions for
use. The following symbols are used:
These symbols identify the required personal
protection equipment:
For your safety
General safety instructions
• To operate this device safely, the user
must have read and understood these
instructions for use before using the
device for the first time.
• Observe all safety instructions! Failure to
do so may cause harm to you and others.
• Retain all instructions for use, and safety
instructions for future reference.
• If you sell or pass the device on, you must
also hand over these operating instruc-
tions.
• The device must only be used when it
functions properly. If the device or part of
the device is defective, have it repaired
by a specialist.
• Never use the device in a room where
there is a danger of explosion or in the
vicinity of flammable liquids or gases.
• Danger of suffocation caused by exhaust
fumes! Starting the motor and using the
device inside closed rooms is prohibited.
• The motor should be switched off:
– whenever you leave the machine unat-
tended
– before you refill it
• When the motor is switched off, close the
throttle. If the machine has a petrol feed
tap, this should be closed when you finish
working.
• Never store the unit with fuel in the tank
inside a building in which fuel vapours
may come into contact with naked flames
or sparks or may inflame.
• Always allow the motor to cool down
before putting the unit into a close space.
• To prevent risks of fire, ensure that both
the motor and the exhaust are free of
plant materials or leaking grease (oil).
• Always ensure that a device which has
been switched off cannot be restarted
unintentionally.
• Do not use devices with an on/off switch
that does not function correctly.
• Keep children away from the device!
Keep the device out of the way of children
and other unauthorised persons.
DANGER! Direct danger to life and
risk of injury! Directly dangerous
situation that may lead to death or
severe injuries.
WARNING! Probable danger to life
and risk of injury! Generally dan-
gerous situation that may lead to
death or severe injuries.
CAUTION! Possible risk of injury!
Dangerous situation that may lead to
injuries.
NOTICE! Risk of damage to the
device! Situation that may lead to
property damage.
Note: Information to help you reach
a better understanding of the pro-
cesses involved.
GB
temp.book Seite 7 Donnerstag, 5. November 2015 8:59 08
8
• Do not overload the device. Do not use
the device for purposes for which it is not
intended.
• Make sure to always wear the required
personal protective equipment.
• Exercise caution and only work when in
good condition: If you are tired, ill, if you
have ingested alcohol, medication or ille-
gal drugs, do not use the device, as you
are not in a condition to use it safely.
• This product is not intended to be used
by persons (including children) or who are
limited in their physical, sensory or men-
tal capacities or who lack experience
and/or knowledge of the product unless
they are supervised, or have been
instructed on how to use the product, by
a person responsible for their safety.
• Ensure that children are not able to play
with the device.
• Always comply with all applicable
domestic and international safety, health,
and working regulations.
Risks caused by vibrations
The vibration values specified in the technical
data represent the main uses of the device.
The actual existing vibrations during use may
deviate from these as a result of the following
factors:
• Incorrect use of the product;
• Unsuitable tools inserted;
• Unsuitable material;
• Insufficient maintenance.
You can reduce the risks considerably by fol-
lowing the tips below:
– Maintain the device in accordance with
the instructions in the operating instruc-
tions.
– Avoid working at low temperatures.
– When it is cold, make sure your body and
your hands, in particular, are kept warm.
– Take regular breaks and move your
hands at the same time to promote circu-
lation.
Concerning the use of fuels
Fuels are inflammable and explosive.
Reduce the risk of explosion and fire as
follows:
• Turn off and cool the motor down before
filling the tank with fuel.
• Refrain from smoking and starting open
fires when handling fuels.
• Store and mix fuels in approved and cor-
respondingly labelled canisters.
• Store fuels in closed containers. Keep in
mind that fuels may also evaporate at
room temperature and collect on the floor
of closed rooms(risk of explosion).
• Do not open the tank lid or refill with pet-
rol when the motor is running or even
when it is hot.
• If petrol is spilled, do not attempt to start
the motor.
• Start the machine at least nine metres
away from the fuelling location.
• If you need to empty the tank, do so out
in the open.
Fuels are toxic! They contain substances
that have an immediate toxic effect and
may also cause permanent damage to
your health. Take all precautionary meas-
ures to prevent your body from absorbing
any of these substances:
• Tank and siphon fuels only outdoors or in
well-ventilated rooms.
• Do not inhale fuel fumes.
• Avoid contact with eyes and skin. If con-
tact occurs, thoroughly rinse with water.
If contact with eyes occurs, seek immedi-
ate medical attention.
• Wear gloves when transferring fuel.
• When fuel has come into contact with
your clothes, change them immediately.
Clean your clothes before putting them
back on.
• Store fuels out of the reach of children.
When handled inappropriately, fuels may
cause damage to the environment:
• Use caution when siphoning fuels. Fuel
must never seep into the ground or the
sewage system.
• Dispose of any remaining fuel in an
appropriate manner. Never dispose of
fuel with regular household waste.
CAUTION! Risk of injury due to
vibrations! Vibrations may, in partic-
ular for persons with circulation
problems, cause damage to blood
vessels and/or nerves.
If you notice any of the following
symptoms, stop working immedi-
ately and consult a doctor. Numb-
ness of body parts, loss of sense of
feeling, itching, pins and needles,
pain, changes in skin colour.
GB
temp.book Seite 8 Donnerstag, 5. November 2015 8:59 08
9
• Fuels may be stored only for a limited
time. Never buy more fuel than you plan
on consuming within the next few
months.
Maintenance
• Before conducting any maintenance on
the device, always set the ignition switch
to[0] and pull the ignition cable plug.
• Check the fuel system regularly for leaks
or defective parts.
• Only those maintenance and fault elimi-
nation tasks described here may be car-
ried out. Any other tasks must be com-
pleted by a specialist.
• Only use original replacement parts. Only
these replacement parts are designed
and suitable for the device. Other
replacement parts will not only lead to an
invalidation of the warranty, they may
also endanger you and your environment.
Device-specific safety instructions
• Young people under 18 years of age and
users who are not sufficiently acquainted
with its operation must not use the device
• Make sure that the device is assembled
completely and according to regulations.
• Check the device to ensure that it works
correctly, especially check the correct
and secure fit of the chain rail, saw chain
tensioned according to regulations and
correct function of the chain brake.
• Check all screw connections regularly to
ensure tight fit.
• Before use, ensure that there are no peo-
ple or animals in the work area.
• Make certain that the work area is free of
obstacles.
• Always keep an eye on your surroundings
in order to ensure that you are not endan-
gering any people or animals with your
work.
• No other persons or animals may be pre-
sent within an area of 15m around the
cutting area, as they may otherwise by hit
by objects being slung away.
• Never work in poor light or weather con-
ditions.
• Only saw wood. Do not use the chain saw
for work for which it is not intended.
• Keep the handles dry, clean and free of oil
and grease. Greasy, oily handles are slip-
pery and cause loss of control.
• Avoid sawing in bushes, since here small
branches may get caught in the saw
chain and they can fly out uncontrolled.
• Make sure that you can stand firmly and
safely in each work position. When work-
ing on a sloping subsurface, be especially
careful!
• Always hold the device firmly in both
hands. Use your right hand to grip the
rear handle, your left hand to grip the
other handle, even if you are left-handed.
Do not let go of the handles!
• When the saw is running, keep all body
parts away from the saw chain. Make
sure before starting the saw that the saw
chain does not touch anything.
• Never saw above shoulder height! Do not
lean forward or back!
• Always ensure that you are standing
firmly and only use the chain saw when
you are standing on stable, firm and level
ground. A slippery subsurface or instable
standing area such as on a ladder can
cause you to lose your balance or lose
control over the chain saw.
• Do not stretch your arms too far forwards.
• Never work on ladders, on trees or in
other positions in which you cannot stand
safely.
• Take care when walking backwards.
Danger of stumbling!
• Always saw at a high chain speed.
• Do not saw any wood which is under ten-
sion.
• Do not work alone! Ensure that you have
an aural, visual or other connection with
another person who is in a position to
administer first aid in emergency situa-
tions.
• When putting the device down, the motor
must always be switched off!
• With each change of location, switch the
motor off and activate the chain brake.
The device may only be carried with the
saw rail facing towards the back and a
protective cover on.
• Protect the device against hard shocks!
Do not let it fall! If the device has been
subjected to shocks, check immediately
whether fuel is leaking (danger of fire and
explosion!).
• Keep the hot motor of the device away
from everything which is flammable, e.g.
dry grass, plastics.
• Only use the prescribed fuel-oil mixture
(►Approved fuels– p.21).
GB
temp.book Seite 9 Donnerstag, 5. November 2015 8:59 08
10
• Symbols appearing on your product may
not be removed or covered. Information
on the product that are no longer legible
must be replaced immediately.
Personal protective equipment/sensible
clothing
When cutting, wear the following protective
equipment:
Avoid with your clothing that you get caught
on something:
• Wear only close-fitting clothing!
• Do not wear any jewellery!
• If you have long hair, wear a hair net!
Residual risks
Even when using correctly, there is still a ele-
ment of residual risk that cannot be
excluded.
• Contact with the unprotected saw chain
(injury by cutting)
• Expulsion of parts of the saw chain
• Expulsion of parts of the cut items
• Damage to hearing
• Breathing in of particles from cut items
• Contact with petrol/oil
For this reason, it is essential that this chain
saw is always used with the additional per-
sonal protective equipment as shown on the
machine and described in these operating
instructions. It is also necessary to observer
the safety notes.
Your device at a glance
►P.3, item1
1. Hand guard (trigger for chain brake)
2. Handle
3. Cover for air filter and spark plug
4. Choke handle
5. Handle
6. Throttle
7. Ignition switch
8. Tank cover (for fuel-oil mixture)
9. Pull-starter
10. Tank cover (for saw chain oil)
11. Saw rail
12. Saw chain
13. Throttle block
14. Decompression valve
15. Exhaust
16. Protective cover
17. Chain tensioning screw
18. Fastening nuts (for saw rail)
19. Chain wheel guard
20. Fuel pump
21. Rear hand guard
Scope of delivery
• Instructions for use
• Chain saw
• Protective cover for saw rail
• Tool set
Assembly
Be careful when handling the de-
vice! Observe all safety instruc-
tions in the instructions for use!
Read and observe the operating
instructions before commission-
ing.
Risk of rebound!
Always hold the device firmly in
both hands.
Head protection: safety helmet
with visor
Ear protection: earplugs/ear muffs
according to DINEN 352-1
Eye protection: wrap-around gog-
gles/protective visor on the hel-
met
Foot protection: safety shoes with
gripping soles, steel caps and leg
protection
Hand protection: work gloves of
leather
Clothing: safety overalls (cut-
proof)
Safety jacket (cut-proof)
GB
temp.book Seite 10 Donnerstag, 5. November 2015 8:59 08
Autres manuels pour BKS-45/45MM
1
Ce manuel convient aux modèles suivants
1
Table des matières
Langues :
Autres manuels Lux Tools Tronçonneuse
