Kioti CK25 Manuel utilisateur
Congratulations, and welcome to the fabulous world of KIOTI CK25/30/35 ownership, where serious work is
made fun again!
This versatile tractor is a culmination of the entire tractor and diesel knowledge gained by the Daedong Indus-
trial Co.,LTD over the years since 1947 and has been designed with the finest materials and under rigid quality
control standards set forth by the KIOTI Engineering Department.
Knowledge of tractor operation is essential for many years of dependable service and reliability. To help new
owner's familiarize themselves with the KIOTI CK25/30/35 it is the policy of KIOTI tractor to provide an owner's
manual which includes helpful information about tractor safety, operation and maintenance. If the information
you seek is not found in this manual, your KIOTI tractor dealer will be happy to help you.
Please feel free to contact DAEDONG IND. CO.,LTD / DAEDONG-USA, INC. with your questions/concerns.
FOREWORD
This manual includes information titled as WARNING, CAUTION, IMPORTANT
and NOTE. These titles indicate the following:
SAFETY AND VEHICLE DAMAGE WARNING
NOTE
This indicates that interesting or helpful information is being
provided.
CAUTION
!!
!!
!This indicates that a condition may result in damage to your
vehicle or its equipment if the caution is not heeded. Follow the
advice provided with the caution.
WARNING
This indicates that a condition may result in harm, serious injury
or death to you or other persons if the warning is not heeded.
Follow the advice provided with the warning.
!!
!!
!
This mark indicates emphasis on notable characteristics of work-
ing procedures, and information about technology for easier
operation.
IMPORTANT
ABBREVIATION LIST
ABBREVIATIONS
4WD
API
ASAE
ASTM
fpm
Hi-Lo
HST
m/s
PTO
RH/LH
ROPS
m-1 (rpm)
S-1 (r/s)
SAE
SMV
DEFINITIONS
Four Wheel Drive
American Petroleum Institute
American Society of Agricultural Engineers, USA
American Society of Testing and Materials, USA
Feet Per Minute
High Speed-Low Speed
Hydrostatic Transmission
Meters Per Second
Power Take Off
Right-hand and Left-hand sides are determined by facing in the direction of forward travel
Roll-Over Protective Structures
Revolutions Per Minute
Revolutions Per Second
Society of Automotive Engineers, USA
Slow Moving Vehicle
Various universal symbols have been used on the instruments and controls of your KIOTI tractor. Below is a list
of the universal symbols and their meanings.
UNIVERSAL SYMBOLS
Fuel-Level
Engine Coolant-Temperature
Parking Brake
Battery Charging Condition
Engine Oil-Pressure
Turn Signal
Power Take-Off Clutch Con-
trol-Off Position
Power Take-Off Clutch Control-
ON Position
Differential Lock
Position Control-Lowered Position
Hazard Warning Lights
Headlight-Low Beam
Headlight-High Beam
Four-Wheel Drive-ON
Fast
Slow
High Range
Middle Range
Low Range
Neutral Position
Coolant
Preheat
SAFETY PRECAUTIONS .............................................
SERVICING OF TRACTOR .........................................
SPECIFICATIONS .........................................................
DESCRIPTION OF OPERATING SYSTEM ..............
OPERATION...................................................................
THREE-POINT HITCH & DRAWBAR........................
HYDRAULIC UNIT ........................................................
TIRES, TREAD AND BALLAST .................................
MAINTENANCE .............................................................
PERIODIC SERVICE ....................................................
STORAGE.......................................................................
TROUBLESHOOTING ..................................................
OPTIONS ........................................................................
INDEX ..............................................................................
APPENDIX ......................................................................
TABLE OF CONTENTS
SECTION
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1
BEFORE OPERATING THE TRACTOR .................... 1-2
OPERATING THE TRACTOR .................................... 1-5
DRIVING THE TRACTOR ........................................... 1-8
PARKING THE TRACTOR ......................................... 1-9
OPERATING THE PTO ............................................. 1-10
USING 3-POINT HITCH ............................................. 1-10
SERVICING THE TRACTOR .................................... 1-11
TRACTOR SAFETY LABELS ................................... 1-14
SAFETY PRECAUTIONS
CK25/30/351-2
A careful operator is the best operator.
Most accidents can be avoided by ob-
serving certain precautions. To help pre-
vent accidents, use these safety
precautions, and pay attention to the
job at hand. If you can prevent an
accident, your time will have been well
spent.
BEFORE OPERATING THE
TRACTOR
5. Keep safety decals clean of dirt and
debris.
6. Watch where you are going at all
times so that you are able to avoid
obstacles that can cause injury or
damage to your tractor.
7. When starting the tractor make sure
your path is clear of people to avoid
accidents caused by sudden
movements.
8. Before making reverse movements
with your tractor, you should always
check to see that the path is clear.
1. It is recommended that you read and
understand this entire manual before
operation of your new tractor. Fail-
ure to do so could result in accidents
or injury.
2. Only persons who are properly
trained should be allowed to operate
the tractor.
3. Read and follow all warning labels
and decals affixed to the tractor.
4. Replace any missing or damaged
decals as soon as it is practical. A
list of decals is shown on page1-
14~16.
704O101C 704O102C
1-3SAFETY PRECAUTIONS
16. All persons using the tractor should
have knowledge of its proper op-
eration and should read this manual
carefully.
17. Never get off the tractor without
setting the parking brake, lower-
ing the implement to the ground
and shutting of the tractor.
18. No alterations should be made to
your KIOTI tractor.
12. Never start the engine while stand-
ing on the ground.
13. Only the operator should ride on the
tractor unless a passenger seat is
installed. Keep bystanders away
from the tractor while in operation.
14. When getting on and off the tractor,
handholds and step plates should
always be used. This will help to
prevent accidental slips trips and
falls.
15. Be sure to scrape off mud or soil
from your shoes before mounting
the tractor.
704O103C 704O104C 704O105C
9. Never operate this tractor or any
other agricultural equipment while
under the influence of alcohol,
drugs or while fatigued.
10. While working in cooperation with
other tractors always communicate
your intentions.
11. Do not start your tractor by short-
ing across the starter.
CK25/30/351-4
A ROPS should never be modified by
welding, grinding or cutting, as this can
weaken the ROPS structure. If any
components of the ROPS unit is
damaged, it must be replaced.
If the ROPS unit is removed or loos-
ened for any reason, the parts should
be fitted back to their original positions
and all bolts should be properly torqued.
21. Extra caution should be taken when
driving tractors with narrow tread
widths. For added stability you
should adjust your rear wheel tread
width, see page 8-3.
19. Before starting your tractor you
should depress the clutch and
make sure that all shift levers are
in the neutral position and parking
brake is applied.
20. For your safety ROPS with a seat
belt is recommended for all
applications.
(1) Tread
704O106C 704O107C
zz
zz
zAlways use seat belt when the trac-
tor is equipped with a ROPS. Never
use the seat belt when tractor is
not equipped with a ROPS.
NOTE
1-5SAFETY PRECAUTIONS
1. Avoid accidental contact with gear
shift levers while the engine is
running. Unexpected tractor move-
ments can result in bodily injury.
2. Do not park your tractor on a steep
incline, and remember to shut off the
engine and PTO before dismount-
ing the tractor.
OPERATING THE TRACTOR
3. Do not operate your tractor in an en-
closed building without the proper
ventilation. Exhaust fumes contain
carbon monoxide and may cause
series injury or death.
704O109C
704O108C 704O110C
Autres manuels pour CK25
1
Ce manuel convient aux modèles suivants
3
Table des matières
Autres manuels Kioti Tracteur
Kioti
Kioti KL135 Manuel utilisateur
Kioti
Kioti LX500L Manuel utilisateur
Kioti
Kioti CK22 Manuel utilisateur
Kioti
Kioti DK451 Manuel utilisateur
Kioti
Kioti NX4510 Manuel utilisateur
Kioti
Kioti DK Series Manuel utilisateur
Kioti
Kioti KL701 Manuel utilisateur
Kioti
Kioti DK65 Manuel utilisateur
Kioti
Kioti DK4210(C)HSE Manuel utilisateur
Kioti
Kioti DK35SE Manuel utilisateur
Kioti
Kioti DK50 Manuel utilisateur
Kioti
Kioti DK6010 Manuel utilisateur
Kioti
Kioti KL155 Manuel utilisateur
Kioti
Kioti DK6010 Manuel utilisateur
Kioti
Kioti RX6030 Manuel utilisateur
Kioti
Kioti CH20 Manuel d'instructions
Kioti
Kioti US Manuel utilisateur
Kioti
Kioti CS2220H Manuel utilisateur
Kioti
Kioti LK30 Manuel utilisateur
Kioti
Kioti CK25 Manuel utilisateur
