Invacare Pegasus Manuel utilisateur
Invacare® Pegasus
SERVICE MANUAL
These instructions contain information about:
testing work
repair work
Edition:11.04.08
NB: Limited models available in Australia and New Zealand
2
3
Invacare Australia
1 Lenton Place (PO Box 5002)
North Rocks NSW 2151
Australia
+61 - 1800 460 460
Fax: +61 - 2- 8839 5311
@: sales@invacare.com.au
WWW: www.invacare.com.au
Invacare New Zealand
4 Westfield Place (PO Box 62-124)
Mt Wellington Auckland
New Zealand
+64 - 0508 468 222
Fax: +64 - 0508 807 788
WWW: www.invacare.co.nz
4
5
Table of Contents
Chapter Page
1INTRODUCTION 7
1.1 General information 7
1.2 Notes on transport 7
1.3 Important symbols in this manual 7
2SAFETY AND ASSEMBLY INSTRUCTIONS 9
2.1 Before any inspection or repair work 9
2.2 General safety information and notes on assembly / disassembly 9
3TIGHTENING TORQUES 11
4SERVICE PLAN (1X ANNUALLY) 12
5OPERATIONAL FAULTS 14
5.1 Operational faults 14
5.1.1 Drive fault diagnosis 14
5.2 Error Codes and Diagnostic Codes 15
6REPAIR WORK 17
6.1 General warning information on installation work 17
6.2 Replacing the drive motor 17
6.3 Replacing wheel suspension 20
6.4 Replacing shock absorber 22
6.5 Replacing front axle 24
6.6 Replacing steering column/fork 3-wheel 25
6.7 Replacing brakes 28
6.8 Replacing brake cable 30
6.9 Replacing steering linkage/steering rod 31
6
6.10 Replacing operating console 33
6.11 Replacing bend speed reducer. 35
6.12 Replacing the potentiometer 37
6.13 Replacing front headlight (lamp) 39
6.14 Replacing the front direction indicators 41
6.15 Replacing centre brake light 42
6.16 Replacing rear lights/direction indicators 44
6.17 Replacing the electronics module 46
6.18 Updating software 49
7
1 Introduction
1.1 General information
• All maintenance and overhaul work must be carried out in accordance with these repair
instructions.
• Please observe all safety instructions.
• Information about operation or about general maintenance and care work should be taken
from the electric vehicle Operating Manual.
• You can find information about ordering spare parts in the spare parts catalogue.
• Use only genuine Invacare® spare parts. Using parts from any other source will void the
warranty!
• We reserve the right to make any alterations on the grounds of technical improvements.
• The electric vehicle may only be maintained and overhauled by qualified personnel.
• The minimum requirement for service technicians is relevant training, such as in the cycle or
orthopaedic mechanics fields, or suitably long-term job experience.
- Experience and knowledge of electrical measuring devices (Multimeter)
is also a requirement.
- Special Invacare training sessions are recommended.
• Alterations to the electric vehicle which occur as a result of incorrectly or improperly executed
maintenance or overhaul work lead to the exclusion of all liability on the part of INVACARE.
• If you have any problems or questions please contact INVACARE SERVICE.
1.2 Notes on transport
• If the electric vehicle has to be shipped back to the manufacturer for major repairs, you should
always use the original packaging for transport.
• You should also include as accurate a fault description as possible.
1.3 Important symbols in this manual
WARNING!
This symbol warns you of danger!
• Always follow these instructions to avoid injury to the user or damage to the product!
EXPLOSION HAZARD!
This symbol warns you of an explosion hazard, an example of which can be caused by
excessive tyre pressure in a pneumatic tyre!
• Always follow the instructions to avoid injury to the user or damage to the product!
BURN HAZARD!
This symbol warns you of burns due, for example, to leaking battery acid!
• Always follow the instructions to avoid injury to the user or damage to the product!
8
NOTE:
This symbol identifies general information which is intended to simplify working with your product
and which refers to special functions.
Requirements:
• This symbol identifies a list of various tools, components and items which you will need in
order to carry out certain work.
9
2 Safety and assembly instructions
These safety instructions are intended to prevent accidents during work and it is imperative that
they are observed.
2.1 Before any inspection or repair work
• Read and observe this repair manual and the associated operating manual!
• Observe the minimum requirements for carrying out the work (see chapter entitled "General
information”)!
2.2 General safety information and notes on assembly / disassembly
Danger of injury by crushing!
• Please note the heavy weight of some components. This applies especially to removal of
drive units and batteries!
• Prop up the lifted electric vehicle with appropriate supports before starting the disassembly or
assembly!
Danger of fire and burns due to electrical short-circuit!
• The electric vehicle must be switched off before removal of voltage-carrying components! To
do this, disconnect the batteries!
• When making measurements on voltage-carrying components, avoid short-circuiting the
contacts. Danger of fire and combustion!
Danger of injury and damage to the vehicle can result from incorrect or incomplete
maintenance!
• Only ever use tools which are undamaged in good condition!
• Some moving parts have Teflon bushings! These parts must never be lubricated with grease!
• Never use standard nuts instead of self-locking nuts!
• Always use correctly dimensioned washers or spacers!
• Cable binders which have been cut off during disassembly should be replaced with new ones
during reassembly!
• After completing maintenance work and before operating the electric vehicle, make sure all
fixations are correctly secured! Check all parts for correct interlocking1
• Only operate the electric vehicle with correct tyre pressure (see Technical Specifications)!
• Check electrical components for correct functioning, incorrect polarity of cables can result in
damage to the electronics!
• As a last check, always carry out a test-drive!
Notes
Mark all current settings for the electric vehicle (seat, armrests, backrest etc.), and the cable
connecting plugs associated, before any removals. This makes reassembly easier.
All plugs are fitted with mechanical safety devices which prevent release of the connecting plugs
during operation. To release the connecting plugs the safety devices must be pressed in. When
reassembling, ensure that these safety devices are correctly engaged.
10
WARNING: Any alteration to the drive programme can influence vehicle handling and the
tipping stability of the electric vehicle!
• Alterations to the drive programme may only be carried out by trained Invacare® dealers!
• Invacare® supplies all electric vehicles from the factory with a standard drive programme.
Invacare® can only assume a warranty for the safe vehicle handling of the electric vehicle –
in particular tipping stability - for this standard drive programme!
Autres manuels pour Pegasus
2
Ce manuel convient aux modèles suivants
1
Table des matières
Autres manuels Invacare Scooter
Invacare
Invacare Auriga Manuel utilisateur
Invacare
Invacare Delta II Manuel utilisateur
Invacare
Invacare Spectra Blitz Manuel utilisateur
Invacare
Invacare Lynx SX3P Mode d’emploi
Invacare
Invacare Leo Manuel utilisateur
Invacare
Invacare Comet Series Manuel utilisateur
Invacare
Invacare Comet Mode d’emploi
Invacare
Invacare Leo Manuel utilisateur
Invacare
Invacare Lynx L-4 Mode d’emploi
Invacare
Invacare HMV Highly 300 Manuel
Invacare
Invacare Comet Manuel de l'installateur
Invacare
Invacare Zoom-3 Manuel utilisateur
Invacare
Invacare orion Manuel utilisateur
Invacare
Invacare Leo Manuel utilisateur
Invacare
Invacare Comet Manuel utilisateur
Invacare
Invacare Colibri Manuel utilisateur
Invacare
Invacare Leo Manuel utilisateur
Invacare
Invacare Cetus Manuel utilisateur
Invacare
Invacare Cetus Manuel utilisateur
Invacare
Invacare Comet Manuel utilisateur
Manuels Scooter populaires d'autres marques
First Choice Mobility
First Choice Mobility Roma Medical Corella S741 Manuel utilisateur
Carrera
Carrera impel Manuel utilisateur
Afikim
Afikim Superlight SL-3 Manuel utilisateur
CareCo
CareCo ZOOM Manuel utilisateur
Douglas
Douglas Vespa G.S. Manuel utilisateur
Gazelle
Gazelle with BOSCH System Manuel utilisateur