IAE CIRCONOMY Guide rapide

CIRCONOMY

ASSEMBLY & MAINTENANCE

MANUAL

-22 QUEENS SQUARE, HODDLESDEN, DARWEN, LANCASHIRE. BB3 3NQ

Tel: + 44 (0)1254 703212 Fax: +44 (0)1254 707407 WEB: www.multihog.co.uk

BF J000 0007 05 V1.2 SEP 2015

MOSSFIELD ROAD, ADDERLEY GREEN, STOKE ON TRENT, STAFFORDSHIRE. ST3 5BW

TEL: 01782 339320 FAX:01782 339321 WEB: www.iae.co.uk

General Dimensions

Safety

Stages of the installaon may require the use of personal protecon

equipment.

When working at heights refer to HSE guidance.

Fig 1

Ground Fixing Detail

 It is the responsibility of the installer to ensure that

the foundaons are suitable for the ground

condions.

 The base plate supplied with the Circonomy shelter

is drilled with Ø19 holes.

 The installer should ensure that the ground xings

are sucient to secure the Circonomy shelter to

the foundaons.

Fig 3

Fig 2

Frame Assembly

The legs are supplied undrilled. Do not drill

unl frame is built & level.

Levelling should be done before sheets are

xed.

Bolt legs to fully assembled, levelled frame

using M12 x 70mm socket buon head

screws.

Fit the top and the base

purlins to the side panels

using M10 x 70 socket dome

head screws.

Bolt the centre trimmer to the

top and base purlins using

M10 x 70 socket dome head

screws.

Please take care when

posioning the centre trimmer

as it is handed.

The sequence of images is not representave of assembly order, use as a

guide for bolt selecon only.

Fig 5

Fig 6

Fig 4

Frame Assembly

Before ghtening all

bolts, ensure that the

framework is square.

Fit the intermediate purlins

between the end panels and the

centre trimmer.

Use M10 x 70mm socket dome

head screws to bolt to the end

panels.

Use M10 x 80mm socket buon

head screws to bolt through the

centre trimmer.

Fit plasc caps to the end panels.

Fig 10

Fig 7

Fig 8

Fig 9

Plasc Installaon

Before ng the sheet, IAE advise that the mid purlins are pre drilled using a drill screw. Drill

unl it starts to thread then remove and clean to remove all swarf. See Fig 11.

·Make sure to allow a 10mm gap between the two sheets.

·Pre drill ø10mm holes in sheet rst to match purlins.

·Fix the sheet to the mid purlins using 5.5x32mm drill screws.

Drill mid purlins to

accept.

Fig 11

Plasc Installaon

Fit 50x3mm cover strips using 5.5x32 drill screws.

When ng these strips it is important that you work from one end.

Fig 12

Apply 19mm wide tape to the strip before ng.

Cycle Racks

Ensure sucient xings are used to secure the cycle rack to the ground.

The holes to bolt the cycle rack to the ground are Ø13.5mm.

Cycle racks are supplied as an oponal extra.

Installaon will vary depending on the opon purchased.

NOTE: The hoops must be bolted to the rails before the rails are bolted to the

ground.

Fig 14

Fig 13

Maintenance

Roune visual inspecon

Cycle storage equipment may be subject to heavy use or vandalism, weekly inspecon of this

type can be necessary.

Examples of frame inspecon points are:

Cleanliness.

Rigidity of cycle hoops.

Tightness of all xings.

Signs of corrosion or wear.

Missing parts.

Structural integrity.

Maintenance of plasc sheeng:

Wipe down regularly with warm soapy water using a non-abrasive cloth.

Check for surface damage.

Light scus and scratches can be repaired by dusng with hot air gun or pencil torch ame.

Cracked or severely damaged panels should be removed and replaced.

Exploded Detail

Fig 15

Table des matières

Autres manuels IAE Abri

IAE

IAE LONGTON SMOKING SHELTER Guide rapide

IAE

IAE SHELTER Guide rapide

IAE

IAE FLAT ROOF SMOKING SHELTER Guide rapide

Manuels Abri populaires d'autres marques

Tempo Fitness

Tempo Fitness S11 Manuel utilisateur

Tuindeco

Tuindeco 42.7906 Manuel utilisateur

No Butts Bin

No Butts Bin SR1605 Manuel utilisateur

TMG

TMG TMG-DT5040CG Manuel utilisateur

TMG

TMG TMG-DT3063-PRO Manuel utilisateur

EAGLE CLAW

EAGLE CLAW Shappell DX4000 Manuel utilisateur

Kampa

Kampa Poled Shelter 300 Manuel utilisateur

Harnois

Harnois TA-R Manuel utilisateur

Shelters4Less

Shelters4Less SR1551 Manuel utilisateur

TMG

TMG TMG-DT50FW8 Manuel utilisateur

Vikre Handel AS

Vikre Handel AS JIT-1216 Manuel utilisateur

VARNA buildings

VARNA buildings C2020H Manuel utilisateur

Storage Canopy

Storage Canopy C3340R Manuel utilisateur

Frabill

Frabill ICE HUNTER 195 Manuel utilisateur

Shelters4Less

Shelters4Less SR1588 Manuel utilisateur

Sealey

Sealey Power Products GSS150819SD Manuel utilisateur

Crivit

Crivit 104155 Manuel utilisateur

No Butts Bin

No Butts Bin SR1558-F Manuel utilisateur