Hussmann IMPACT Elite E2SP Manuel utilisateur

P/N 0453525B

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

Note: Changed items have been underlined.

E2SP

Data Sheet Set

P/N 0453525B

NSF®Certified

October 2005

Item Part # Description Wiring Item #

FAN ASSEMBLIES AND THERMOSTATS

A. 12W Fan Assembly (1)

0047000 Fan Motor, Evaporator

0124150 Fan Blade,

embossing toward motor

12W Energy Efficient Fan Assembly (1)

0441749 Fan Motor, Evaporator

0124150 Fan Blade,

embossing toward motor

B. 0458883 Fan, Optional Refrigerated (2)

Rear Storage

C. 0404551 Cavity Fan, Ambient (3)

D. 0411744 Standard Non-adjustable (4)

Defrost Thermostat

Item Part # Description Wiring Item #

E. 0353949 Optional Adjustable (5)

Refrigeration Thermostat

LAMPS AND BALLASTS

F. 0466234 Ballast, Electronic

2 lamps (6)

F. 0466235 Ballast, Electronic

3 lamps (6)

F. 0466236 Ballast, Electronic

4 lamps (6)

G. Fluorescent Lamp (7)

Replace with like fixtures

SHOWN WITH

OPTIONAL

REAR STORAGE

We reserve the right to change or revise specifications

and product design in connection with any feature of

our products. Such changes do not entitle the buyer to

corresponding changes, improvements, additions or

replacements for equipment previously sold or shipped.

2 of 10 E2SP Data Sheet

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

E2SP

Meat, Delicatessen

Precut & Packaged

Produce

Standard

Configuration

(without Optional

Rear Storage)

Front to back dimensions do not include optional rear storage dimension. 4 ft 6 ft 8 ft 12 ft

General

(A)

Case Length (without ends or partitions) 48 1/8(1222) 72 1/8(1832) 96 1/4(2445) 144 3/8(3667)

Maximum O/S dimension back to front (with bumper) 47 (1194) 47 (1194) 47 (1194) 47 (1194)

Back of case to front of front panel 35 (889) 35 (889) 35 (889) 35 (889)

Back of case to O/S edge of front skid rail 29 3/4 (756) 29 3/4 (756) 29 3/4 (756) 29 3/4 (756)

Width of skid rail 4 1/2 (114) 4 1/2 (114) 4 1/2 (114) 4 1/2 (114)

RH end of case to outside edge of external support 1 3/8(35) 1 3/8(35) 1 3/8(35) 1 3/8(35)

Distance between edges of

external support and center support NA 28 1/2 (724) 40 1/2 (1029) 40 1/2 (1029)

Distance between edges of center supports NA NA NA 44 (1118)

Distance between edges of external supports 37 (940) NA NA NA

Stub-up area between front skid rail and front panel 5 3/4(146) 5 3/4(146) 5 3/4 (146) 5 3/4 (146)

Electrical Service (Electrical Field Wiring connection point)

(B)

Length of electrical raceway 36 1/8 (918) 26 5/8 (676) 36 1/8 (918) 36 1/8 (918)

RH End of case to center of farthest knockout 11 3/8(289) 11 3/8(289) 11 3/8(289) 11 3/8(289)

Back of case to center of end knockout 6 3/8 (162) 6 3/8 (162) 6 3/8 (162) 6 3/8 (162)

(C)

RH End of case to RH end of raceway 6 1/8 (156) 6 1/8 (156) 6 1/8 (156) 6 1/8 (156)

Waste Outlet

(D)

RH End of case to the center of waste outlet 24 1/4(616) 24 1/4(616) 24 1/2 (622) 72 1/4 (1835)

(E)

LH End of case to the center of waste outlet 23 7/8(606) 47 7/8 (1216) 72 3/4 (1848) 72 1/8 (1832)

Back O/S of case to center of waste outlet 28 1/8 (714) 28 1/8 (714) 28 1/8 (714) 28 1/8 (714)

Water Seal

Edge of water seal to center of waste outlet 4 (102) 4 (102) 4 (102) 4 (102)

Outside diameter of the drip pipe 1 1/2 (38) 1 1/2 (38) 1 1/2 (38) 1 1/2 (38)

NOTE: Water seal outlet must clear front skid rail;

water seal rotation in forward direction only due to low base.

Refrigeration Outlet

Back of case to center of refrigeration outlet 31 1/4 (794) 31 1/4 (794) 31 1/4 (794) 31 1/4 (794)

RH end of case to center of refrigeration outlet 8 3/8 (213) 8 3/8 (213) 8 3/8 (213) 8 3/8 (213)

Engineering

Plan Views

Dimensions shown as inches and (mm).

10-2005

12 Ft Case 28 1/8

(714) 31 1/4

(794)

(889)

83/8 (213)

Front

Waste Outlet Water Seal

Electrical

63/8

(162)

(1194)

REFRIGERATION DATA

Note: This data is based on store temperature and

humidity that does not exceed 75 (°F) and 55% R.H.

E2SP

Meat Deli

Discharge Air (°F) 25 28

Evaporator (°F) 18 21

Unit Sizing (°F) 16 19

Btu/hr/ft* †E2SP

Parallel 900 890

Conventional 1000 980

*For all refrigeration equipment other than

Hussmann, use conventional Btu values.

†

with refrigerated rear storage, add 300 Btu/hr/ft

DEFROST DATA

E2SP

Frequency (hr) 6

Defrost Water 8 lb/ft/day

(± 15% based on case configuration and product

loading).

OFFTIME E2SP

Temp Term (°F) 48

Failsafe (minutes) 40

ELECTRIC OR GAS Not Recommended

Standard Defrost Thermostat

Close on rise: close 48°F – open 33°F

CONVENTIONAL CONTROLS

Low Pressure Backup Control CI/CO**

E2SP Meat Deli

Temp (°F) 11 / 6 14 / 4

Indoor Unit Only, Pressure Defrost

Termination (Temp °F)** 48°F

**Use a Temperature Pressure Chart to determine

PSIG conversions.

PHYSICAL DATA

Drip Pipe (in.) 1 1/2

Liquid Line (in.) 3/8

Suction Line (in.) 7/8

Estimated Charge (lb)*** E2SP

4 ft 0.9

6 ft 1.8

8 ft 1.9

12 ft 2.9

***This is an average for all refrigerant types actual

refrigerant charge may vary by approximately half a

pound.

Length Added to Lineup by Each

End or Insulated Partition 1 in.

(889)

9 3/4 (248)

4 3/4

(121)

(305)

19 1/8

(486)

(787)

Refrigeration

Outlet

E2SP

FAN

31 1/4

(794)

28 1/8

(714)

(508)

Standard Sneeze Guard 53 3/4

(1365)

(1194)

(305)

(559)

40 1/4

(1022)

Impact Elite E2SP

Meat, Delicatessen

Precut & Packaged Produce

Elite Specialty Merchandiser Multi-deck, Prep Top, 2 Display Levels

Dimensions shown as in. & (mm).

See Page 9 for

shelf arrangement.

3 of 10P/N 0453525B HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

E2SP

Meat, Delicatessen

Precut & Packaged

Produce

with Optional

Rear Storage —

Refrigerated or

Nonrefrigerated

4 of 10 E2SP Data Sheet

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

Engineering

Plan Views

Dimensions shown as inches and (mm).

10-2005

Ballast

Tray

Optional

Unrefrigerated

Rear Storage

(305)

Optional

Refrigerated

Rear Storage

(406)

8 Ft Case 28 1/8

(714)

(889)

83/8 (213)

Front

Waste Outlet Water Seal

31 1/4

(794) 47

(1194)

(1600)

Front to back dimensions do not include optional rear storage dimension. 4 ft 6 ft 8 ft 12 ft

General

(A)

Case Length (without ends or partitions) 48 1/8(1222) 72 1/8(1832) 96 1/4(2445) 144 3/83667)

Maximum O/S dimension back to front (with bumper) 47 (1194) 47 (1194) 47 (1194) 47 (1194)

Back of case to front of front panel 35 (889) 35 (889) 35 (889) 35 (889)

Back of case to O/S edge of front skid rail 29 3/4 (756) 29 3/4 (756) 29 3/4 (756) 29 3/4 (756)

Width of skid rail 4 1/2 (114) 4 1/2 (114) 4 1/2 (114) 4 1/2 (114)

RH end of case to outside edge of external support 1 3/8(35) 1 3/8(35) 1 3/8(35) 1 3/8(35)

Distance between edges of

external support and center support NA 28 1/2 (724) 40 1/2 (1029) 40 1/2 (1029)

Distance between edges of center supports NA NA NA 44 (1118)

Distance between edges of external supports 37 (940) NA NA NA

Stub-up area between front skid rail and front panel 5 3/4(146) 5 3/4(146) 5 3/4 (146) 5 3/4(146)

Electrical Service (Electrical Field Wiring connection point)

(B)

RH End of case to LH end of connection box 42 1/8(1070) 42 1/8(1070) 42 1/8(1070) 91 3/8(2321)

(E)

Back of storage to NONREFRIGERATED STORAGE

CONNECTION BOX, center of knockout 7 (178) 7 (178) 7 (178) 7 (178)

(E)

Back of storage to REFRIGERATED STORAGE

CONNECTION BOX, center of knockout 11 (279) 11 (279) 11 (279) 11 (279)

Waste Outlet

(C)

RH End of case to the center of waste outlet 24 1/4(616) 24 1/4(616) 24 1/4(616) 24 1/4(616)

(D)

LH End of case to the center of waste outlet 23 7/8(606) 47 7/8 (1216) 72 3/4 (1848) 72 1/8 (1832)

Back O/S of case to center of waste outlet 28 1/8 (714) 28 1/8 (714) 28 1/8 (714) 28 1/8 (714)

Water Seal

Edge of water seal to center of waste outlet 4 (102) 4 (102) 4 (102) 4 (102)

Outside diameter of the drip pipe 1 1/2 (38) 1 1/2 (38) 1 1/2 (38) 1 1/2 (38)

NOTE: Water seal outlet must clear front skid rail;

water seal rotation in forward direction only due to low base.

Refrigeration Outlet

Back of case to center of refrigeration outlet 31 1/4 (794) 31 1/4 (794) 31 1/4 (794) 31 1/4 (794)

RH end of case to center of refrigeration outlet 8 3/8 (213) 8 3/8 (213) 8 3/8 (213) 8 3/8 (213)

REFRIGERATION DATA

Note: This data is based on store temperature and

humidity that does not exceed 75 (°F) and 55% R.H.

E2SP

Meat Deli

Discharge Air (°F) 25 28

Evaporator (°F) 18 21

Unit Sizing (°F) 16 19

Btu/hr/ft* †E2SP

Parallel 900 890

Conventional 1000 980

*For all refrigeration equipment other than

Hussmann, use conventional Btu values.

†

with refrigerated rear storage, add 300 Btu/hr/ft

DEFROST DATA

E2SP

Frequency (hr) 6

Defrost Water 8 lb/ft/day

(± 15% based on case configuration and product

loading).

OFFTIME E2SP

Temp Term (°F) 48

Failsafe (minutes) 40

ELECTRIC OR GAS Not Recommended

Standard Defrost Thermostat

Close on rise: close 48°F – open 33°F

CONVENTIONAL CONTROLS

Low Pressure Backup Control CI/CO**

E2SP Meat Deli

Temp (°F) 11 / 6 14 / 4

Indoor Unit Only, Pressure Defrost

Termination (Temp °F)** 48°F

**Use a Temperature Pressure Chart to determine

PSIG conversions.

PHYSICAL DATA

Drip Pipe (in.) 1 1/2

Liquid Line (in.) 3/8

Suction Line (in.) 7/8

Estimated Charge (lb)*** E2SP

4 ft 0.9

6 ft 1.8

8 ft 1.9

12 ft 2.9

***This is an average for all refrigerant types actual

refrigerant charge may vary by approximately half a

pound.

Length Added to Lineup by Each

End or Insulated Partition 1 in.

5 of 10

P/N 0453525B HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

Refrigeration

Outlet FAN

COIL

Electrical

Connection

Cavity & Fan

w/Refrigerated

Storage

w/ Non refrigerated

Storage

(305)

(559)

40 1/4

(1022)

(889)

9 3/4 (248)

(305)

19 1/8

(486)

(787)

E2SP

31 1/4

(794)

28 1/8

(714)

(508)

Standard Curved

Sneeze Guard

53 3/4

(1365)

(1194)

(1499)

4 3/4 (121)

(1600)

9 1/4

(235)

(914)

(406)

(305)

Impact Elite E2SP

Meat, Delicatessen

Precut & Packaged Produce

Elite Specialty Merchandiser Multi-deck, Prep Top, 2 Display Levels

Optional Rear Storage, Refrigerated or Non refrigerated

Dimensions shown as in. & (mm).

See Page 9 for

shelf arrangement.

Shown with curved sneeze guard

and optional refrigerated and

non-refrigerated rear storage.

6 of 10 E2SP Data Sheet

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

Impact Elite E2SP

Meat, Delicatessen

Precut & Packaged Produce

Electrical Data

4 ft 6 ft 8 ft 12 ft

Number of Fans — 12W 1223

Number of Fans — 12W (Export) 1223

(Export: 230V 50 hz shown)

Amperes Watts

Merchandiser 4 ft 6 ft 8 ft 12 ft 4 ft 6 ft 8 ft 12 ft

Fans

Standard (120V 60Hz) 0.70 1.40 1.40 2.10 55 110 110 165

Energy Efficient (120V 60 Hz) 0.38 0.76 0.76 1.14 25 50 50 75

Export (230V 50Hz) 0.38 0.76 0.76 1.14 57 114 114 171

Optional Rear Refrigerated Storage 0.8 1.6 1.6 3.2 96 192 192 384

Constant-on Cavity Ambient Air Fan 0.26 0.26 0.26 0.26 23 23 23 23

(Standard on Optional Refrigerated Rear Storage)

Cycling Anti-sweat Heaters NA

Minimum Circuit Ampacity

With Standard Fans (120V 60Hz) 0.90 1.60 1.60 2.30

With Rear Refrigerated Storage

(standard fans) 1.96 3.46 3.46 5.56

With Energy Efficient Fans (120V 60 Hz) 0.58 0.96 0.96 1.34

With Export Fans (230V 50Hz) 0.58 0.96 0.96 1.34

Maximum Over Current Protection 20 20 20 20

Export (230V 50Hz) 15 15 15 15

Electric Defrost Heaters (208V 1Ph) NA

Standard Lighting

1 Row Canopy 0.51 0.51 0.51 0.76 62 62 62 92

Optional Lighting

1 Row Rail Lights 0.51 0.51 0.51 0.76 62 62 62 92

1 Row Ledge Lights 0.51 0.51 0.51 0.76 62 62 62 92

Optional Shelf Lighting

1 Row of Shelves 0.51 0.51 0.51 0.76 62 62 62 92

2 Rows of Shelves 0.51 1.01 1.01 1.52 62 122 122 185

7 of 10P/N 0453525B HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

WARNING

All components must have mechanical ground, and the merchandiser must be grounded.

CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS

= 120V POWER = 120V NEUTRAL

Defrost

Termination

Thermostat

Refrigeration

Thermostat

Dark Blue

Condensing

Unit

}

Light Blue

1, 2 or 3 Fans

120V NEUTRAL

BROWN BAND

120V POWER

Fans 1

BROWN BAND

Optional Refrigerated Rear Storage,

1 or 2 Fans

120V NEUTRAL

BROWN BAND

120V POWER Fans 2

BROWN BAND

4 ft case has 1 Fan

6 ft case has 1 Fan

8 ft case has 2 Fans

12 ft case has 2 Fans

4 ft case has 1 Fan

6 ft case has 2 Fans

8 ft case has 2 Fans

12 ft case has 3 Fans

Cavity Fan, Ambient

120V NEUTRAL

BROWN BAND

120V POWER Fan 3

BROWN BAND

4 ft case has 1 Fan

6 ft case has 1 Fan

8 ft case has 1 Fan

12 ft case has 1 Fan

Fan Wiring

Offtime Defrost

8 of 10 E2SP Data Sheet

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

R = Red Y = Yellow G = Green BL = Blue B = Black W = White

= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND

CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS

WARNING

All components must have mechanical ground, and the merchandiser must be grounded.

Connector

777

Connector

Connector Connector

Optional Shelf Harness and Light Circuits for

One Row of Shelves

120 V

Power

BL G

BL BL G

Shelf Harness

Shelf Light Circuits

Connector

4 ft 6 ft & 8 ft 12 ft

RR BL BL

Shelf Lighting

9 of 10P/N 0453525B HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

120V NEUTRAL

ORANGE OR TAN BAND

Light

Switch

120V POWER

ORANGE OR TAN

BAND

RBL

Optional Lighting: 1 Row Ledge or 1 Row Rail

Light Circuits

Standard Lighting 1 Row Canopy

WARNING

All components must have mechanical ground, and the merchandiser must be grounded.

= 120V POWER = 120V NEUTRAL

R = Red Y = Yellow G = Green BL = Blue B = Black W = White

CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS

120V NEUTRAL

ORANGE OR TAN BAND

Light

Switch

120V POWER

ORANGE OR TAN

BAND

777

4 ft case has 1 Lamp

6 ft case has 2 Lamps

8 ft case has 2 Lamps

12 ft case has 3 Lamps

4 ft case has 1 Lamp

6 ft case has 2 Lamps

8 ft case has 2 Lamps

12 ft case has 3 Lamps

SHELF CONFIGURATION

This merchandiser is designed for two

shelves.

This illustration shows recommended

shelf depth and shelf angle for the two

locations.

It is critical to case performance that no

product, shelf or stop extend beyond the

load limit, as shown in this illustration.

This configuration supports the air

curtain and provides optimal case

performance.

Check with Hussmann engineering

before using a different configuration.

Load Limit

12 in.

10°

Recommended

Angle

Shelf

Size

18 in.

0°

Impact Elite E2SP

Meat, Delicatessen

Precut & Packaged Produce

10 of 10 E2SP Data Sheet

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.

Table des matières

Autres manuels Hussmann marchandiseur

Hussmann

Hussmann IMPACT D5RRI Manuel utilisateur

Hussmann

Hussmann RID Mode d'emploi

Hussmann

Hussmann LGH Mode d’emploi

Hussmann

Hussmann RI1 Manuel utilisateur

Hussmann

Hussmann ASC-L Mode d'emploi

Hussmann

Hussmann Freedom Line series Manuel utilisateur

Hussmann

Hussmann C6L-EP Manuel utilisateur

Hussmann

Hussmann C2NX-XE Mode d’emploi

Hussmann

Hussmann RGDC Mode d’emploi

Hussmann

Hussmann DM Manuel utilisateur

Hussmann

Hussmann D5-EP Manuel utilisateur

Hussmann

Hussmann IMPACT M1CIMP-4B Manuel utilisateur

Hussmann

Hussmann M3NX-GEP Mode d’emploi

Hussmann

Hussmann VR3-M-EP Instructions d'utilisation d'origine

Hussmann

Hussmann P4NX-EP Mode d’emploi

Hussmann

Hussmann IMPACT Elite E1 Manuel utilisateur

Hussmann

Hussmann IMPACT RL Manuel utilisateur

Hussmann

Hussmann ESBDS Mode d’emploi

Hussmann

Hussmann SMB Manuel utilisateur

Hussmann

Hussmann MicroSC ISMGG2DA-A Manuel utilisateur

Hussmann

Hussmann D5NX-LE Mode d’emploi

Hussmann

Hussmann IMPACT Elite E2V Manuel utilisateur

Hussmann

Hussmann Excel FWG Manuel utilisateur

Hussmann

Hussmann Elite Series Manuel utilisateur

Manuels marchandiseur populaires d'autres marques

FRIGOGLASS

FRIGOGLASS Flex 20 HC Manuel utilisateur

EPTA

EPTA COSTAN RHINO MULTI Manuel utilisateur

CASCO

CASCO Nano Cube Manuel utilisateur

True

True GDIM-26 Manuel utilisateur

Structural Concepts

Structural Concepts Oasis Mobile Series Instructions d'installation

Haussmann

Haussmann RL Manuel utilisateur

Howard McCray

Howard McCray R-CDS32E-4 Manuel utilisateur

EPTA

EPTA iarp Cool Emotions Delight Lite Manuel utilisateur

VALERA

VALERA BC 85 Manuel utilisateur

HL Display

HL Display 3eBin Manuel utilisateur

Dixie Narco

Dixie Narco DNCB 501E Manuel utilisateur

APW Wyott

APW Wyott Racer DMXD-30H Manuel utilisateur

Hoshizaki

Hoshizaki KD-90C Manuel utilisateur

Summit

Summit SCR1006 Manuel utilisateur

Delfield

Delfield Shelleyspeed SPM-28E Manuel utilisateur

EPTA

EPTA iarp Cool Emotions GLEE 40 Manuel utilisateur

Kysor/Warren

Kysor/Warren GranBering KW Mode d’emploi

Crane

Crane BevMAX Refresh 6 Media Manuel utilisateur