Grindmaster Cecilware Crathco CS-2E-16 Manuel utilisateur

Operator Manual

Grindmaster-Cecilware

4003 Collins Lane, Louisville, KY 40245 USA

Phone: 502.425.4776 Toll Free: 800.695.4500

Fax: 502.425.4664

Web: gmcw.com Email: info@gmcw.com

Safety Information........................2

Specifications.................................3

Installation and Set-Up.................4

Product Preparation & Use...........7

Daily Cleaning ...............................8

Troubleshooting..........................11

Basic Machine Parts ....................14

Thank you for purchasing this quality cold beverage dispenser. For your safety and the safety of

others, read all warnings and the operator’s manual before installing or using the product. Properly

instruct all operators. Keep training records. For future reference, record serial number here:

Table of Contents

Simplicity™Bubbler

Crathco®Cold Beverage Dispensers

Grindmaster-Cecilware provides the industry’s

BEST warranty. Visit gmcw.com for warranty

terms and conditions.

Model CS-2D-16

Model CS-2E-16

Printed in Thailand

0917 Form # CC-330-05

Part # 390-00003

(cULus certification applies only to

United States and Canada models.)

Model CS-3L-16

Activate your warranty now at

http://gmcw.com/warranty-registration

2 Crathco®Simplicity Bubbler

Lifting hazard. Single person lift could cause injury. Use assistance when moving or lifting.

Sharp edges can cause personal injury. Handle with care.

The appliance is not to be used by persons (including children 8 years and above) with reduced physical, sen-

sory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or

instruction. Be sure to provide supervision or instruction concerning use of the appliance in a safe way and

understand the hazards involved.

Children must be supervised to ensure they do not play with the appliance.

For safe and proper operation the appliance has to be placed in a stable horizontal position.

The appliance is only to be installed in locations where it can be overseen by trained personnel.

Safety Information

Observe machine voltage configuration. Do not apply improper voltage to machine or damage to machine will

occur.

Do not use extension cord.

Do not operate the appliance below 1.7°C (35°F) or above 40°C (104°F).

Clean and sanitize unit before first use.

NOTICE/ AVIS/ AVISO

The appliance is not intended for outdoor use.

Do not clean with a water jet or use in an area where a water jet may be used.

Cleaning and maintenance shall be made only by properly trained persons with supervision.

Important Safety Information

This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages

that follow this symbol to avoid possible injury or death.

For your safety and the safety of others, read all warnings and the operator manual before installing or using

the product.

DANGER: This term warns the user of imminent hazard that will result in serious injury or death.

WARNING: This term refers to a potential hazard or unsafe practice, which could result in serious injury or death.

CAUTION: This term refers to a potential hazard or unsafe practice, which could result in minor or moderate

injury.

NOTICE: This term refers to information that needs special attention or must be fully understood.

CAUTION/ ATTENTION/

ATENCIÓN

WARNING/ AVERTISSEMENT/ ADVERTENCIA

Simplicity Bubbler Crathco®3

Specifications

Northern America

Export

Model Description Dimensions (H x W x D) Electrical Certifications/

Declarations

CS-2E-10 (2) 2.4 gallon (9L) bowls, 25.3” x 10.5” x 17.6” 100V / 50/60 HZ / 3.6A NSF

agitator model. 64 cm x 27 cm x 45 cm

CS-2E-10-S (2) 2.4 gallon (9L) bowls, 25.3” x 10.5” x 17.6” 100V / 50/60 HZ / 3.6A NSF

spray model. 64 cm x 27 cm x 45 cm

CS-2E-22 (2) 2.4 gallon (9L) bowls, 25.3” x 10.5” x 17.6” 230V / 50/60 HZ / 1.5A NSF, CE

agitator model. 64 cm x 27 cm x 45 cm

CS-2E-22-S (2) 2.4 gallon (9L) bowls, 25.3” x 10.5” x 17.6” 230V / 50/60 HZ / 1.5A NSF, CE

spray model. 64 cm x 27 cm x 45 cm

CS-4E-22 (4) 2.4 gallon (9L) bowls, 25.5” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

agitator model. 65 cm x 52 cm x 45 cm

CS-4E-22-S (4) 2.4 gallon (9L) bowls, 25.5” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

spray model. 65 cm x 52 cm x 45 cm

CS-1D-22 (1) 4.75 gallon (18L) bowl, 25.3” x 10.5” x 17.6” 230V / 50/60 HZ / 1.5A NSF, CE

agitator model. 64 cm x 27 cm x 45 cm

CS-1D-22-S (1) 4.75 gallon (18L) bowl, 25.3” x 10.5” x 17.6” 230V / 50/60 HZ / 1.5A NSF, CE

spray model. 64 cm x 27 cm x 45 cm

CS-2D-22 (2) 4.75 gallon (18L) bowls, 25.5” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

agitator model. 65 cm x 52 cm x 45 cm

CS-2D-22-S (2) 4.75 gallon (18L) bowls, 25.5” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

spray model. 65 cm x 52 cm x 45 cm

CS-3D-22 (1) 4.75 gallon (18L) bowl, 25.5” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

(2) 2.4 gallon (9L) bowls, 65 cm x 52 cm x 45 cm

agitator model.

CS-3D-22-S (1) 4.75 gallon (18L) bowl, 25.5” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

(2) 2.4 gallon (9L) bowls, 65 cm x 52 cm x 45 cm

spray model.

CS-3L-22 (3) 4.75 gallon (18L) bowls, 29.0” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

agitator model. 74 cm x 52 cm x 45 cm

CS-3L-22-S (3) 4.75 gallon (18L) bowls, 29.0” x 20.4” x 17.7” 230V / 50/60 HZ / 4A NSF, CE

spray model. 74 cm x 52 cm x 45 cm

Model Description Dimensions (H x W x D) Electrical Certifications

CS-2E-16 (2) 2.4 gallon (9L) bowls, 27.5” x 10.5” x 17.75” 120V / 60 Hz / 3.6A C-UL US, NSF

agitator model.

CS-2E-16-S (2) 2.4 gallon (9L) bowls, 27.5” x 10.5” x 17.75” 120V / 60 Hz / 3.6A C-UL US, NSF

spray model.

CS-4E-16 (4) 2.4 gallon (9L) bowls, 27.5” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

agitator model.

CS-4E-16-S (4) 2.4 gallon (9L) bowls, 27.5” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

spray model.

CS-1D-16 (1) 4.75 gallon (18L) bowl, 27.5” x 10.5” x 17.75” 120V / 60 Hz / 3.6A C-UL US, NSF

agitator model.

CS-1D-16-S (1) 4.75 gallon (18L) bowl, 27.5” x 10.5” x 17.75” 120V / 60 Hz / 3.6A C-UL US, NSF

spray model.

CS-2D-16 (2) 4.75 gallon (18L) bowls, 27.5” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

agitator model.

CS-2D-16-S (2) 4.75 gallon (18L) bowls, 27.5” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

spray model.

CS-3D-16 (1) 4.75 gallon (18L) bowl, 27.5” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

(2) 2.4 gallon (9L) bowls,

agitator model.

CS-3D-16-S (1) 4.75 gallon (18L) bowl, 27.5” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

(2) 2.4 gallon (9L) bowls,

spray model.

CS-3L-16 (3) 4.75 gallon (18L) bowls, 31.3” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

agitator model.

CS-3L-16-S (3) 4.75 gallon (18L) bowls, 31.3” x 20.5” x 17.75” 120V / 60 Hz / 8.5A C-UL US, NSF

spray model.

4 Crathco®Simplicity Bubbler

Installation and Set-Up

Place machine on counter with proper spacing.

• The appliance must be placed in a horizontal position.

• The appliance is suitable for indoor use only.

a. Place dispenser on

stable counter strong

enough to support

its weight.

b. Allow 5” (13 cm) on sides

and 6” (15 cm) on back

for proper ventilation.

c. Position machine away

from heat emitting

objects (i.e. ovens, grills,

refrigeration equipment).

Install power cord.

Do not use extension cord.

Failure to follow proper installation

guidelines can damage equipment

and void warranty.

Plug cord into power outlet.

Note proper voltage.

Observe machine voltage configuration.

Do not apply improper voltage to

machine or damage to machine will

occur.

1. This appliance is not intended for the use by persons (including children) with reduced physical, sensory, or

mental capabilities, or lack of experience and knowledge, unless they have been given supervision or

instruction concerning use of the appliance by person responsible for their safety.

2. Children should be supervised to ensure that they do not play with the appliance.

3. This appliance is only to be installed in locations where it can be overseen by trained personnel.

5”

(13 cm)

5”

(13 cm)

6”

(15 cm)

6” (15 cm) minimum

machine spacing from

wall

5” (13 cm) minimum

machine spacing from

wall or other machines

Recommended ambient temperature 75° F

(25° C).

Top View

Front View

CAUTION/ ATTENTION/

ATENCIÓN

Simplicity Bubbler Crathco®5

Installation - Agitator Function (Model CS-XX-YY)

1. 2.

5. 7.

9. 10.

Install mixing impeller.

Install bowl gasket.

Place o-ring on dispense valve

(check if nicked or twisted). Place in

bowl.

Install assembled bowl.

NOTICE:

Machine must be OFF.

Insert bowl lip underneath

of lock position on the back

of top tray.

Then, press down on the

front of the bowl until

you hear a click indicating

the bowl is locked proper-

ly in place.

Install handle. Flip out support bracket for

drip tray.

Place drip tray

cover on drip

tray.

Install drip tray.

Mix product in clean container.

Fill bowl with product.

Install bowl cover. Turn power “on”.

a. b.

CAUTION/ ATENCIÓN/

ATTENTION

Sharp edges can

cause personal injury. Handle

with care.

Replace axle if flange

thickness is less than

0.75mm

(0.03 inch)

thick.

Replace impeller if

bearing surface is

worn more than

0.5mm (0.02 inch).

Inspect for wear.

NOTICE/ AVIS/ AVISO:

6 Crathco®Simplicity Bubbler

3. 4. 5.

Install pump cover.

Place o-ring on dispense valve

(check if nicked or twisted).

Place in bowl.

Install assembled bowl.

Machine must be OFF.

Insert bowl lip underneath

of lock position on the

back of top tray.

Then, press down on the

front of the bowl until

you hear a click indicating

the bowl is locked proper-

ly in place.

6. 7. 8. 9.

10. 11. 12.

Install spray tube to fit

with Pump cover.

Install handle. Flip out support bracket

for drip tray.

Install drip tray and cover.

Mix product in clean container.

Fill bowl with product.

Install bowl cover. Turn power “on”.

Installation - Spray Function (Model CS-XX-YY-S)

Install mixing impeller. Install bowl gasket.

CAUTION/ ATENCIÓN/

ATTENTION

Sharp edges can

cause personal injury. Handle

with care.

Replace axle if flange thick-

ness is less than 0.75mm

(0.03 inch) thick.

Replace impeller if

bearing surface is

worn more than

0.5mm (0.02 inch).

Inspect for wear.

NOTICE/ AVIS/

AVISO:

Simplicity Bubbler Crathco®7

Product Preparation & Use

1. Wash hands thoroughly when handling

dispenser and product. 2.

Pail

Wire whisk

Measuring pitcher

3. 4.

Pour concentrate into dispenser and then add

remaining water per product label.

Turn on main power

switch.

Correct way

to dispense.

Install lid.

8. 18L

Bowl 9L

Bowl

Min.

(1-1/2L)

Max.

To ensure safe and quality beverage, use only

reliable, purified, or potable water source to

prepare the product.

Prepare concentrate by mixing powder with water

using wire whisk until completely dissolved. Follow

recommended dilution per product label.

Always observe minimum 3 liter (18L bowl) or 1-1/2

liter (9L bowl) fill level to prevent foaming of

product at low level.

Min.

(3L)

Max.

Incorrect way

to dispense.

Mixing tools.

Use only clean mixing tools to prepare product.

9. PRODUCT PREPARATION AND USE

1. Prepare concentrate by mixing powder with water using wire whisk until completely

dissolved. Follow recommended dilution per product label.

2. Pour concentrate into dispenser and then add remaining water per product label.

3. Install lid and turn on main power switch.

4. 25~30° C (77~86° F) ambient temperature is suitable for the operation.

5. This machine maintains beverage temperature of 1~5° C (34~41° F).

6. The dispenser is not for dispensing potentially hazardous beverage.

8 Crathco®Simplicity Bubbler

Daily Cleaning

Machine Disassembly

1. 2.

3. 4. 5.

7. 9.

DAILY

12345

6 7 8 9 10 11 12

13 14 15 16 17 18 19

20 21 22 23 24 25 26

27 28 29 30

FRAGILE!

Turn power “off”. Remove drip tray and cover.

Rotate support brackets for

drip tray.

Drain bowl. Remove handle.

Remove bowl cover. Press release latch on front of the

machine before removing the bowl.

Do not drop.

Remove valve with seal. Remove bowl gasket. Remove mixing impeller.

NOTICE/ AVIS/ AVISO:

Simplicity Bubbler Crathco®9

Daily Cleaning (cont.)

Cleaning Procedures

Cleaning Materials & Tools

Take parts to sink.

Units with spray agitators:

Remove pump cover and spray

tube.

Lift out dispense valve and

remove o-ring.

Wash with detergent

and warm water.

2. 3. 50°C (122°F)

Maximum water

temperature for

cleaning.

75mm (3 inch)

Maximum

water level for

cleaning

Rinse with clean water. Wipe evaporator plate with

detergent and warm water.

6.5.

8. 9.

liquid detergent

(do not use laundry bar/

powdered detergents)

long brush

foam/sponge

(do not use abrasive)

sprayer

toothbrush

sanitizer

(chlorine based)

paper towels

Clean front panel, exterior panels

and release latch.

a. b.

Clean counter and bottom part

of dispenser with paper towel.

ABRASIVES WILL SCRATCH PLASTIC

PARTS. WASH BOWL LIDS IN COOL OR LUKEWARM WATER TO

AVOID LEAKS DUE TO SEALED SURFACE BEING DAMAGED.

The appliance is not suitable for

installation in an area where a water jet could be used. The

appliance must not be cleaned by water jet.

THOROUGHLY CLEAN ALL PARTS IN WARM WATER USING A MILD

NON-ABRASIVE DETERGENT AND RINSE THOROUGHLY.

NOTICE/ AVIS/ AVISO:

10 Crathco®Simplicity Bubbler

Daily Cleaning (cont.)

Daily Sanitizing

DAILY

12345

678910 11 12

13 14 15 16 17 18 19

20 21 22 23 24 25 26

27 28 29 30 Prepare 8L of chlorine-based

sanitizing solution (to 100 ppm) per

package instructions.

Submerge parts in solution for 15

minutes.

Spray inside of lid with sanitizer.

3. 4.

Air dry parts overnight.

Spray inside of bowl with sanitizer.

XII

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Grindmaster Cecilware Distributeur de boissons

Grindmaster Cecilware

Grindmaster Cecilware GB Series Manuel utilisateur

Manuels Distributeur de boissons populaires d'autres marques

PEGAS

PEGAS Evolution Manuel utilisateur

Ugolini

Ugolini MT micro Manuel utilisateur

Bunn

Bunn SLCA-7 Instructions d'installation

Gekkeikan

Gekkeikan Sake Machine Manuel utilisateur

Olympia

Olympia DH709 Manuel utilisateur

Marco

Marco ECOSMART PB10 Manuel utilisateur

Marvel

Marvel ML24BN Series Manuel

Cecilware

Cecilware 2K-GB-LD Manuel

Sure Vend

Sure Vend 673 Manuel utilisateur

Cornelius

Cornelius 2 Flavor Post-Mix Cold Coffee Dispenser Quest... Manuel utilisateur

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manuel utilisateur

Bunn

Bunn LCR-3 HV Guide de dépannage

Servend

Servend SV-200 Manuel utilisateur

EdgeStar

EdgeStar VBR440 Manuel utilisateur

Cornelius

Cornelius A.B.S. Unit Manuel utilisateur

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manuel utilisateur

Siemens

Siemens GA 3000 Manuel d'instructions et de sécurité

Cornelius

Cornelius FCB V4 Caractéristiques techniques