Graco 238817 Manuel utilisateur

308654DINSTRUCTIONS-PARTS LIST

Important Safety Instructions

Read all warnings and instructions in this

manual. Save these instructions.

FTx Spray Gun

Swivel Replacement Kit 238817

GENERAL REPAIR INFORMATION

WARNING

INJECTION HAZARD

The system pressure must be manually

relieved to prevent the system from

starting or spraying accidentally. Fluid

under high pressure can be injected through the

skin and cause serious injury. To reduce the risk of

an injury from injection, splashing fluid, or moving

parts, follow the Pressure Relief Procedure

whenever you:

Dare instructed to relieve the pressure,

Dstop spraying,

Dcheck or service any of the system equipment,

Dor install or clean the spray tip.

Pressure Relief Procedure

1. Engage the gun safety latch.

2. Turn the ON/OFF switch to OFF.

3. Unplug the power supply cord.

4. Disengage the gun safety latch. Hold a metal part

of the gun firmly to a grounded metal pail. Trigger

the gun to relieve pressure.

5. Engage the gun safety latch.

6. Open the pressure drain valve. Leave the pressure

drain valve open until ready to spray again.

If you suspect that the spray tip or hose is completely

clogged, or that pressure has not been fully relieved

after following the steps above, VERY SLOWLY loos-

en the tip guard retaining nut or hose end coupling to

relieve pressure gradually, then loosen completely.

Now clear the tip or hose obstruction.

Test your repair before regular operation of the

sprayer to be sure the problem is corrected.

GRACO INC. P.O. BOX 1441 MINNEAPOLIS, MN 55440–1441

Graco Inc. is registered to I.S. EN ISO 9001

2308654

Service

Replace Swivel

Disassembly

1. Follow Pressure Relief Procedure on page 1.

2. Push up on trigger guard (12) and swing trigger

guard away from trigger (5).

3. Unscrew gun handle (6) from housing (26).

Remove filter and clean in compatible solvent.

4. Remove swivel (15), guard retainer (42) and

cushion o–ring (43) on other side of (42).

5. Save guard retainer and cushion o–ring.

Reassembly

1. Clean internal thread of handle (6).

2. Install guard retainer (42), cushion o–ring (43) and

swivel (15).

3. Apply anaerobic sealant (included in Swivel Kit

238817) to external thread of swivel (15) that

connects to swivel handle (6).

4. Install swivel (15) into handle (6). Torque swivel to

250 in–lb.

5. Engage trigger guard (12) to retainer guard (42).

15 05968B

Graco headquarters: Minneapolis

International Offices: Belgium, China, Japan, Korea

GRACO INC. P.O. BOX 1441 MINNEAPOLIS, MN 55440–1441

PRINTED IN U.S.A. 308654 03/1996, Rev 07/2005

Table des matières

Autres manuels Graco Pistolet à peinture

Graco

Graco EM 490 Manuel d'utilisation

Graco

Graco 307-896 Manuel d'utilisation

Graco

Graco GM7000 231327 Manuel d'utilisation

Graco

Graco Triton 308 Manuel d'utilisation

Graco

Graco Field Lazer 248942 Mode d’emploi

Graco

Graco WB100 Manuel d'utilisation

Graco

Graco PerformAA 15 Manuel de la liste des pièces

Graco

Graco C Series Manuel utilisateur

Graco

Graco 223–390 Manuel d'utilisation

Graco

Graco Switch 3D Gun Manuel de la liste des pièces

Graco

Graco Glascraft GC-1387J Manuel utilisateur

Graco

Graco GM 1030 Manuel utilisateur

Graco

Graco Magnum 261825 Manuel utilisateur

Graco

Graco Magnum X5 Manuel utilisateur

Graco

Graco SUPER NOVA SP Manuel utilisateur

Graco

Graco Pro/Delta Spray 240367 Manuel d'utilisation

Graco

Graco magnum pro plus a20 Mode d'emploi

Graco

Graco GX-7A Guide de démarrage rapide

Graco

Graco SENATOR 237-289 Manuel d'utilisation

Graco

Graco 240539 Manuel utilisateur

Graco

Graco Reactor 3 E-XP1 Standard Mode d’emploi

Graco

Graco 308-328 Manuel d'utilisation

Graco

Graco Pro Xp 24N319 Manuel utilisateur

Graco

Graco Series A Manuel utilisateur

Manuels Pistolet à peinture populaires d'autres marques

SNOWJOE

SNOWJOE Sunjoe 24V-GS-LTW-RM Manuel utilisateur

Binks

Binks SV100 Manuel utilisateur

Fimco

Fimco LG-4-3-1 Manuel utilisateur

AG SPRAY

AG SPRAY FS-ATV-25BL Manuel utilisateur

Nordson

Nordson MicroMax 2 Manuel utilisateur

Bonide

Bonide 051 Manuel d'utilisation

zogics

zogics Z-DAS Manuel utilisateur

KISANKRAFT

KISANKRAFT KK-KBS-165 Manuel utilisateur

Matrix

Matrix SG 650 Manuel utilisateur

Anest Iwata

Anest Iwata SGA-3 Guide de démarrage rapide

paasche

paasche VV Fiche technique

Carlisle

Carlisle DeVilbiss JGA-510 Manuel utilisateur

Gardena

Gardena 11120 Manuel utilisateur

Conrad

Conrad Hobby Airbrush K3 Manuel utilisateur

wiwa

wiwa 14025 R/F Manuel utilisateur

DeVilbiss

DeVilbiss LUNA2i Manuel utilisateur

WAGNER

WAGNER W 125 Manuel utilisateur

My Clean Buddy

My Clean Buddy PW018 Manuel utilisateur