Fisher & Paykel DCS CAD1 Series Manuel utilisateur
INSTALLATION GUIDE / USER GUIDE
US CA
PROFESSIONAL
GRILL CART
CAD1 models
1
CONTENTS
IMPORTANT!
SAVE THESE INSTRUCTIONS
The models shown in this user guide may not be available in all markets and are subject to change
at any time. For current details about model and specification availability in your country, visit our
website listed on the back cover or contact your DCS by Fisher & Paykel dealer.
Safety and warnings 2
Introduction 4
Model identification & dimensions 5
Shipping inspection 6
Locating the cart 7
Cart assembly instructions 7
Components 8
Cart assembly instructions 9
Side shelf assembly instructions (optional) 14
Using the cart 15
Removing the drawers 15
Re-installing the drawers 15
Freezer pack (optional, kit #70696A) 16
Care and maintenance 17
Service & warranty 18
2
SAFETY AND WARNINGS
To reduce the risk of fire, electrical shock, injury to persons, or damage when using the
appliance, follow the important safety instructions listed below: hazard or other injury.
!WARNING!
Explosion Hazard
Failure to follow this advice may result in
injury or death.
• Do not store or use gasoline or other flammable
vapors and liquids inside or in the vicinity of this
or any other appliance.
• An LP cylinder not connected for use shall not
be stored inside or in the vicinity of this unit.
!WARNING!
Tip Hazard
Failure to follow this advice may result
in injury.
• Do not push down on the top of the drawers.
The unit could tip forward.
• Do not overload drawers. Maximum rating of
each drawer is 35 pounds.
!WARNING!
Crush Hazard
Failure to follow this advice may result
in injury.
• Improper hand placement during drawer closure
may cause injury to hands or fingers. Always
close or open drawers using their handles.
• Be sure to keep hands away from drawer edges
when opening or closing drawers.
3
SAFETY AND WARNINGS
zDo not allow children or pets to play in or around the cart.
zTo prevent personal injury or damage to the drawers, do not overload them. The
maximum rating of each drawer is 35 pounds.
zDo not store items of interest to children above or on the inside of any cart.
Children could be seriously injured if they should climb onto or into the cart to
reach these items.
zTo prevent injury from tipping, all Series 9 grills must only be used with either CAD1-
36E or CAD1-48E model carts.
IF YOU SMELL GAS:
zDo not turn on any electrical switch; do not use any phone in your building.
zImmediately call your gas supplier from a neighbor’s phone.
zFollow the gas supplier’s instructions.
zIf you cannot reach your gas supplier, call the fire department.
zInstallation and service must be performed by a qualified installer, service agency or
the gas supplier.
4
INTRODUCTION
Thank you for selecting this DCS by Fisher & Paykel Grill Cart. This installation and user
guide contains valuable information on how to properly install, and maintain your new
Professional Grill Cart for years of safe and enjoyable use.
For your convenience, product questions can be answered by a DCS Customer Care
Representative at www.dcsappliances.com, or email: customer.care@fisherpaykel.com.
5
MODEL IDENTIFICATION & DIMENSIONS
PRODUCT DIMENSIONS CAD1-30 CAD1-36/36E CAD1-48/48E
IN MM IN MM IN MM
A Overall width of cart 30 762 36 914 48 1219
B Overall height of cart 35 1/2 902 35 1/2 902 35 1/2 902
C Height of cart chasis
(excluding wheels) 32 816 32 816 32 816
D Overall depth of cart 25 1/2 648 25 1/2 648 25 1/2 648
E Depth of cart chasis
(excluding doors & handles) 23 1/2 597 23 1/2 597 23 1/2 597
F Width of side shelf bracket 4 1/2 114 4 1/2 114 4 1/2 114
G Width of side shelf 24 610 24 610 24 610
A
f
E
g
D
c b
A
A
A
f
E
g
D
c b
A A
A
f
E
g
D
c b
A A
A
f
E
g
D
c b
A
A
CAD1-30 and side shelf
Front
CAD1-36/36E
Front
CAD1-48/48E
Front
CAD1-30, CAD1-36/36E and CAD1-48/48E
Profile
6
INSTALLATION
Compatibility
IMPORTANT!
All Series 9 grills MUST only be used with either CAD1-36E
or CAD1-48E model carts. They cannot be used with any other CAD1 carts.
Series 7 grills can be used with both
CAD1 and CAD1-E cart models.
Shipping inspection
IMPORTANT!
zDo not discard any packing material (box, straps) until the unit has
been inspected.
1 Inspect the Cart to verify that there is no shipping damage.
2 If any damage is detected, call the retail dealer and initiate a damage claim.
DCS by Fisher & Paykel is not responsible for shipping damage.
zOperate the drawers to be sure they glide smoothly.
zExamine the drawer fronts to be sure there are no dents or scratches.
7
INSTALLATION
A
B
Top view
(with
drawers
open)
Locating the cart
For proper use, this product should be installed/positioned on a flat ground or patio.
Unevenness such as bumps, cracks and protrusions should be 1/4” or less. Refer to
illustration and the below table for required flat area dimensions.
REQUIRED FLAT AREA CAD1-30 CAD1-36/36E CAD1-48/48E
IN MM IN MM IN MM
A Width 30 762 36 914 48 1219
B Depth 48 1219 48 1219 48 1219
Cart assembly instructions
IMPORTANT!
zSome parts have sharp edges; care must be taken when handling the various
components to avoid injury. Please read safety information provided in these
instructions before beginning assembly. Wear gloves when handling.
zTwo or more people should work together to assemble the cart and All-Grill, Double
Side Burner/Sink, or Double Side Burner/Griddle.
zAvoid using side shelf to move cart. Push or pull the cart by grasping corners of head.
8
INSTALLATION
Eye Goggles Work Gloves Allen Wrench (3):
5/32”, 3/16” and 3/32”
Power Screwdriver or
Variable Speed Drill
with Phillips - tip #2
Attachment
Components
Your cart is packaged in one box. The box contains your cart and a universal hardware kit
to be used for grill installation and may contain extra hardware for your convenience.
Table of quantity of parts
CONTENTS MODEL PART NO. QTY
22.5”
11-1/2”
X
19-3/4”
12-3/16”
X
19-3/4”
24.128”
26.6”
19.08” 2.497”
30” Cart shown
CAD1-30 71131 1
CAD1-36 71132 1
CAD1-36E 71407 1
CAD1-48 71133 1
CAD1-48E 71408 1
CONTENTS CAD1-30 CAD1-36/36E CAD1-48/48E
Machined Phillip
screws 10-24X1/2” 13 16 17
Bracket, Tab 2 2 4
Bolt Hex
1/4-20-12” 2 2 2
Washer
.313 x .750 4 4 4
Nut Hex
1/4-20 2 2 2
Tools required
Ce manuel convient aux modèles suivants
5
Table des matières
Autres manuels Fisher & Paykel Gril
Fisher & Paykel
Fisher & Paykel BGB36-BQAR-FS Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS BE1-48R Manuel utilisateur
Fisher & Paykel
Fisher & Paykel BGB48-BQAR Instructions de montage
Fisher & Paykel
Fisher & Paykel 71131 Instructions de montage
Fisher & Paykel
Fisher & Paykel DCS BGC30BQL Instructions de montage
Fisher & Paykel
Fisher & Paykel BGB36-BQAR Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS BH1 Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS 30 BGC Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS BGC48-BQAR Instructions de montage
Fisher & Paykel
Fisher & Paykel DCS BE Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS BE1-30 Manuel utilisateur
Fisher & Paykel
Fisher & Paykel BGB48-BQR Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS BH136RGIL Manuel utilisateur
Fisher & Paykel
Fisher & Paykel BGB48-BQAR Manuel utilisateur
Fisher & Paykel
Fisher & Paykel BGB48-BQR Mode d’emploi
Fisher & Paykel
Fisher & Paykel DCS BH148RL Instructions de montage
Fisher & Paykel
Fisher & Paykel DCS BFGC-30 Instructions de montage
Fisher & Paykel
Fisher & Paykel DCS BGC Series Instructions de montage
Fisher & Paykel
Fisher & Paykel DCS BE1-30 Manuel utilisateur
Fisher & Paykel
Fisher & Paykel DCS CAD-36 Instructions de montage
