Firegear ESTOP-RM-KIT Manuel utilisateur

REV. A Page 1

MODEL: ESTOP-RM-KIT

IF YOU CANNOT READ OR UNDERSTAND THESE INSTALLATION INSTRUCTIONS

DO NOT ATTEMPT TO INSTALL OR OPERATE THIS APPLIANCE

E-STOP Gas Timer Surface Mounting Kit

For use with Firegear Outdoors MatchThrow (MT),

Thermocouple Manual Safety (TMSI) Fire Pits and BBQ Grill applications

Warning: For Outdoor Use Only

PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE

Installation and Operating Instructions

PN#90084

CALIFORNIA PROPOSITION 65

WARNING

This product can expose you to Chromium, which is

known to the state of California to cause cancer

and birth defects or other reproductive harm.

(For more information, go to www.p65warnings.ca.gov)

REV. A Page 2

ESTOP-RM-KIT

PRODUCT DESCRIPTION: This ESTOP-RM-KIT is surface mounted design to be installed with a

Firegear Outdooors Match Throw (MT) re pit, a Thermocouple Manual Safety (TMSI) re pit or BBQ grill applications.

Use either the ESTOP1-0H or ESTOP2-5H gas timer models with this kit. The ESTOP Gas Timer is not supplied with this

kit and must be purchased seperately. The ESTOP gas timers must be oriented in the upright position as shown in the

instructions. NOTE: All gas lines must enter from the back side of the ESTOP gas timer to use this mounting kit. Ensure

to install the plugs provided with the ESTOP gas timer and seal them with gas rated Teon tape before installing

this ESTOP-RM-KIT.

FOLLOW LOCAL CODES IF APPLICABLE FOR THIS INSTALLATION

INSTALLATION

Step 1: Use the four (4) screws provided in the ESTOP

gas timer box and install the two (2) mounting brackets to

each side of the ESTOP as shown in Fig. 1.

Tools Needed: Power Screwdriver with a Phillips head tip,

5/16” wrench or nut driver.

Step 3: Cut a 3⅛” wide x 4 ¾”tall hole into the wall board

where the ESTOP is to be located.

Step 4: Place the ESTOP into the hole and mark the

mounting hole brackets. Ensure assembly is centered and

level, then drill four ¼” holes in the wall for mounting. See

Fig. 3.

Step 2: After brackets are installed, the ESTOP gas timer

should look like Fig. 2.

Fig. 1 Installing mounting brackets to ESTOP gas timer.

PUSH TO STOP

TURN TO START

OFF

TURN

PAST

Fig. 2 Shows front view of ESTOP with mounting

brackets installed.

PUSH TO STOP

TURN TO START

OFF

TURN

PAST

Hole in Wall Board

Fig. 3 Installing ESTOP gas timer into wall.

4 ¾”

3⅛”

REV. A Page 3

ESTOP-RM-KIT

Step 5: Install the (4) 10-24 x 1.25” Phillips screws through

the mounting brackets, into the wall board holes and secure

with a washer and nut (on back side) for each hole.

PUSH TO STOP

TURN TO START

OFF

TURN

PAST

Fig. 4 Shows ESTOP mounted into wall.

PUSH TO STOP

TURN TO START

OFF

TURN

PAST

Cover Plate

Step 6: Install the cover plate overtop of the ESTOP gas

timer. Align the holes in the cover plate with the holes in

the ESTOP gas timer (top and bottom) and install the two

(2) mounting screws (#10-24x6.25 SS Phillips screws) to

secure the cover plate as shown in Figs.5 and 6.

Wall Board

Cover Plate

Mounting

Screw

Mounting

Screw

Fig. 5 Installing cover plate.

Fig. 6 Side view of ESTOP mounted into wall.

Step 7: When cover plate is installed over the ESTOP gas

timer it will protrude ⅞”. See Fig. 7 for outside dimensions.

PUSH TO STOP

TURN TO START

OFF

TURN

PAST

5¾”

6¾”

Fig.7 Cover plate outer dimensions.

Step 8: After the ESTOP-RM-KIT is installed then use gas

rated Teon tape on the gas lines to connect gas supply.

Ensure you check for gas leaks before nal operation.

REV. A Page 4

ESTOP-RM-KIT

REPLACEMENT PARTS LIST

Item# Description Part Number Qty.

1 Cover Plate Stainless ESTOP-COVER-PLATE 1

2 Stainless Mounting Brackets ESTOP-RECESS-BRKT 8 2

3 #10 Stainless Washers WASHER10SS 4

4 #10-24 Stainless Nuts ST3-113-1020 4

5#10-24x 1¼” Phillips Pan Screw SS SCREW1024PANSS 4

6#10-24x6.25 Phil SS Panhead Screw ST3-113-1019 2

REPLACEMENT PARTS

345

Manual changes often occur, ensure to check the Firegear Outdoor

website for any recent updates and warranty information.

FOR TECHNICAL SERVICE, CALL:

Firegear Outdoors

17322 Gothard St

Huntington Beach, CA 92647

Web Site: www.regearoutdoors.com

(800) 966-8126

Autres manuels Firegear Accessoires de cheminée

Firegear

Firegear OFP-36COV Manuel utilisateur

Firegear

Firegear 73230 Manuel utilisateur

Firegear

Firegear 326-930 Manuel utilisateur

Firegear

Firegear FPB-26DBS22MT-N Manuel utilisateur

Firegear

Firegear FG-H-2110SS Manuel utilisateur

Firegear

Firegear FPB-16SBSTMSI-N Manuel utilisateur

Firegear

Firegear ADP10-OUT Manuel utilisateur

Firegear

Firegear LOF-3010PS246MT-N Manuel utilisateur

Firegear

Firegear FG-FR-6SSK Manuel utilisateur

Firegear

Firegear LOF-3012HTMSI-N Manuel utilisateur

Firegear

Firegear LOF-48LHTMSI-N Manuel utilisateur

Firegear

Firegear FPB-19RBS16TPSI-N Manuel utilisateur

Manuels Accessoires de cheminée populaires d'autres marques

Valor

Valor L2 1700K Manuel utilisateur

Exodraft

Exodraft Xzense Manuel utilisateur

Whalen

Whalen Ruso MNFP62BF23-6 Manuel utilisateur

Lopi

Lopi Hearthview 864 Manuel utilisateur

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Manuel utilisateur

EdilKamin

EdilKamin SERBATOIO 250 Guide de démarrage rapide

Bronpi

Bronpi KIT-1 Manuel utilisateur

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Manuel utilisateur

Travis Industries

Travis Industries 33 DVI Manuel utilisateur

Superior

Superior ASD3628-TI Manuel utilisateur

pleasant hearth

pleasant hearth OFP28WG Manuel utilisateur

IHP

IHP Astria Series Manuel utilisateur

Nibe

Nibe Contura C i31 Manuel utilisateur

kozy heat

kozy heat KZK-052 Manuel utilisateur

SimpliFire

SimpliFire SF-WM36 Manuel utilisateur

Bluegrass Living

Bluegrass Living BC18NR Guide de démarrage rapide

pleasant hearth

pleasant hearth IRIS SCROLL Manuel utilisateur

Cooke

Cooke Glass Wind Guard Manuel utilisateur