EOS Cubo Manuel utilisateur
Druck-Nr.: 2902 5259
Stand: 26/23
EN
Made in Germany
EOS Cubo / Cubo Avantgarde
Heater for Sauna Cabins
Installation and Operating Instructions
EN-2 Installation and Operating Instructions - EOS Cubo / Cubo Avantgarde
EN Documentation
Documentation
Manufacturer
Original installation instructions EN
Copyright for these installation instructions remains with
EOS Saunatechnik GmbH.
The copying and distribution of this document, as well as the use and com-
munication of its contents without express authorization, are not permit-
ted. Compensation will be claimed in the event of infringements.
All rights reserved with regard to patent claims or submission of design or
utility patent.
Characters, symbols and illustrations
Revision history
EOS Saunatechnik GmbH
Schneiderstriesch 1
35759 Driedorf, Germany
Tel. +49 2775 82-514
Fax +49 2775 82-431
Email servicec[email protected]
Web www.eos-sauna.com
Additional information about an operating step
Cross-reference to a page
Read instructions
Result of a step
Table title
Title of figure
≤ ≥ Less than or equal to, greater than or equal to
Date Version Description
1 May 2022 01.00 First version
EOS Cubo / Cubo Avantgarde - Installation and Operating Instructions EN-3
Contents
Documentation ..................................................................................................EN-2
1 General safety instructions ..........................................................................EN-5
1.1 Mounting and electrical installation .................................................EN-5
1.2 Operator instruction................................................................................EN-8
1.3 Heater and cabin labels....................................................................... EN-11
1.4 Safety levels.............................................................................................EN-14
1.5 Standards and regulations.................................................................EN-14
2 Identification....................................................................................................EN-15
2.1 Requirements for operation .............................................................EN-15
2.2 Nameplate ...............................................................................................EN-15
2.3 Scope of delivery ...................................................................................EN-16
2.4 Technical data.........................................................................................EN-17
2.5 Intended use ...........................................................................................EN-19
3 Installation ........................................................................................................EN-21
3.1 Specifications for the cabin ...............................................................EN-21
3.1.1 Installation site ......................................................................EN-21
3.1.2 Temperature sensor ............................................................ EN-24
3.1.3 Air inlets and outlets............................................................EN-25
3.1.4 Connecting cable..................................................................EN-25
3.2 Heater guard rail....................................................................................EN-26
3.3 Installing the heater ............................................................................EN-26
3.3.1 Installing the connecting cable........................................EN-26
3.4 Adding stones .......................................................................................EN-30
3.5 Warning signs on the cabin...............................................................EN-31
4 Connections...................................................................................................... EN-32
4.1 General instructions for electrical installation............................EN-32
4.2 Connections ............................................................................................EN-32
4.3 Establishing an electrical connection ............................................EN-35
4.4 Heating period limitation................................................................... EN-35
EN-4 Installation and Operating Instructions - EOS Cubo / Cubo Avantgarde
EN
5 Commissioning................................................................................................EN-36
5.1 Starting the heater ................................................................................EN-36
5.2 Water splash ............................................................................................EN-37
6 Maintenance .....................................................................................................EN-38
6.1 Cleaning ....................................................................................................EN-38
6.2 Sauna stones............................................................................................EN-39
6.3 Replacing the heating elements ......................................................EN-40
6.4 Resetting the safety temperature limiter......................................EN-45
6.5 Troubleshooting.....................................................................................EN-46
7 General terms and conditions of service ............................................EN-48
8 Disposal...............................................................................................................EN-51
EOS Cubo / Cubo Avantgarde - Installation and Operating Instructions EN-5
General safety instructions
1 General safety instructions
1.1 Mounting and electrical installation
The installation instructions are intended for qualified
personnel familiar with the laws and regulations appli-
cable to electrical installations at the installation site.
Observe the following general safety instructions
during mounting, configuration and commissioning
of the product.
Risk to life and limb and risk of fire
Risk to life and limb from electric shock and fire in the event of im-
proper or faulty electrical connection. This risk remains also after
completion of the installation work.
The electrical installation of the heater, relay boxes and other
electrical systems or equipment with a fixed mains connection
must only be performed by a trained electrician from an autho-
rized electrical company.
Ensure compliance with the applicable standards and regula-
tions for electrical installation.
The system must be completely disconnected from the mains
supply before commencing installation and repair work.
The housing cover must only be removed by a qualified electri-
cian.
Fire hazard from overheating
Insufficient ventilation can lead to device overheating and fire.
Install air inlets and outlets in the cabin.
Observe the cabin manufacturer’s safety and installation in-
structions.
EN-6 Installation and Operating Instructions - EOS Cubo / Cubo Avantgarde
EN General safety instructions
Risk of fire due to sauna stones
It is possible for hot stones or stone pieces to fall out of the rock
store.
The sauna heater may not be placed on a floor made of easily
flammable material (e.g., laminate or synthetic flooring). Ce-
ramic tiles are recommended as a flooring option.
Risk of burns from hot glass
Glass surfaces in the cabin become hot while the sauna is in oper-
ation.
When installing the cabin, ensure that the touchable glass sur-
faces on its outside do not exceed a maximum temperature of
76°C/169°F. Appropriate protection may need to be installed.
Risk of burns from hot unit
During operation, the sauna heater may become hot and, if
touched, could cause burns.
Maintain a safe distance.
Sauna cabin and heater
The sauna cabin must be constructed with proper material and
built in a professional manner, and the heater must be suited for
the cabin.
Sauna heaters and control units may only be used in sauna cab-
ins made of suitable, low-resin and untreated material (e.g.,
Nordic spruce).
Multiple heaters may be installed in one sauna if the heater
power can properly supply the cabin volume. In this case, de-
pending on the position, an additional safety temperature lim-
iter must be installed for each additional heater.
The sauna heater is not designed to be installed or set up in an
alcove or under a bench or sloping roof unless the sauna heater
is specifically designed and approved for this type of installa-
tion.
EOS Cubo / Cubo Avantgarde - Installation and Operating Instructions EN-7
General safety instructions
Receptacles may not be installed inside the sauna cabin.
Each sauna cabin must have air inlets and outlets. The air inlets
and outlets may be installed below or behind the sauna heater,
approx. 5–10 cm/2–4 inches above the floor. The minimum di-
mensions of the air inlets and outlets can be found here:
2.4 Technical data, EN-17, 3.1.3 Air inlets and outlets,
EN-25.
The exhaust openings are always installed in the lower part of
the wall diagonal to the sauna heater. The supply and exhaust
openings must not be closed. Please observe the instructions
provided by your sauna cabin manufacturer.
Use one of the control units listed below to check and control
the sauna heater. This control unit is fixed to a suitable location
on the cabin’s external wall, and the corresponding sensor
housings according to the installation instructions that accom-
pany the control units inside the sauna cabin.
The cabin lighting must be safe for sauna cabin use and in-
stalled in such a way that it can be used safely in a sauna cabin.
Ensure that the heater is installed in compliance with the stan-
dards and legal norms valid in your country.
The cabin door must open outward and must not have a lock
that cannot be opened in the case of failure. We recommend
magnetic or spring locks.
EN-8 Installation and Operating Instructions - EOS Cubo / Cubo Avantgarde
EN General safety instructions
1.2 Operator instruction
The operator of the sauna cabin must be instructed in the general
safety instructions during commissioning. The operator must be
given a copy of the operating instructions.
The operator must make the end user aware of safety instructions
that are relevant to the end user.
The operator must be familiar with the settings for the heating pe-
riod and understand how it is controlled.
Risk of electric shock
A risk to life and limb from electric shock and fire arises in the event
of improper repair work. This risk remains also after work is com-
pleted.
The housing cover must only be removed by a qualified electri-
cian.
Repairs and installations must only be performed by a trained
electrician.
The system must be disconnected and removed entirely from
the mains supply before commencing repair work.
Use only original spare parts from the manufacturer.
Fire hazard
Objects placed on the heater or protective grilles can
easily be ignited and cause fires.
Attach the heater guard rail.
Do not place objects on the heater.
Fill the stone grate as directed.
Inspect the sauna cabin prior to each use.
If you switch on the heater using pre-set timers or remotely, at-
tach a protective cover to the heater or install a suitable safety
system.
EOS Cubo / Cubo Avantgarde - Installation and Operating Instructions EN-9
General safety instructions
Health risks
Spending time in a sauna cabin can lead to serious health risks or
even death for persons with health impairments.
Persons with health impairments who spend time in a sauna
must consult a doctor before entering a sauna cabin.
Damage to health
Excessive time spent in a heated sauna cabin can lead to overheat-
ing of the body (hyperthermia), which may cause serious health
problems and even death. Hyperthermia occurs when the core
temperature of the body exceeds the norm by a few degrees.
Symptoms of hyperthermia include fever, dizziness, lethargy,
sleepiness, and fainting. Side effects of hyperthermia include per-
ception disorders, inability to recognize the need to leave the
room, inability to identify imminent danger, harm to the fetus in
the case of pregnant women, inability to physically leave the
room, unconsciousness.
Alcohol, drugs, and medications increase the risk of hyperthermia.
Do not exceed the maximum recommended time in the sauna.
Leave the sauna cabin if your body responds abnormally to the
heat or if you do not feel well.
Avoid alcohol, drugs, and medications when you are using the
sauna.
EN-10 Installation and Operating Instructions - EOS Cubo / Cubo Avantgarde
EN General safety instructions
Operation by children or persons with reduced mental
capacity
Children and persons with reduced mental capacity can put them-
selves at risk.
Children must be supervised to ensure they do not play with
the unit.
Children under 8 years of age should not operate the sauna
cabin.
The settings for the heating period may only be changed by
children over 8 if they are supervised by an adult.
The sauna cabin must only be used by persons with reduced
mental capacity or limited physical or sensory abilities under su-
pervision or if they have been previously instructed in its use
and understand the risks.
Children and persons who have not received proper instruction
must not clean or service the system.
Autres manuels pour Cubo
1
Ce manuel convient aux modèles suivants
1
Table des matières
Autres manuels EOS Chauffage
EOS
EOS Bi-O Mat U Guide de planification
EOS
EOS Skiff Manuel utilisateur
EOS
EOS Vitae Protect+ Guide de planification
EOS
EOS Majesty Manuel utilisateur
EOS
EOS Bi-O Cubo Guide de l'utilisateur
EOS
EOS Cubo Guide de planification
EOS
EOS 43.FN Guide de planification
EOS
EOS Zeus Guide de l'utilisateur
EOS
EOS Zeus S Manuel utilisateur
EOS
EOS Herkules XL S120 Manuel utilisateur
EOS
EOS 43.HB Guide de planification
EOS
EOS 46.U Guide de planification
EOS
EOS Ecomat 8 Manuel utilisateur
EOS
EOS Saunadome II Manuel utilisateur
EOS
EOS Herkules XL S120 Guide de planification
EOS
EOS P1 W Manuel utilisateur
EOS
EOS Mythos S34 Manuel utilisateur
EOS
EOS IRelax Manuel utilisateur
EOS
EOS Moment W Guide de planification
EOS
EOS IRS 30 Keramik Guide de planification
Manuels Chauffage populaires d'autres marques
oventrop
oventrop Regucor Series Manuel utilisateur
Blaze King
Blaze King CLARITY CL2118.IPI.1 Manuel utilisateur
ELMEKO
ELMEKO ML 150 Manuel utilisateur
BN Thermic
BN Thermic 830T Manuel utilisateur
KING
KING K Series Mode d’emploi
Empire Comfort Systems
Empire Comfort Systems RH-50-5 Guide de démarrage rapide
Empire Heating Systems
Empire Heating Systems WCC65 Manuel utilisateur
Wetekom
Wetekom 92 86 43 Manuel utilisateur
Desa
Desa SPC170-F Manuel utilisateur
Watlow
Watlow Watrod Electric Tubular Heaters Manuel utilisateur
Haverland
Haverland ECO-DRY GPS Series Manuel de la liste des pièces
Stelpro
Stelpro ASILVC2060 Series Manuel utilisateur