Emerson Fisher FIELDVUE DVC6200 SIS Guide de configuration

www.Fisher.com

Fisher™FIELDVUE™DVC6200 SIS Digital Valve

Controller PST Calibration and Testing using

ValveLink™Software

The test procedure contained in this Instruction Manual Supplement is to be considered as a guideline only and should

be modified to address site‐specific requirements. Use this procedure in conjunction with the DVC6200 Series quick

start guide (D103556X012) and the DVC6200 SIS instruction manual (D103557X012). In addition, exercise good

engineering practices and abide by specific plant safety guidelines for safe operation.

WARNING

This document is not intended to be used as a stand‐alone document. It must be used in conjunction with the following

documents:

Safety Manual for FIELDVUE DVC6200 SIS Digital Valve Controller and Position Monitor (D103601X012)

Fisher FIELDVUE DVC6200 SIS Instruction Manual (D103557X012)

Failure to use this instruction manual supplement in conjunction with the above referenced manuals could result in

personal injury or property damage. If you have any questions regarding these instructions or need assistance in obtaining

any of these documents, contact your Emerson sales office.

For additional information on Partial Stroke Testing and associated parameters refer to Partial Stroke Test Information

on page 19.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

PST Calibration

This document covers the basic PST calibration, as well as details for making adjustments to the normal end, using

Advanced Settings (see figure 11).

Figure 1. Calibration > Partial Stroke

Confirm SIS Tier

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 2. Set Instrument Out of Service and start Partial Stroke Test calibration

Refer to figure 11 for

information on Advanced

Settings

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 3. Enter the Desired Outgoing Ramp Rate

Supports separate ramp

rates for outing and

incoming strokes

Figure 4. Enter the Desired Incoming Ramp Rate

Additional ramp

rates for the

incoming stroke

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 5. Enter the Travel Target Movement

Target Travel Movement is the

percentage of travel from the

normal end

Figure 6. Partial Stroke Calibration progress

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 7. Partial Stroke Calibration progress

Will calibrate to 30% from

the normal end

Figure 8. Configuring SIS Triggers

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 9. Partial Stroke Calibration Progress

Figure 10. Calibration Procedure Complete

List of parameter values

being downloaded to the

device

If you need to make adjustments to the normal end default settings, select Advanced Settings, as shown in figure 11,

and make the necessary adjustments.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 11. Select Advanced Settings to Make Adjustments to the Normal End

Select to define the

normal end

Figure 12. Set Travel High End

Defines the normal end of travel

(where the valve is when the

process is running normally)

The point at which valve

seating occurs will vary slightly

every time. Do not set this

higher than 99.5% or lower

than 0.5%.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 13. Enter Target Travel Movement

Figure 14. Partial Stroke Calibration Progress

Running a PST calibration will enable Short Duration PST. If this is not desired, refer to figure 24 for information on

disabling Short Duration PST.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Configuration

After successfully calibrating the valve for PST go to the Detailed Setup SIS/Partial Stroke tab and verify the values for

the parameters in the Test Configuration group box are correct. Then go to the SIS Options group box and enable any

of the behaviors required for the PST.

Figure 15. Verify Test Configuration and Test Acceptance Criteria

Autres manuels pour Fisher FIELDVUE DVC6200 SIS

Table des matières

Autres manuels Emerson Contrôleurs

Emerson

Emerson Bettis BHH Series Manuel utilisateur

Emerson

Emerson Tescom ER5000 Series Manuel utilisateur

Emerson

Emerson EC3-D72 Manuel utilisateur

Emerson

Emerson ECD-002 Manuel utilisateur

Emerson

Emerson Bristol CI-9110 Manuel utilisateur

Emerson

Emerson Bettis XTE3000 Manuel utilisateur

Emerson

Emerson Fisher 92S Manuel utilisateur

Emerson

Emerson Fisher Type 99 Manuel utilisateur

Emerson

Emerson PeC C100 Manuel utilisateur

Emerson

Emerson Bettis RTS Manuel utilisateur

Emerson

Emerson Fisher CS400 Series Manuel utilisateur

Emerson

Emerson Fisher 630 Series Manuel utilisateur

Emerson

Emerson Dixell XC645CX Manuel utilisateur

Emerson

Emerson Dixell iChill IC200D EVO Series Schéma de câblage

Emerson

Emerson PACSystems RX3i Energy Pack Manuel utilisateur

Emerson

Emerson Bettis RPX Series Manuel d'installation et d'exploitation

Emerson

Emerson EL-O-MATIC EL35 Manuel utilisateur

Emerson

Emerson Branson 2000X Manuel utilisateur

Emerson

Emerson Fisher 585CLS Manuel utilisateur

Emerson

Emerson Control Link Refrigeration System Controller Manuel utilisateur

Emerson

Emerson FieldQ Series Manuel d'exploitation

Emerson

Emerson DIXELL XRi20CH Schéma de câblage

Emerson

Emerson Fisher 161 Series Manuel utilisateur

Emerson

Emerson EXD-HP1 Manuel utilisateur

Manuels Contrôleurs populaires d'autres marques

Digiplex

Digiplex DGP-848 Mode d'emploi

YASKAWA

YASKAWA SGM series Manuel utilisateur

Sinope

Sinope Calypso RM3500ZB Manuel utilisateur

Isimet

Isimet DLA Series Style 2 Manuel d'installation

LSIS

LSIS sv-ip5a Manuel utilisateur

Rockwell Automation

Rockwell Automation 1769-L31 Manuel utilisateur

Airflow

Airflow Uno hab Manuel utilisateur

ABB

ABB ACS580-01 drives Manuel utilisateur

Panasonic

Panasonic GM1 Series Manuel utilisateur

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuel utilisateur

Panasonic

Panasonic FP? Positioning Unit RTEX Manuel utilisateur

Samson

Samson Type 5824 Manuel de service

Alpha IP

Alpha IP MIOB 21001 Manuel utilisateur

Siemens

Siemens OpenAir GMA 1 Series Manuel utilisateur

Surecom

Surecom SR-629 Manuel utilisateur

Fishman

Fishman TriplePlay Manuel utilisateur

Regulus

Regulus SRS1 T Manuel utilisateur

3M MicroTouch EX113 Manuel utilisateur