Emerson Bettis RP3E Manuel utilisateur

Bettis RTS Relay Board (RP3E)

Electric Actuator

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

April 2023

Note

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

This page intentionally left blank.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Table of Contents

April 2023

Table of Contents

Section 1: Tools

Tools.........................................................................................................................1

Section 2: Material

Material.....................................................................................................................2

Section 3: Installation

Installation................................................................................................................3

Section 4: Programming

Programming............................................................................................................8

Note

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

This page intentionally left blank.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1 April 2023

Tools 1

Section 1: Tools

! WARNING

Remove all power supplies before doing the exchange. Always act with caution during

the exchange!

• Needle nose pliers

• Screw driver phillips

• Screw driver at

• Allen key 5

• Socket wrench 5

Figure 1.

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Material

Section 2: Material

• 1x relay board RP3E6A (ID:13009)

• 1x adapter cable (ID:16504)

• 2x steel screw M3x16 (ID:952)

• 3x plastic distance 8 mm (ID:9896)

• 1x plastic screw M3x15 (ID:9895)

• 1x plastic nut M3 (ID:7084)

• 2x lock plates M3 red (ID:13674)

Figure 2.

Figure 3.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1 April 2023

Installation 3

Section 3: Installation

Unscrew the 4 hexagon socket screws from the cover and remove it carefully. Mind the

connection cable between display and logic board.

Figure 4.

Unscrew the 4 cross recessed screws from the existing logic board and afterwards, tilt it

carefully to you.

Figure 5.

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Installation4

Section 3: Installation

Remove carefully the connected cables: ribbon cable and 6-, 8- and 10-pole plugs

(see Figure 6, left image). Afterwards, you can remove the logic board from the control

unit and disconnect the second ribbon cable on the back (see Figure 6, right image).

Figure 6.

Remove the two steel spacers (marked with the black arrows in Figure 7) in the housing.

Figure 7.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1 April 2023

Installation 5

Section 3: Installation

Place the 8 mm plastic spacers on the relay board as shown in the top image of Figure 8.

Insert the M3x16 steel screws through the holes next to the multi-pin connectors in the

logic board as shown in the bottom image of Figure 8. Then line up the screws with the

plastic spacers in the relay board and secure the screws with the red lock plates. For the

third hole, use the plastic screw M3x15 and secure it in place with the plastic nut.

Figure 8.

Connect the relay board with the multi-pin connector from the logic board.

! WARNING

The four pins on the left side must remain disconnected (see Figure 9).

The orientation of the mounting holes on both the logic and relay boards plus the spacers

must be aligned as shown in Figure 9.

Figure 9.

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Installation6

Section 3: Installation

Connect the 10- and 6-pole connectors to the adapter cables, then connect the blue

connectors of the adapter cables to the corresponding connectors on the relay board.

Figure 10.

Autres manuels pour Bettis RP3E

Table des matières

Autres manuels Emerson Contrôleurs

Emerson

Emerson FISHER 657NS Manuel utilisateur

Emerson

Emerson Fisher CML-750 Manuel utilisateur

Emerson

Emerson Bettis CBB Series Mode d'emploi

Emerson

Emerson Bettis PressureGuard Manuel

Emerson

Emerson KEYSTONE OM13 EPI-2 Manuel utilisateur

Emerson

Emerson COPELAND XC PRO Manuel du propriétaire

Emerson

Emerson Fisher M Series Manuel utilisateur

Emerson

Emerson P159A Series Instructions d'installation et d'utilisation

Emerson

Emerson PACSystems RSTi-EP Manuel utilisateur

Emerson

Emerson FISHER FIELDVUE DLC3010 Manuel utilisateur

Emerson

Emerson MCi210 Manuel utilisateur

Emerson

Emerson Fisher 2503 Manuel utilisateur

Emerson

Emerson Alco Controls EC3 Series Manuel utilisateur

Emerson

Emerson Fisher 95L Manuel utilisateur

Emerson

Emerson unidrive m201 Manuel utilisateur

Emerson

Emerson MultiFlex ESR Manuel utilisateur

Emerson

Emerson Fisher 1052 Manuel utilisateur

Emerson

Emerson Bettis G Series Manuel utilisateur

Emerson

Emerson Fisher EZH Series Manuel utilisateur

Emerson

Emerson TESCOM 04 Series Guide de configuration

Emerson

Emerson Leroy-Somer R220 Mode d’emploi

Emerson

Emerson Autochangeover Controllers AC8 Manuel utilisateur

Emerson

Emerson CPHE Manuel utilisateur

Emerson

Emerson E2 Manuel utilisateur

Manuels Contrôleurs populaires d'autres marques

Digiplex

Digiplex DGP-848 Mode d'emploi

YASKAWA

YASKAWA SGM series Manuel utilisateur

Sinope

Sinope Calypso RM3500ZB Manuel utilisateur

Isimet

Isimet DLA Series Style 2 Manuel d'installation

LSIS

LSIS sv-ip5a Manuel utilisateur

Rockwell Automation

Rockwell Automation 1769-L31 Manuel utilisateur

Airflow

Airflow Uno hab Manuel utilisateur

ABB

ABB ACS580-01 drives Manuel utilisateur

Panasonic

Panasonic GM1 Series Manuel utilisateur

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuel utilisateur

Panasonic

Panasonic FP? Positioning Unit RTEX Manuel utilisateur

Samson

Samson Type 5824 Manuel de service

Alpha IP

Alpha IP MIOB 21001 Manuel utilisateur

Siemens

Siemens OpenAir GMA 1 Series Manuel utilisateur

Surecom

Surecom SR-629 Manuel utilisateur

Fishman

Fishman TriplePlay Manuel utilisateur

Regulus

Regulus SRS1 T Manuel utilisateur

3M MicroTouch EX113 Manuel utilisateur