Dell XPS 630i Manuel utilisateur

www.dell.com | support.dell.com

Dell™ XPS™ 630i

Service Manual

Model DCDR01

book.book Page 1 Monday, January 7, 2008 2:53 PM

Notes, Notices, and Cautions

NOTE: A NOTE indicates important information that helps you make better use of

your computer.

NOTICE: A NOTICE indicates either potential damage to hardware or loss of data

and tells you how to avoid the problem.

CAUTION: A CAUTION indicates a potential for property damage, personal injury,

or death.

____________________

Information in this document is subject to change without notice.

Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly

forbidden.

Trademarks used in this text: Dell, the DELL logo, and XPS are trademarks of Dell Inc.; Microsoft,

Windows,Windows Vista, and Windows Vista start button are either trademarks or registered

trademarks of Microsoft Corporation in the United States and/or other countries.

Other trademarks and trade names may be used in this document to refer to either the entities claiming

the marks and names or their products. Dell Inc. disclaims any proprietary interest in trademarks and

trade names other than its own.

Model DCDR01

February 2008 Rev. A00

book.book Page 2 Monday, January 7, 2008 2:53 PM

Contents 3

Contents

1 Before You Begin . . . . . . . . . . . . . . . . . . . 9

Recommended Tools . . . . . . . . . . . . . . . . . . . 9

Turning Off Your Computer . . . . . . . . . . . . . . . . 9

Before Working Inside Your Computer . . . . . . . . . 10

2 Removing the Computer Cover . . . . . . . . 13

3 Technical Overview . . . . . . . . . . . . . . . . . 15

Inside View of Your Computer . . . . . . . . . . . . . 15

System Board Components . . . . . . . . . . . . . . . 16

Power Supply Unit (PSU) DC Connector

Pin Assignments . . . . . . . . . . . . . . . . . . . . . 18

DC Power Connector P1 . . . . . . . . . . . . . . 18

DC Power Connector P2 and P3

(Graphics Card) . . . . . . . . . . . . . . . . . . 20

DC Power Connectors P4–P7

(HDD0–HDD3) . . . . . . . . . . . . . . . . . . . 20

DC Power Connector P8 (PHY) . . . . . . . . . . . 21

DC Power Connectors P9 and P10

(Bay1 SATA and Bay2 SATA) . . . . . . . . . . . . 21

DC Power Connector P11 and P12

(BAY and BAY2) . . . . . . . . . . . . . . . . . . 21

DC Power Connector P13 (FDI) . . . . . . . . . . 22

book.book Page 3 Monday, January 7, 2008 2:53 PM

4Contents

DC Power Connector P14 (MS BD) . . . . . . . . . 22

DC Power Connectors P15 . . . . . . . . . . . . . 23

Power Button DC Pin Assignments . . . . . . . . 23

4 Memory . . . . . . . . . . . . . . . . . . . . . . . . . . 25

DDR2 Memory Overview . . . . . . . . . . . . . . . . 25

Addressing Memory Configurations . . . . . . . . . . 27

Installing Memory . . . . . . . . . . . . . . . . . . . . 27

Removing Memory . . . . . . . . . . . . . . . . . . . . 29

5Cards. . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Removing PCI and PCI Express Cards . . . . . . . . . . 32

Installing PCI and PCI Express Cards . . . . . . . . . . 35

Removing a PCI Express Graphics Card From

a Dual Configuration . . . . . . . . . . . . . . . . . . . 38

Installing a PCI Express Graphics Card in a

Dual Configuration . . . . . . . . . . . . . . . . . . . . 40

Network Adapter and Sound Card Settings . . . . . . . 43

6Drives. . . . . . . . . . . . . . . . . . . . . . . . . . . 45

About Serial ATA (SATA) Drives . . . . . . . . . . . . . 46

General Drive Installation Guidelines . . . . . . . . . 46

Hard Drive . . . . . . . . . . . . . . . . . . . . . . . . 47

Removing a Hard Drive . . . . . . . . . . . . . . . 47

Installing a Hard Drive . . . . . . . . . . . . . . . 50

book.book Page 4 Monday, January 7, 2008 2:53 PM

Contents 5

Drive Panel . . . . . . . . . . . . . . . . . . . . . . . 53

Removing the Drive Panel . . . . . . . . . . . . . 53

Installing the Drive Panel . . . . . . . . . . . . . 54

Floppy Drive . . . . . . . . . . . . . . . . . . . . . . . 55

Removing a Floppy Drive . . . . . . . . . . . . . . 55

Installing a Floppy Drive . . . . . . . . . . . . . . 56

Media Card Reader . . . . . . . . . . . . . . . . . . . 59

Removing a Media Card Reader . . . . . . . . . . 59

Installing a Media Card Reader . . . . . . . . . . 60

CD/DVD Drive . . . . . . . . . . . . . . . . . . . . . . 63

Removing a CD/DVD Drive . . . . . . . . . . . . . 63

Installing a CD/DVD Drive . . . . . . . . . . . . . 64

7 Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69

Removing the Card Fan . . . . . . . . . . . . . . . . . 69

Installing the Card Fan . . . . . . . . . . . . . . . . . 71

Removing the Hard Drive Fan . . . . . . . . . . . . . . 74

Installing the Hard Drive Fan . . . . . . . . . . . . . . 76

8 Processor Heatsink . . . . . . . . . . . . . . . . . 79

Removing the Processor Heatsink . . . . . . . . . . . 79

Installing the Processor Heatsink . . . . . . . . . . . 80

book.book Page 5 Monday, January 7, 2008 2:53 PM

6Contents

9 Processor . . . . . . . . . . . . . . . . . . . . . . . . 83

Removing the Processor . . . . . . . . . . . . . . . . . 83

Installing the Processor . . . . . . . . . . . . . . . . . 84

10 System Board . . . . . . . . . . . . . . . . . . . . . 87

Removing the System Board . . . . . . . . . . . . . . . 87

Installing the System Board . . . . . . . . . . . . . . . 88

11 Power Supply . . . . . . . . . . . . . . . . . . . . . 91

Removing the Power Supply . . . . . . . . . . . . . . 91

Installing the Power Supply . . . . . . . . . . . . . . . 92

12 Front I/O Panel . . . . . . . . . . . . . . . . . . . . 95

Removing the Front I/O Panel . . . . . . . . . . . . . . 95

Installing the Front I/O Panel . . . . . . . . . . . . . . 97

13 Master I/O Board . . . . . . . . . . . . . . . . . . 101

Master I/O Board Components . . . . . . . . . . . . . 101

Removing the Master I/O Board . . . . . . . . . . . . . 102

Installing the Master I/O Board . . . . . . . . . . . . . 103

book.book Page 6 Monday, January 7, 2008 2:53 PM

Contents 7

14 Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 105

Removing the Front LED Board . . . . . . . . . . . . . 105

Installing the Front LED Board . . . . . . . . . . . . . 106

Removing the Rear LED Board . . . . . . . . . . . . . 107

Installing the Rear LED Board . . . . . . . . . . . . . . 109

15 Replacing the Battery . . . . . . . . . . . . . . 111

16 Cables . . . . . . . . . . . . . . . . . . . . . . . . . . 113

Power Cables . . . . . . . . . . . . . . . . . . . . . . 113

Power Cables With a Release Latch . . . . . . . . 113

Power Cables Without a Release Latch . . . . . . 114

IDE and Floppy-Drive Cables . . . . . . . . . . . . . . 115

SATA Cables . . . . . . . . . . . . . . . . . . . . . . . 116

Front I/O Panel Cables . . . . . . . . . . . . . . . . . 117

17 Replacing the Computer Cover . . . . . . . 119

book.book Page 7 Monday, January 7, 2008 2:53 PM

8Contents

book.book Page 8 Monday, January 7, 2008 2:53 PM

Before You Begin 9

Before You Begin

This document provides procedures for removing and installing the

components in your computer. Unless otherwise noted, each procedure

assumes that the following conditions exist:

• You have performed the steps in "Turning Off Your Computer" on page 9

and "Before Working Inside Your Computer" on page 10.

• You have read the safety information in the Dell™

Product Information

Guide.

• A component can be replaced or—if purchased separately—installed by

performing the removal procedure in reverse order.

Recommended Tools

The procedures in this document may require the following tools:

• Small Phillips screwdriver

• Flash BIOS update program media

Turning Off Your Computer

NOTICE: To avoid losing data, save and close all open files and exit all open

programs before you turn off your computer.

Shut down the operating system:

Save and close all open files and exit all open programs.

In the Microsoft

Windows

XP operating system

, click

Start

→

Shut

Down

→

Shut down

book.book Page 9 Monday, January 7, 2008 2:53 PM

10 Before You Begin

In the Microsoft Windows Vista

operating system,

click the Windows

Vista Start button , click the arrow in the lower-right corner of the

Start menu as shown below, and then click

Shut Down

The computer turns off after the operating system shutdown process

is complete.

Ensure that the computer and all attached devices are turned off. If your

computer and attached devices did not automatically turn off when you

shut down your operating system, press and hold the power button for

about 4 seconds to turn them off.

Before Working Inside Your Computer

Use the following safety guidelines to help protect your computer from

potential damage and to help to ensure your own personal safety.

CAUTION: Before you begin any of the procedures in this section, follow the

safety instructions in the Product Information Guide.

NOTICE: Handle components and cards with care. Do not touch the components

or contacts on a card. Hold a card by its edges or by its metal mounting bracket.

Hold a component such as a processor by its edges, not by its pins.

NOTICE: Only a certified service technician should perform repairs on your

computer. Damage due to servicing that is not authorized by Dell is not covered by

your warranty.

NOTICE: When you disconnect a cable, pull on its connector or on its pull-tab, not

on the cable itself. Some cables have connectors with locking tabs; if you are

disconnecting this type of cable, press in on the locking tabs before you disconnect

the cable. As you pull connectors apart, keep them evenly aligned to avoid bending

any connector pins. Also, before you connect a cable, ensure that both connectors

are correctly oriented and aligned.

NOTICE: To avoid damaging the computer, perform the following steps before you

begin working inside the computer.

Ensure that the work surface is flat and clean to prevent the computer

cover from being scratched.

Turn off your computer (see "Turning Off Your Computer" on page 9).

book.book Page 10 Monday, January 7, 2008 2:53 PM

Autres manuels pour XPS 630i

Table des matières

Autres manuels Dell Ordinateur de bureau

Dell

Dell Precision Workstation 350 Manuel utilisateur

Dell

Dell Precision T3500 Manuel utilisateur

Dell

Dell OPTIPLEX 740 Manuel utilisateur

Dell

Dell Inspiron 5570 Manuel d'exploitation et d'entretien

Dell

Dell Dimension 0F0272A01 Manuel utilisateur

Dell

Dell Precision R5500 Manuel utilisateur

Dell

Dell PowerVault NX200 Manuel utilisateur

Dell

Dell XPS 8930 Manuel utilisateur

Dell

Dell PowerEdge T310 Manuel utilisateur

Dell

Dell POWEREDGE SC440 Manuel technique

Dell

Dell Alienware Area-51 ALX Instructions de fonctionnement

Dell

Dell Inspiron 23 Manuel utilisateur

Dell

Dell OptiPlex 790 Manuel utilisateur

Dell

Dell ubuntu Manuel utilisateur

Dell

Dell GX520 - OptiPlex - 512 MB RAM Manuel utilisateur

Dell

Dell P2418HZ Manuel utilisateur

Dell

Dell Inspiron 530sa Manuel utilisateur

Dell

Dell Inspiron 20 3000 Series Manuel utilisateur

Dell

Dell Precision M65 Manuel utilisateur

Dell

Dell Latitude 7000 Series Instructions d'utilisation et d'entretien

Dell

Dell OptiPlex 2U454 Manuel utilisateur

Dell

Dell Inspiron 3662 Manuel utilisateur

Dell

Dell XPS 27 Manuel utilisateur

Dell

Dell Inspiron One 2320 Manuel utilisateur

Manuels Ordinateur de bureau populaires d'autres marques

HP m9060n - Pavilion - Elite Fiche technique

Asus

Asus E210 Series Manuel utilisateur

TotalFlow

TotalFlow uFLO Manuel utilisateur

HP Presario SV7000 - Desktop PC Manuel utilisateur

HP ProDesk 400 G5 Manuel

Logitech

Logitech MK320 Manuel utilisateur

Sony

Sony Vaio Series Manuel utilisateur

Sony

Sony VGC-LT32E - Vaio All-in-one Desktop Computer Manuel utilisateur

Alto

Alto MD 250 Manuel utilisateur

Lenovo

Lenovo ThinkCentre Edge 72 Manuel

Lenovo

Lenovo ThinkStation D20 Manuel

Arbor Technology

Arbor Technology FPC-7800 Series Manuel utilisateur

Sony

Sony VAIO VGX-TP1 Series Manuel utilisateur

Asus

Asus Eee Box B204 Manuel utilisateur

HP Z1 Manuel utilisateur

Everex

Everex eXplora Manuel utilisateur

Lenovo

Lenovo ThinkCentre M75e Manuel utilisateur

Compaq

Compaq iPAQ Internet Device Manuel utilisateur