Dancover CA119011 Manuel utilisateur

06-07-2017

for

Folding Garage (Car)

2,5x5,4x2m

Manual

TABLE OF CONTENTS

1. GENERAL INFORMATION……………………………………………………………….…....3

1.1 Introduction………………………………………………………………………………...........3

2. BOX DESCRIPTION AND TECHNICAL SHEET………………………………………....….4

2.1 General description…………………………………………………………………………......4

2.2 Components………………………………………………………………………………..……5

2.3 Fabric’s characteristics……………………………………………………………………..…..8

3. INSTALLATION…………………………………………………………………………..........10

3.1 Handling and transport…………………………………………….......................................10

3.2 Place and requirements for the installation…………………………………………….…...10

3.3 Installation…………………………………………………………………………………...…10

3.3.1 Package opening……………………………………………………………………………10

3.3.2 Squared holding devices placement………………………………………………..........11

3.3.3 Box installation…………………………………………………………………………..….11

3.3.4 Bracing system………………………………………………………………….……..........12

3.3.5 Snails opening…………………………………………………………………………..…. .13

4. BOX UTILIZATION…………………………………………………………………….…….. .13

5. CHECKS AND MAINTENANCE………………………………………………………..........14

6. DISASSEMBLY…………………………………………………………………………….…..14

1. GENERAL INFORMATION

1.1. Introduction

This manual is an integral part of the product; it is addressed to the installer and to the final user of

the box, and enables a correct installation and use. For this reason it must be hold with the box

until proper disposal.

In this manual you will find the instructionsto:

•

correctly install the box

understandthe functions of the box and of the whole thereof

correctly do the box scheduled maintenance processes

take care of the basic safety rules

ATTENTION: the installer and the final user must read the whole manual in each part of

it. Keepthis manual in a safe and accessible place.

Before using the box, please read carefully the technical information contained in this

manual and follow them strictly.

2. BOX DESCRIPTION AND TECHNICAL SHEET

2.1. General description

The box must be used only as an ordinary protection cover, for purely temporary use. In case of

bad weather conditions (wind, snow), the box must be removed. Given that the box can not be

fixed to the ground - but only bound to it - its use in these conditions can cause damages to

people and things.

It is particularly important for safety not to hang or apply any type of load at the structure or at the

top cover of the box.

In particular, children must not handle the snails. The failure to respect the conditions of use and

warnings immediately voids the warranty.

BOX MODULARE/BOX MODULARE ECO 1 snail

BOX MODULARE/BOX MODULARE ECO 2 snails

A (cm): 410/480/550

B (cm): 250

C (cm): 200

A (cm): 470/540/610

B (cm): 250

C (cm): 200

2.2. Components

N. DESCRIPTION

1 ALUMINIUM PROFILE MM 45X15

2 ALUMINIUM PROFILE (gables)

3 SQUARED HOLDING DEVICE

4 SQUARED HOLDING DEVICE CAP

5 ANODIZED ALUMINIUM 120x60 FOOT

6 PVC COVERSOL/FABRITARP TOP COVER

7 ALUMINIUM LACQUERED RAL 9010 PLATE (crosses)

8 ALUMINIUM LACQUERED RAL 9010 PLATE (tension bars)

9 NYLON ROPE DIAM. MM 5

10 STRING FASTENER HANDLE

11 HINGE FASTENING RIVET

12 TENTMESH LATERAL COVER (only for Box Modulare)

13 FOOT WITH FINAL HINGE

14 FOOT WITH CENTRAL HINGE

15 FOOT WITH HINGE FOR HEAD-FASTENING PLATE

2.3. Fabric’s characteristics

COVERSOL

BOX MODULARE

Yarn Warp: 100% PES 280 Dtex

Weft: 100% PES 280 Dtex

Construction Warp: 16 yarn/cm

Weft: 16 yarn/cm

Fabric’s weight Ca 400 gr/m2

Tensile strength Warp: Ca 120 DaN/5 cm

(DIN 53354) Weft: Ca 130 DaN/5 cm

Tearing resistance Warp: Ca 5,5 DaN

(DIN 53363) Weft: Ca 7,5 DaN

Grip (ISO 2411) Ca 6 DaN/5 cm

Temperature resistance +70°C/-30°C

Light resistance (DIN 53388) Level: 7/8

Finishing Gloss lacquered (one side)

UV Treated

LG 450

BOX MODULARE ECO

Coating PVC

Fabric’s weight Ca 450 gr/m2

Tensile strength Warp: Ca 250 DaN/5 cm

(DIN 53354) Weft: Ca 180 DaN/5 cm

Tearing resistance Warp: Ca 25 DaN

(DIN 53363) Weft: Ca 25 DaN

Hot / cold resistance

+70° C/ -30°C

Finishing 1 side gloss lacquered

3. INSTALLATION

3.1. Handling and transport

The box installation should only be done by qualified staff.

The products must be unloaded through appropriate lifting equipment, which must be used only by

authorized staff.

If the unloading operation is made by hand, it is important to consider that the weight limit that each

person can handle is 25 Kg; moreover, the operators should be equipped with gloves and safety

shoes.

3.2. Place and requirements for the installation

Before the arrival of the installers the user must arrange:

•any permits required by local regulations

•appropriate ground

3.3. Installation

Before starting the installation, if electrical equipment utilization is needed:

•make sure you do not work in wet areas

•use only intact extension cords, according to the place of use

•use shoes with rubber soles

ATTENTION: it is necessary for the operators to use appropriate personal protective

equipment such as safety shoes and gloves, in order to avoid injuries provoqued by the

fall of the packaging or of components that it contains, perforation and cutting due to

cutting or hanging parts.

3.3.1. Package opening

Packaging must be opened only with scissors with rounded tips, using the best care not to cut the

cloth of the article (Photo 1).

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Dancover Tente

Dancover

Dancover TentZing CT168040 Manuel utilisateur

Dancover

Dancover Semi PRO 5x10m Manuel utilisateur

Dancover

Dancover Arched PE Manuel utilisateur

Dancover

Dancover Patio Cover Expert 3x5m Manuel utilisateur

Dancover

Dancover AQUILA Manuel utilisateur

Dancover

Dancover PRO XL Manuel utilisateur

Dancover

Dancover Teepee Manuel utilisateur

Dancover

Dancover 3m storage pro Manuel utilisateur

Dancover

Dancover Titanium Tent Manuel utilisateur

Dancover

Dancover Marquee 10x15 m PRO+ EventZone Manuel utilisateur

Dancover

Dancover CombiTent SEMI PRO AC18026 Manuel utilisateur

Dancover

Dancover TentZing Manuel utilisateur

Dancover

Dancover Garage tent 3,77x7,3x3,24m PVC Manuel utilisateur

Dancover

Dancover CA119071 Manuel utilisateur

Dancover

Dancover PRO EventZone 9m Series Manuel utilisateur

Dancover

Dancover Basic-1339H Manuel utilisateur

Dancover

Dancover Multipavillon 6x9m Manuel utilisateur

Dancover

Dancover 5.4m Series Manuel utilisateur

Dancover

Dancover Crestline 2L Manuel utilisateur

Dancover

Dancover PRO EventZone 9m Series Manuel utilisateur

Dancover

Dancover 2,4m Series Manuel utilisateur

Dancover

Dancover ProShed MS572012 Manuel utilisateur

Dancover

Dancover TentZing CT168200 Manuel utilisateur

Dancover

Dancover Oceancover PVC Manuel utilisateur

Manuels Tente populaires d'autres marques

OZTENT

OZTENT JV SIGNATURE EDITION Manuel utilisateur

GigaTent

GigaTent Summer Chalet Mini Tent Manuel utilisateur

Coleman

Coleman 2000007827 Manuel

ShelterLogic

ShelterLogic 107153 Manuel utilisateur

Outsunny

Outsunny 84C-230 Manuel utilisateur

Napier

Napier SPORTZ COVE 61 Series Manuel utilisateur

EuroTrail

EuroTrail ATLANTIS PRO Manuel utilisateur

Reimo

Reimo Marina Manuel utilisateur

TiiTENT

TiiTENT TB300 Manuel utilisateur

Coleman

Coleman 2000033134 Guide d'installation

Ozark Trail

Ozark Trail W784.1 Guide de démarrage rapide

SlingFin

SlingFin CrossBow 2 Manuel utilisateur

Coleman

Coleman 9600-141 Manuel utilisateur

Palram

Palram Arizona 5000 Wave - WINGS Manuel utilisateur

COVERPRO

COVERPRO 56184 Instructions de montage

Vango

Vango Zenith 100 Manuel utilisateur

Costway

Costway PATIOJOY OP70818 Manuel utilisateur

Clarke

Clarke PUC 88 Manuel utilisateur