CYBEX 600T Manuel utilisateur

Cybex 600T Treadmill Service Manual

Cardiovascular Systems

Cybex and the Cybex logo are registered trademarks of Cybex International, Inc. Stableflex and the Stableflex logo are registered

trademarks

Cybex International,Inc.Polar is aregistered trademark of Polar.

DISCLAIMER: Cybex International, Inc.

makes

representations

warranties

regarding

the

contents

this

manual. We

reserve

the

right

revise

this

document

any

time

make

changes

the

product

described

within

without

notice

obligation

notify

any

person

such

revisions

changes.

United States

America.

10 Trotter Drive Medway,MA 02053 •888-GO-CYBEX •888-462-9239 •508-533-4300 •

FAX

508-533-5183

www.eCybex.com·techhelp@cybexintl.com·[email protected] •SM-15650 •September 2000

Cybex 600T Treadmill Service Manual

Read All Instructions &Warnings Before

Using Grounding Instructions

This treadmill is intended for commercial use. This treadmill must be grounded. If it should

malfunction

break down, grounding provides apath

least resistance for electric current

to reduce the risk

electric shock. This product is equipped with acord having

equipment-grounding conductor and agrounding plug. The plug must be plugged into

appropriate outlet that is properly installed and grounded

accordance with all local codes

and ordinances.

!DANGER:

Improper

connection

the

equipment-grounding

conductor

can

result

in a

risk

electric

shock.

Check

with

qualified

electrician

service

provider

you

are

doubt

whether

the

treadmill

properly

grounded. Seek a

qualified

electrician to

perform

any

modifications

the

cord

plug. Cybex is

not

responsible

for

injuries

damages

result

cord

plug

modification.

This treadmill is for use on anominal 115

VAG

±10%, 60 Hz and 20 amps or a220

VAG

±15%, 50 Hz/60 Hz and 15 amps grounded, dedicated circuit. Make sure that the treadmill is

connected

outlet having the same configuration as the plug.

not use aground plug

adapter to adapt the power cord

anon-grounded outlet.

115V

NEMA 5-20 Euro Plug

GEE

717

208/220V

NEMA 6-15

Pagei

Page ii

Cybex 600T Treadmill Service Manual

Important Safety Instructions

(Save These Instructions)

!DANGER:

reduce

the

risk

electric

shock, always

unplug

this

treadmill

from

the

electrical

outlet

immediately

after

using

and

before

cleaning it.

!WARNING: Serious

injury

could

occur

these

precautions

are

not

observed.

reduce

the

risk

burns, fires,

electric

shock,

injury:

•Obtain amedical exam before beginning any exercise program.

•Keep children away from the treadmill. Teenagers and disabled persons must be

supervised while using.

•Stop exercising if you feel faint, dizzy, or experience pain at any time while exercising

and consult your physician.

•Use

the

treadmill handrails

for

support

and

maintain balance.

•Disconnect all power before servicing the treadmill.

•Use adedicated line when operating the treadmill.

•Connect the treadmill to aproperly grounded outlet only.

•

not operate electrically powered treadmills

damp or wet locations.

•Stop and place the treadmill at 0degrees incline (level) after each use.

•

not leave the treadmill unattended when plugged

and running. After turning off the

treadmill, don'tleave it until it comes to acomplete stop and is level.

disconnect,

turn all controls to the

STOP

OFF

position, and then remove the plug from the outlet.

•Inspect the treadmill for worn or loose components before each use.

not use until

worn or damaged parts

are

replaced.

• Maintain and replace worn parts regularly. Refer to

Preventative Maintenance

Section

of Owner'sManual.

•

not operate the treadmill if the cord is damaged, if the treadmill is not working

properly, or if the treadmill has been dropped or damaged. Seek service from aqualified

technician.

Cybex 600T Treadmill Service Manual

•

not place the cord near heated surfaces or sharp edges.

•

not use the treadmill outdoors.

•

not operate the treadmill around or where aerosol (spray) or where oxygen products

are being used.

•

Read

and understand the Owner'sManual completely before using the treadmill.

•

Read

and understand emergency stop procedures.

•

Read

and understand all warnings posted on the treadmill.

•Replace any warning label if damaged, worn or illegible.

•

not wear loose or dangling clothing while using the treadmill.

•Proper footwear should always be worn on or around exercise equipment.

•Keep

all

body parts,

hair,

towels, water bottles, and the like free and clear

moving

parts.

•Set up and operate the treadmill on asolid, level surface.

not operate

recessed

areas or on

ush carpet.

•Provide the following clearances: 39 inches

at each side, 78 inches

at the

back, and enough room for safe access and passage at the front

the treadmill. Be

sure your treadmill is clear

walls, equipment, and other hard surfaces.

•

not attempt repairs, electrical or mechanical. Seek trained repair personnel when

servicing. Contact the nearest authorized Cybex dealer or other competent repair

service.

•Use Cybex factory parts when replacing parts on the treadmill.

•

not modify the treadmill

any

way.

•

not use attachments unless recommended for the treadmill

Cybex.

•Report any malfunctions, damage or repairs to the facility.

•

not use the treadmill if you exceed 350 Ibs. (157

kg).

This is the rated maximum user

weight.

Page iii

Pageiv

Cybex 600T Treadmill Service Manual

About This Manual

For your convenience, all measurements and voltage requirements are listed

both English

and metric units. English values are listed first, followed by metric units

parentheses. For

example: 1" (2.54 cm).

Owner's Manual

shipped with each 600T Treadmill.

purchase acopy

the Service

Manual contact Cybex Customer Service at 888-462-9239 or 508-533-4300.

contact Cybex with comments about this manual you may send email to

[email protected].

Important Voltage Information

Before you assemble your

600T,

check to make sure that the treadmill has the correct voltage

requirements for your area, and that you have the correct model.

check for the correct model and voltage requirements, locate the serial number label and

voltage label. Your serial number can be found on the rear crossbar under the running deck.

The voltage of your treadmill can be found on alabel near the on/off (I/O) switch.

The power requirements for this treadmill

are

115

VAC

±10%, 60 Hz and 20 amps or a220

VAC

±15%, 50 Hz/60 Hz and 15 amps grounded, dedicated circuit.

!WARNING: Do

not

attempt to use this unit with avoltage adapter.

!WARNING: Do

not

attempt to use this unit with an extension cord.

FCC Compliance Information

!WARNING: Changes

modifications to this unit

not

expressly approved

the party

responsible for compliance could void the user's authority to operate the

equipment.

This equipment has been tested and found to comply with the limits for aClass Adigital

device, pursuant to Part 15 of the FCC Rules. Operation is subject to the following

two

conditions:

(1)

This device may not cause harmful interference, and

(2)

this device must

accept any interference received, including interference that may cause undesired operation.

Cybex 600T Treadmill Service Manual

Declaration

Conformity

Treadmill

600T (220V)

Attention: European Sales Director

Room

Floor

Tredegar Chambers,

Bridge Street, Newport,

South Wales, NP204AQ Phone 011-44-1633-251222

We declare that to the best

our knowledge that the fitness

equipment listed below, and manufactured by:

Cybex International, Inc.

10 Trotter Drive

Medway MA, 02053, USA

Conforms to:

Directives: 73/23/EEC, 89/336/EEC

Standards:

957-1, EN60335-1, EN55022, EN55014, EN50082-1

Product Name:

Model Number:

European Contact:

NOTE: For European customers only.

Page v

Page vi

Cybex 600T Treadmill Service Manual

Table of Contents

iRead All Instructions and Warnings

ii Important Safety Instructions

About

This Manual

Important Voltage Information iv

FCC Compliance Information iv

VDeclaration

Conformity

vii

Table

Contents

1Safety

Warning Decals 1-1

Caution Decals 1-2

2Technical Specifications

Specifications 2-1

3Preventative Maintenance

Regular Maintenance Activities 3-1

Running Belt Maintenance 3-3

4Troubleshooting

Test

Mode

4-1

LED Functions 4-1

Key Functions

4-2

Error Codes

4-2

Speed Sensor Adjustments

4-3

5Removal &Replacement

Running

Deck

5-1

Running Belt

5-5

Front Roller

5-5

Drive Belt 5-5

Rear Roller

5-6

Drive

Motor

. . . . . . . . . . ... . . .. . . . .

5-7

Motor

Brush 5-1 0

Elevation

Motor

5-13

Lower Control Board .5-15

Power Cables 5-16

Line Filter 5-17

Power Switch 5-17

Power Cord Inlet 5-18

Display Board 5-18

Heart Rate Board 5-20

Lower Display Board 5-21

Polar Board 5-21

Upper

Display Cable 5-22

Lower Display Cable 5-24

Display Overlays 5-25

6Diagrams

Parts List 6-1

Exploded View

6-3

600T Schematic 6-4

7Customer Service

Contacting Service 7-1

Serial Number &Voltage 7-1

Return Material Authorization (RMA)

7-1

Damaged Parts 7-2

8Index

8-1

Page vii

Autres manuels pour 600T

Table des matières

Autres manuels CYBEX tapis roulant

CYBEX

CYBEX 750T Manuel utilisateur

CYBEX

CYBEX 525T Manuel utilisateur

CYBEX

CYBEX LT-16602-4 Guide d'application

CYBEX

CYBEX LCX-425T Manuel utilisateur

CYBEX

CYBEX 400T Manuel d'utilisation

CYBEX

CYBEX 525T Manuel utilisateur

CYBEX

CYBEX 710T Manuel utilisateur

CYBEX

CYBEX Pro+ Guide d'application

CYBEX

CYBEX V Series Manuel utilisateur

CYBEX

CYBEX 770T-CT Manuel utilisateur

CYBEX

CYBEX PRO3 Manuel utilisateur

CYBEX

CYBEX CardioTouch 770T Manuel utilisateur

CYBEX

CYBEX CX-445T Manuel utilisateur

CYBEX

CYBEX 750T Manuel utilisateur

CYBEX

CYBEX Pro+ Guide d'application

CYBEX

CYBEX 625T Manuel utilisateur

CYBEX

CYBEX LCX-425T Manuel utilisateur

CYBEX

CYBEX 790T Manuel utilisateur

CYBEX

CYBEX Pro+ Manuel utilisateur

CYBEX

CYBEX Pro+ Manuel utilisateur

CYBEX

CYBEX 600T Manuel utilisateur

CYBEX

CYBEX LCX-425T Manuel utilisateur

CYBEX

CYBEX LT-24467-4 F Manuel utilisateur

CYBEX

CYBEX 770T-CT Manuel utilisateur

Manuels tapis roulant populaires d'autres marques

Treadly

Treadly TREADLY 2 Manuel utilisateur

HEALTH ONE

HEALTH ONE Walk Ro Manuel utilisateur

NordicTrack

NordicTrack NTL12941 Manuel utilisateur

NordicTrack

NordicTrack T7.5 S Manuel utilisateur

Gold's Gym

Gold's Gym ADVANTAGE GGTL12920 Manuel utilisateur

Merax

Merax MS282992 Manuel utilisateur

FYTTER

FYTTER RU-2SX Manuel utilisateur

Precor

Precor 903 Manuel utilisateur

FitLogic

FitLogic freewill d225 Manuel utilisateur

HOP-SPORT

HOP-SPORT ESTIMA HS-3200LB Manuel utilisateur

Horizon Fitness

Horizon Fitness Adventure 5 Plus Manuel utilisateur

Stamia

Stamia InMotion II Manuel utilisateur

Smooth Fitness

Smooth Fitness EVO 3i Manuel utilisateur

NordicTrack

NordicTrack NETL81810.0 Manuel utilisateur

Schwinn

Schwinn 830/Journey 8.0 Manuel utilisateur

Keys Fitness

Keys Fitness HealthTrainer HT-740T Manuel utilisateur

Spirit

Spirit XT8 Manuel utilisateur

NordicTrack

NordicTrack T 14.0 Treadmill Manuel utilisateur