Bosch C 1210 ESC Manuel de référence

Technical Service Bulletin:

C6 & C7 Error Code Troubleshooting

Models: C1210ESC, C1210ES, C1050ES, C950ES, 940ES, 940ESO, 830ES, 2400ES,

2700ES, 715ES, C800ES, C920ES/ESC, Integra 500, Evolution 500

Introduction

This procedure must be performed by a qualiﬁed technician.

DANGER!

120 VAC present in wire connections. Use caution

when testing.

Follow the procedures below and report results to Bosch Technical

Support. This will assist in determining the cause and solution to the

problem.

C6 and C7 error codes

These errors are fan-related error codes with the following

explanations:

C6 error indicates the primary fan rotation is too low during

operation.

C7 error indicates there is no primary fan rotation sensed

during an attempted start-up.

Primary Fan Assembly

The primary fan is a 120 volt AC fan that receives power from

the main control board.

The primary fan has its own built-in circuit board which relays

information and signals back to the control board.

Tools needed:

Phillips head screwdriver

Digital Multi-meter

Procedure

1. Press the reset button on the control panel of the heater to

attempt to clear the error code. If the error code does not reset

or continues to reoccur, proceed with the following trouble-

shooting steps.

2. Conﬁrm that the exhaust vent is not blocked and does

not exceed the speciﬁed maximum length as shown in the

installation manual.

3. Ensure that the 3 foot minimum separation between air intake

and exhaust vents is met (applies to a twin pipe vent system).

4. Verify the heater is plugged into a properly grounded 120V AC

power supply.

5. Supply the heater with a steady supply voltage. It is

recommended to supply electricity from a dedicated electrical

circuit with no other major appliances on the same circuit.

6. Shut off power to the heater and unplug from electrical outlet.

Remove cover per installation manual.

7. Remove the black plastic intake (Fig.1, pos.1) that is secured

with three Phillips head screws to the fan (Fig.1, pos.2).

Figure 1

8. Check the wire connection to the fan. The wire connection is

located on the back, left hand side of the fan housing. (Fig. 2).

Data subject to change without notice | Printed in the USA | BTC 740002330 A | 05.2014 Bosch Thermotechnology Corp.

Technical Service Bulletin

2 | C6 & C7 Error Code Troubleshooting

Bosch Thermotechnology Corp.

50 Wentworth Avenue

Londonderry, NH 03053

Tel: 1-800-283-3787

Fax: 1-603-965-7581

www.bosch-climate.us

Figure 2

9. Check that the wire connections to the control board are ﬁrmly

attached to the board. Removal of the lower access cover on

the control board is required. Refer to Bulletin TWH-G3-24.

10. Remove wire connection from back of fan, plug in heater and

turn power on with water shut off. Check for voltage AC on the

plug between the 1st and 2nd pin. You should ﬁnd 120VAC (Fig.

Figure 3

a. If the plug shows 120 VAC between the pins, the

primary fan needs to be replaced.

b. If the plug shows no voltage between the pins; shut

power off, disconnect plug from the outlet, and check

the 2.5A white fuse inside of the control unit (Fig. 4).

Refer to Bulletin TWH-G3-24. If the 2.5A white fuse has

continuity, then the control unit needs to be replaced.

c. If the 2.5A fuse is blown, replace with spare from the

back cover of the control unit, remove the connection

from the primary fan, and remove both wire connections

from the secondary fan (Fig. 5).

d. Reconnect primary fan only, turn power on, run

water for 30 seconds. LEAVE SECONDARY FAN

DISCONNECTED

Figure 4

Figure 5

e. If fan turns on, unit ignites, and/or E4, then shut the

power off and reconnect the secondary fan. If C6 or C7

and/or the fuse blows before connecting the secondary

fan then the primary fan needs to be replaced.

f. With both primary and secondary fans connected, turn

power on, and run water. If no issues, then just a bad

fuse. If the 2.5A fuse blows then the secondary fan

needs to be replaced.

After completing this procedure, please call us while still at

the unit at 1-800-798-8161 for diagnosis and resolution. If

it is more convenient for you, please email the results of

this procedure to ldy[email protected] and we will reply

within one business day.

Autres manuels pour C 1210 ESC

Ce manuel convient aux modèles suivants

Autres manuels Bosch Chauffe-eau

Bosch

Bosch WT 11 AM1 E Mode d’emploi

Bosch

Bosch GWH-425-HN-N Manuel utilisateur

Bosch

Bosch TF250 Document technique

Bosch

Bosch AquaStar 125B LPS Manuel

Bosch

Bosch TR6000R 18/21 ESOB Manuel utilisateur

Bosch

Bosch Tronic 1000T ES 035-4 M 0 WIV-B Manuel d'utilisation

Bosch

Bosch PROTANKLESS GWH 345 Manuel utilisateur

Bosch

Bosch TR1000 4 T Manuel utilisateur

Bosch

Bosch HydroPower 10H Manuel utilisateur

Bosch

Bosch Evolution 500 Manuel utilisateur

Bosch

Bosch AquaStar 125HX NG Manuel utilisateur

Bosch

Bosch 940ES Manuel utilisateur

Bosch

Bosch Stora WP 400 PK Guide rapide

Bosch

Bosch BC3200RA Manuel utilisateur

Bosch

Bosch WR8 series Document technique

Bosch

Bosch 8 718 686 408 0 Guide de démarrage rapide

Bosch

Bosch GWH C 920 ES Manuel de référence

Bosch

Bosch AquaStar 125X LP Manuel utilisateur

Bosch

Bosch TRONIC 6000C WH17 Document technique

Bosch

Bosch Tronic 3000T ES 2.5 Manuel utilisateur

Bosch

Bosch TR7000 Series Manuel utilisateur

Bosch

Bosch 125B LP Manuel utilisateur

Bosch

Bosch TR7000R Series Manuel utilisateur

Bosch

Bosch AquaStar 125HX LP Manuel utilisateur

Manuels Chauffe-eau populaires d'autres marques

Kenmore

Kenmore 153.582400 Manuel utilisateur

Applimo

Applimo Edel AIR Manuel utilisateur

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manuel utilisateur

clage

clage E-Mini Series Manuel utilisateur

Toyotomi

Toyotomi Oil Miser OM-180 Manuel utilisateur

Bradford White

Bradford White EF Series Manuel utilisateur

Eccotemp

Eccotemp 40-H Manuel utilisateur

Dimplex

Dimplex ECSd125-580 Mode d’emploi

Dux

Dux 32FCR6N Manuel utilisateur

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guide de dépannage

Noritz

Noritz N-132M Manuel d'instructions

TESY

TESY GCV7/4S 10047 Fiche technique

A.O. Smith

A.O. Smith Gphe 50 Manuel utilisateur

Koryo

Koryo KWHZF15Y Manuel utilisateur

Pentair

Pentair PSC-14-4-02 Manuel utilisateur

GE 40M06AAG Instructions de montage

Thermor

Thermor AEROMAX SPLIT 2 Manuel utilisateur

American Hometec

American Hometec AHQ-B03X Manuel utilisateur