Bosch C 1210 ESC Manuel de référence

Technical Service Bulletin:

Removing & Replacing The Water Valve

Models: C1210ESC, C1210ES, C1050ES, 940ES, 940ESO, 830ES

Introduction

 When replacing the watervalve, it is very important to drain all

water from the water heater beforehand to prevent water

damage to the internal electronics.

Tools needed:

 Phillips head screwdriver

 Bucket to catch draining water

 Plumber’s grease

Removing the water valve

1. Press On/Off button to Off and unplug power cord from electrical

outlet.

2. Loosen two Phillips head screws located at bottom rear of cover.

(Fig. 1).

3. Lift front cover upward and remove. (Fig. 1).

Step 1 Step 2

tep

Figure 1

4. Remove 3 Phillips screws from control unit (Fig. 2, step 1)

4. Place water heater‘s control unit into the service position.

(Fig. 2, step 2).

Step 2Step

Figure 2

Water

valve

5. Close installer supplied inlet and outlet shutoff valves.

6. Relieve water pressure from unit by opening pressure relief valve

on hot outlet side of unit. Have a bucket ready to catch the

draining water. Drain water from unit by removing cold water

inlet connection on bottom of heater.

Data subject to change without notice | Printed in the USA | BTC 740002319 A | 07.2010 Bosch Thermotechnology Corp.

Technical Service Bulletin

18 | Removing & Replacing The Water Valve

Bosch Thermotechnology Corp.

50 Wentworth Avenue

Londonderry, NH 03053

Tel: 1-866-642-3198

Fax: 1-603-584-1687

www.boschpro.com

7. Unplug smaller wire connectors (A) from water valve.

(Fig. 3).

8. Remove pipe clips (C) located at the base and side of water

valve. (Fig. 3).

9. With a rag ready to catch residual water, lift water valve upwards

to separate it from the brass inlet connection (D). (Fig. 3).

Please note certain models may not have a water lter screen in

the base of the water valve.

10. Again with a rag ready to catch residual water, pull water valve

from pipe (E). (Fig. 3).

11. Remove water valve from heater and remove main wire plug

connection (B) from water valve. (Fig. 3)..

Figure 3

Replacing the water valve

1. Lubricate o-rings (F) with plumbers grease to prevent o-ring

damage or leaks. (Fig. 3).

2. Install replacement water valve by seating the side pipe

connection (E) rst (Fig. 3). Be careful to push water valve body

past o-ring on connecting pipe.

3. Reconnect clip (C) for side pipe connection. (Fig. 3).

4. Reinstall water valve onto brass inlet tting (D) (Fig. 3). Be

careful to seat water valve body past o-ring on inlet tting.

5. Reconnect remaining clip (C) on inlet tting connection (Fig. 3).

6. Check that both clips (C) are seated correctly in the anges

(Fig. 2). Improper seating will result in water leaks.

7. Reconnect main wire plug connection (B) to water valve. (Fig. 3).

8. Reconnect smaller wire connectors (A) for the water valve and

temperature sensor wires. (Fig. 3).

9. Open installer supplied inlet and outlet shutoff valves and

inspect for water leaks.

10. If no water leaks are present, return control unit to normal

position and secure with 3 Phillips screws (Fig 2). Plug power

cord into electrical outlet and push power button back to "On"

position. If an error code appears on the heater display, reset

the unit with the reset button. If error code reappears on the

display, press power switch to Off and check all wire

connections.

11. Push power switch back to On. If no errors are present, replace

cover and return heater to normal operation.

Autres manuels pour C 1210 ESC

Ce manuel convient aux modèles suivants

Autres manuels Bosch Chauffe-eau

Bosch

Bosch TR8500 21/24 DESOAB Manuel utilisateur

Bosch

Bosch W 325 K**T1 Manuel du propriétaire

Bosch

Bosch DHW Tank QWST120 O Manuel utilisateur

Bosch

Bosch AQUASTAR 125B LPL operati Manuel utilisateur

Bosch

Bosch WR 11 G Series Document technique

Bosch

Bosch Therm 6000 S Manuel utilisateur

Bosch

Bosch TRONIC 6000C WH17 Document technique

Bosch

Bosch RDH 1810 Manuel utilisateur

Bosch

Bosch AquaStar 125B LPS Manuel

Bosch

Bosch Therm 6000 S Manuel utilisateur

Bosch

Bosch TR1500TOR 5 T Manuel utilisateur

Bosch

Bosch TR2000T Series Manuel d'utilisation

Bosch

Bosch TR2500TO 5 B Manuel utilisateur

Bosch

Bosch AE12 Manuel utilisateur

Bosch

Bosch Integra 500 Series Manuel de référence

Bosch

Bosch WR400 K T2 Series Manuel du propriétaire

Bosch

Bosch 13P Manuel

Bosch

Bosch OptiFlow Professional GWH16 1 CTD E23 F5 L Manuel utilisateur

Bosch

Bosch C1210ES Manuel utilisateur

Bosch

Bosch TR5000 24/27 EB Manuel utilisateur

Bosch

Bosch C 1210 ESC Manuel utilisateur

Bosch

Bosch 715ES Manuel utilisateur

Bosch

Bosch Greentherm T9800 SEC 160/199 Manuel utilisateur

Bosch

Bosch BBT NORTH AMERICA AquaStar 240FX Manuel de service

Manuels Chauffe-eau populaires d'autres marques

Kenmore

Kenmore 153.582400 Manuel utilisateur

Applimo

Applimo Edel AIR Manuel utilisateur

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manuel utilisateur

clage

clage E-Mini Series Manuel utilisateur

Toyotomi

Toyotomi Oil Miser OM-180 Manuel utilisateur

Bradford White

Bradford White EF Series Manuel utilisateur

Eccotemp

Eccotemp 40-H Manuel utilisateur

Dimplex

Dimplex ECSd125-580 Mode d’emploi

Dux

Dux 32FCR6N Manuel utilisateur

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guide de dépannage

Noritz

Noritz N-132M Manuel d'instructions

TESY

TESY GCV7/4S 10047 Fiche technique

A.O. Smith

A.O. Smith Gphe 50 Manuel utilisateur

Koryo

Koryo KWHZF15Y Manuel utilisateur

Pentair

Pentair PSC-14-4-02 Manuel utilisateur

GE 40M06AAG Instructions de montage

Thermor

Thermor AEROMAX SPLIT 2 Manuel utilisateur

American Hometec

American Hometec AHQ-B03X Manuel utilisateur