AUTOFRY MTI-5 Manuel utilisateur

Model MTI-5

Operator's Manual

A Patented Product of

Motion Technology, Inc.

6 Huron Drive

Natick, MA 01760

Telephone: (508) 653-0082

Technical Support: 888-664-6640

MTI Form OP

0005 Rev.

002 7/98

E167653

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

AUTOFRY Model MTI-5 Specifications

Electrical Specifications:

Consult wiring diagram at the end of this document for specific ratings.

240V ac single-phase grounded 50/60HZ

4200 Watt

16.67AMPS

NEMA 6-20 Plug Configuration

INTERNATIONAL ONLY

NO PLUG ATTACHMENT

230V ac single-phase grounded 50/60Hz

2950 Watt

13.00 AMPS

US Replace cord set with Motion Technology, Inc. cord set ONLY part number 52097

Physical Specifications:

Materials: 304 Stainless Steel

Dimensions: 21"x21"x21"

Clearances: Left side = 2" Min.

Right side = 12" (for heat lamp)

Rear = 3" Min.

Top = 24" Min.

Oil capacity: 2.5 US Gallons

Approvals and Listings

UL cUL NSF CE CSA

AUTOFRY and NO HOODS! NO VENTS! NO PROBLEM? are registered

trademarks of Motion Technology, Inc.

MTI Form OP-0005 Rev. 002 7/98

E167654

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

Table of Contents

Prepare electrical service 3

Prepare counter top 4

Set-up and Installation 3

Remove components 4

Re-set high limit 4

Leg installation 5

Initial cleaning 6

Install charcoal filter 7

Install oil pot 8

Install heater box 8

Install food basket clip 9

Install food basket 9

Add liquid shortening 10

Install food exit chute 10

Power 11

Let's get cooking 12

Starting the AUTOFRY 12

Begin cooking 13

During cooking 14

Shut off procedure 14

Additional keypad functions 15

Count button 15

Stand-by button 16

Programming cook times 18

Recommended Cleaning Schedule 20

Daily cleaning 21

Weekly cleaning 22

Quarterly cleaning 23

Charcoal filter 24

Semi-annual 24

Fire system 25

Safety system test

MTI Form OP-0005 Rev. 002 7/98

E167654 2

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

AUTOFRY MTI-5 Rev. 2 Set-up and Installation

The AUTOFRY comes from the factory complete with everything you will need to

start cooking with the exception of food and oil. By following these simple

instructions you can have your AUTOFRY installed and ready to earn profits for

you in as little as 30 minutes.

Prepare electrical service.

A licensed electrician in accordance with the National Electrical Code (NEC) and

all local codes must install electrical service. Do not alter the factory supplied

power cord or plug. Never attach the AUTOFRY to an extension cord. Consult the

Identification Tag for equipment wattage and voltage.

Motion Technology, Inc. will not assume responsibility for

any injuries or equipment malfunctions resulting from

non-conforming electrical installations.

Prepare counter top.

Choose a counter top location that is sturdy, level, easily cleanable and fire

resistant. Stainless steel, fire resistant plastic laminate or solid surface materials

are acceptable. Never use a porous material to prepare food as bacterial

contamination could result.

MTI Form OP-0005 Rev. 002 7/98

E167654 3

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

AUTOFRY Installation.

You will need assistance to position and install the AUTOFRY. The

approximate weight of the unit is 130 pounds

1.Remove and save the packing materials.

Be sure to inspect the AUTOFRY. Your AUTOFRY has left the factory in

perfect condition and has been packaged to withstand rugged travel.

However, in the event that you observe damage to the AUTOFRY, you should

contact the carrier immediately and report any damages. Be sure that you

have your signed bill of lading.

2.Take out the removable components from inside the AUTOFRY.

•4 adjustable legs

•Food exit chute

•Wire food basket

• * Heater box assembly

•Oil pot

*Check the red high limit re-set button on the bottom of the heater box

assembly by fully depressing it with the eraser end of a pencil. If the limit has

been tripped you will hear a "click" (see Figure 1).

MTI Form OP-0005 Rev. 002 7/98

E167654

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

3.Charcoal filter removal and leg installation.

•With the AUTOFRY still on its shipping pallet, tilt the unit backward and remove the

charcoal filter from the food exit cutout.

•Install two of the adjustable legs by rotating them clockwise to a hand tight fit into

the front two leg plates located on the underside of the AUTOFRY.

•Tilt the AUTOFRY forward and repeat the leg installation for the rear two legs (see

Figure 2).

4.Place on counter.

•Carefully place the AUTOFRY on the counter

•Adjust the legs (as needed) to level the AUTOFRY.

•Make sure that nothing is placed on top of the AUTOFRY Which could

obstruct the exhaust system.

MTI Form OP-0005 Rev. 002 7/98

E167654

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

5. Initial Cleaning.

•Wash the oil pot, wire food basket and food exit chute in warm

soapy water followed with a clear water rinse.

•Remove the food exit chute by turning the food chute knob

counterclockwise (see Figure 3A).

•Separate the two-piece food entry chute and wash in warm soapy

water followed with a clear water rinse (see Figure 3B).

6. Sanitize parts.

•All parts must be sanitized in a quaternary ammonia or iodine solution at a

temperature of at least 75° F following the manufacturers label instructions.

• Re-assemble and re-install the clean dry parts.

MTI Form OP-0005 Rev. 002 7/98

E167654 6

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

.Install Charcoal Filter

•Remove the filter cover plate from the back interior wall of the

cooking chamber by removing the two black plastic knobs securing

the cover plate (see Figure 4). " Remove the charcoal filter from the plastic

bag with the flange facing

down and facing you insert it into the tracks above the second filter

(see Figure 5).

•Re-install the filter cover plate by turning the black plastic knobs clockwise

to a hand tight fit. Verify that the word "TOP" on the filter cover plate is in the

upper left-hand corner (see Figure 4).

If the filters or the filter cover plate are not installed or installed

incorrectly the AUTOFRY will display Sft at start-up.

Both the grease baffle and the second filter have small holes

along the one side of the frame. These drain holes must be

facing down in order for the filters to efficiently drain and clean

the air (see Figure 5).

.Sanitize interior.

All interior surfaces must be sanitized in a quaternary ammonia or iodine

solution at a temperature of at least 75° F following the manufacturer's label

instructions.

MTI Form OP-0005 Rev. 002 7/98

E167654

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

Install oil pot.

•Place the oil pot into the cooking chamber. Ensure that the taller of the

two oil pot handles is towards the rear of the cook chamber and that both

handles are fully lowered (see Figure 6).

Experience has shown that a light application of Kote® brand soil

shield or Pam® on the exterior surfaces of the oil pot will prove

helpful when it is time to clean the oil pot.

Install the heater box assembly.

?Install the heater box assembly onto the heater box deck located to the

left of the oil pot. Ensure that the heater box assembly seats firmly onto

the sockets (see Figure 7).

MTI Form OP-0005 Rev. 002 7/98

E167654

AUTOFRY Models MTI-5 Rev. 2 Operator's Manual

Install the food basket clip.

•Install the food basket clip onto the two mounting buttons located to the

right of the door opening by aligning the holes in the clip over the buttons

(see Figure 8).

Install the food basket

•Install the square end of the basket rod into the cam located on the rear

wall of the AUTOFRY (see Figure 9A).

•Lower the round end of the basket rod into the basket clip. (see Figure

9B).

MTI Form OP-0005 Rev. 002 7/98

E167654 9

Table des matières

Autres manuels AUTOFRY Friteuse

AUTOFRY

AUTOFRY MTI-40E Manuel utilisateur

AUTOFRY

AUTOFRY FFG-10 Manuel utilisateur

Manuels Friteuse populaires d'autres marques

Innsky

Innsky 55SA1US Manuel utilisateur

Falcon

Falcon G350/11 Guide de l'utilisateur

GoWISE USA

GoWISE USA GW22612 Manuel utilisateur

Wolf

Wolf IF15/S Manuel utilisateur

Electrolux

Electrolux Thermetic 9CHG583284 Guide rapide

Gourmia

Gourmia GAF799 Manuel utilisateur

DeLonghi

DeLonghi D677UX Manuel utilisateur

SEVERIN

SEVERIN DEEP FRYER - Guide de l'utilisateur

Toastmaster

Toastmaster TMFG18-NAT Manuel utilisateur

Domo

Domo DO465FR Manuel utilisateur

Henny Penny

Henny Penny PFG-691 Manuel utilisateur

Farberware

Farberware FBW FT 43721 B Manuel utilisateur

GERMANICA

GERMANICA GEAF5L3LD Manuel utilisateur

Roller Grill

Roller Grill MF 120 R Manuel d'utilisation

Philips

Philips HD9211 Manuel utilisateur

Linea 2000

Linea 2000 Domo DO536FR Manuel utilisateur

Lakeland

Lakeland 31796 Manuel utilisateur

Dash

Dash Tasti-Crisp DFAF755 Manuel utilisateur