York PCC 112 Manuel utilisateur
035T80002-000
Installation Manual
MINISPLIT
FLOOR/CEILING
AIR CONDITIONER
MODELS
PCC/POC 12
PCC/POC 18
PCC/POC 24
PCC/POC 36
PCC/POC 48
PCC/POC 60
01_install.p65 14/3/02, 10:511
2
FLOOR/CEILING
YORK MINISPLIT FLOOR/CEILING
Please read this installation manual
carefully before starting the installation.
It will tell you necessary information.
Quality POLICY
We will continuously strive to satisfy
our customers with consistent reliability
in product, service and support.
CONTENTS
Safety Precautions ......................................4
Cautions for Installation ...........................................4
Part List.........................................................5
Indoor Unit................................................................5
Preparation Before Installation ..................6
Selection of the Location .........................................6
Dimension ................................................................7
Drilling Measurement ...............................................8
Installation in the Following Places
May Result in Trouble ..............................................9
Installation Diagram ..................................10
Installation Procedure ...............................11
Indoor Unit........................................................ 11-12
Outdoor Unit ..................................................... 13-14
Test Operation............................................15
Check This Item Before Start Operation................15
Trouble Shooting Guide ............................15
Technical Specification .............................16
02_install.p65 14/3/02, 10:552
FLOOR/CEILING
3
YORK MINISPLIT FLOOR/CEILING
REQUIRED TOOLS
1.
Screw Driver
2.
Hexagonal Wrench
3.
Torque Wrench
4.
Spanner
5.
Reamer
6.
Hole Core Drill
7.
Tape Measure
8.
Thermometer
9.
Manifold Guage
10.
Gas Leak Detector
11.
Vacuum Pump
12.
Pipe Clamp
13.
Pipe Cutter
14.
Flare Tool Set
15.
Electrical Circuit Tester
EXTENDED PARTS
1.
Refrigerant Pipe
Models PCC/POC
12 18 24 36 48 60
Liquid size 1/4" 3/8" 3/8" 3/8" 3/8" 3/8"
Gas size 1/2" 5/8" 5/8" 5/8" 3/4" 3/4"
2.
Pipe Insulation Material (Polyethylene foam
9 mm thick)
3.
Vinyl Tape
4.
Putty
02_install.p65 14/3/02, 10:553
4
FLOOR/CEILING
YORK MINISPLIT FLOOR/CEILING
SAFETY PRECAUTIONS
•Please read this installation manual carefully before starting installation of the unit.
•This air conditioning system contains refrigerant under pressure, rotating parts and
electrical connection which may be dangerous and can cause injury. Installation
andmaintenanceofthisairconditioningsystemshould only be carriedout bytrained
and qualified personnel.
•After unpacking, please check the unit carefully for possible damage.
•Before undertaking any work on the unit, make sure that the power supply has
been disconnected.
CAUTIONS FOR INSTALLATION
Do not install in a place where flammable gas may
leak.
It may cause fire.
Do not store or unpack the unit in a wet area or expose
to rain or water.
It may cause the unit to short circuit and may result electric
shocks or fire.
Do not conduct installation in wet area or in the rain.
It is a high risk to cause the electrical shocks.
This system is designed for domestic or residential
use only.
If used in certain envionments, such as a manufacturing
workplace, the equipment may not function efficiently.
02_install.p65 14/3/02, 10:554
FLOOR/CEILING
5
YORK MINISPLIT FLOOR/CEILING
INSTALLATION ACCESSORIES
Description Q'ty USE
Bracket
2–
Tapping Screw (∅4x20)
6For install the case
of Remote Control
Nylon Fastener 1 For drain hose
Drain Hose
1–
Insulation (Drain hose) 1 Adhesive type
VT Wire (280 mm)
1 For drain hose
PART LIST
INDOOR UNIT
■PCC12-60
Description Q'ty USE
Remote Control
1–
Installation and
Owner’s manual
2 –
22 23 24 25
26
27
28
29
30
21
POWER COMP.
20
19
18
17
16
15
COOL WARM
LOW
OFF ON
MED
FAN SPEED
POWER
HIGH
TEMPERATURE
Installation Manual
Owner's Manual
02_install.p65 14/3/02, 10:555
6
FLOOR/CEILING
YORK MINISPLIT FLOOR/CEILING
PREPARATION BEFORE INSTALLATION
•Before doing any work, check the interior power supply cord and the main breaker capacity are sufficient and the
installation area is sufficient and complies with the requirements.
•Check that the power supply available agrees with nameplate voltage.
•Electrical work, wiring and cables must be performed in compliance with national and local wiring codes and
standard.
•Do not use the extension cables. In the case extended cables are needed, use the terminal block.
SELECTION OF THE LOCATION
■Select a place which provides the space around the units as shown in the
diagram below.
Indoor Unit Outdoor Unit
Dimension PCC
(cm) 12 18 24 36 48 60
A 505050505050
B 808080808080
C 555555
D 202020202020
Dimension POC
(cm) 12 18 24 36 48 60
A 404040404040
B 202020202020
C 202020202020
D 606060606060
02_install.p65 14/3/02, 10:556
FLOOR/CEILING
7
YORK MINISPLIT FLOOR/CEILING
(continued)
DIMENSION
■Indoor Dimension
■Outdoor Dimension
W
FRONT VIEW
SIDE VIEW
D
H
Dimension PCC
(mm) 12 18 24 36 48 60
W 980 980 1,280 1,780 1,780 1,780
H 630 630 630 630 630 630
D 240 240 240 240 240 240
Dimension POC
(mm) 12 18 24 36 48 60
W 840 840 890 900 870 870
H 590 590 590 700 1,155 1,155
D 300 300 300 325 375 375
FRONT VIEW SIDE VIEW
WD
H
FRONT VIEW SIDE VIEW
WD
H
FRONT VIEW SIDE VIEW
WD
H
POC 48-60
POC 12-24
POC 36
02_install.p65 14/3/02, 10:557
8
FLOOR/CEILING
YORK MINISPLIT FLOOR/CEILING
Preparation Before Installation (continued)
DRILLING MEASUREMENT
■Indoor Unit
Drill the hole to fixing unit follow the diagram below
Ceiling Installation Drilling
■Outdoor Unit
A
BC
D
E
F
Dimension PCC
(mm) 12 18 24 36 48 60
A 85 85 1,105 1,605 1,605 1,605
B 365 365 365 365 365 365
C 505050505050
D 235 235 235 235 235 235
E 165 165 165 165 165 165
F 115 115 115 115 115 115
AC
B
Dimension POC
(mm) 12 18 24 36 48 60
A 570 570 570 610 600 600
B 315 315 315 350 350 350
C 145 145 145 140 150 150
02_install.p65 14/3/02, 10:558
FLOOR/CEILING
9
YORK MINISPLIT FLOOR/CEILING
Installation of the outdoor unit in a place exposed
regularly to a strong wind.
Installation of the indoor unit in a place where there
is an obstacle near the air inlet or outlet.
Installation of the indoor unit at too high > 30 cm a
position.
Installation of outdoor units too close or, blowing
discharged air into each other.
Installation of the indoor unit in direct sun light. Installation in the unit in wrong direction.
INSTALLATION IN THE FOLLOWING PLACES MAY RESULT IN TROUBLE
> 30 cm
02_install.p65 14/3/02, 10:569
10
FLOOR/CEILING
YORK MINISPLIT FLOOR/CEILING
INSTALLATION DIAGRAM
Indoor Unit
Bracket
Front Grille
Vinyl Tape
Apply after carrying out a drainage test.
* To carry out drainage test.
Indoor Unit
Front Grille
Outdoor Unit
Connecting
Cable
Refrigerant Piping
Refrigerant Piping
Additional Drain Hose
Bracket
03_install.p65 14/3/02, 10:5710
Ce manuel convient aux modèles suivants
11
Table des matières
Autres manuels York Climatiseur
York
York YCJD30 S41S1(H) Guide de démarrage rapide
York
York YHKE09XEEAMH-RX Manuel utilisateur
York
York SICH-070B Manuel utilisateur
York
York JVOHQ Series Mode d’emploi
York
York EAKC - 09 FSAAR Manuel utilisateur
York
York YDCFS-022C15B Manuel utilisateur
York
York ZF 180 Series Manuel utilisateur
York
York RVHC 09-12DS Mode d'emploi
York
York FC9C UP Series Manuel utilisateur
York
York YNKFZC024-055BAADAFX Manuel utilisateur
York
York SUNLINE DHG 180 Manuel utilisateur
York
York HVHC 07-12DS Mode d'emploi
York
York PAC036 Guide de démarrage rapide
York
York YCJD18 THRU 60 Guide de démarrage rapide
York
York ZJ078 Manuel utilisateur
York
York LATITUDE Series Guide de démarrage rapide
York
York SUNLINE ULTRA D1HE 036 Manuel utilisateur
York
York H*BE-F018 Guide de démarrage rapide
York
York ZR SERIES Manuel
York
York ZJ037-061 Manuel utilisateur
