Yaesu DR-1X Manuel

Specications

Exploded View & Miscellaneous Parts

Block Diagram

Connection Diagram

Alignment

Board Unit (Schematics, Layouts & Parts)

TX-MAIN Unit

PANEL-1 Unit

PANEL-2 Unit

JACK Unit

RX-MAIN Unit

RELAY-Unit

VR Unit

FILTER-Unit

DSP Unit

144/430 MHz 50 W VHF/UHF AMS DIGITAL REPEATER

DR-1X/XE

C4FM FDMA/FM

Introduction

This manual provides the technical information necessary for servicing the DR-1X/XE 144/430 MHz 50 W VHF/UHF AMS DIGI-

TAL REPEATER.

Servicing this equipment requires expertise in handing surface-mount chip components. Attempts by non-qualied persons to

service this equipment may result in permanent damage not covered by the warranty, and may be illegal in some countries.

Two PCB layout diagrams provided for each double-sided board in this transceiver. Each side of the board is referred to by the

type of the majority of components installed on that side ("Side A" or "Side B"). In most cases one side has only chip compo-

nents, and the other has either a mixture of both chip and leaded components (trimmers, coils, electrolytic capacitors, ICs, etc.),

or leaded components only.

While we believe the information in this manual to be correct, YAESU assumes no liability for damage that may occur as a result

of typographical or other errors that may be present. Your cooperation in pointing out any inconsistencies in the technical infor-

mation would be appreciated.

Important Note

1) This transceiver was assembled using Pb (lead) free solder, based on the RoHS specication.

Only lead-free solder (Alloy Composition: Sn-3.0Ag-0.5Cu) should be used for repairs performed on this apparatus. The solder stat-

ed above utilizes the alloy composition required for compliance with the lead-free specication, and any solder with the above alloy

composition may be used.

2) Risk of explosion if battery is replaced by an incorrect type. Dispose of used batteries according to the instructions.

Contents

Technical Supplement

DR-1X/XE Technical Supplement

Specications

SPECIFICATIONS-1

General

Frequency Range: 144 to 146 MHz, 430 to 440 MHz

144 to 148 MHz, 430 to 450 MHz

Channel Steps: 5 / 6.25 kHz

Emission type: F1D, F2A, F2D, F3E, F7W

Frequency Stability: ±2.5 ppm (-4 °F to +140 °F [–20 °C to +60 °C])

Antenna Impedance: 50 Ohms

Supply Voltage: AC 100 to 240 V (DR-1X, except AUS version)

DC 11.7 to 15.8 V , negative ground

Current Consumption: AC: 2 A (max) (@ 117 V Input) (DR-1X, except AUS version)

DC: 1.5 A (receive)

10 A (50 W TX, 144 MHz band)

10 A (50 W TX, 430 MHz band)

Operating Temperature: DR-1X: -4 °F to +140 °F (–20 °C to +60 °C)

DR-1XE: –20 °C to +55 °C

Dimensions (WxHxD): 19” x 3.5” x 15” (482 x 88 x 380 mm)

Weight (Approx.): DR-1X: 22.05 lbs (10 kg)

DR-1XE: 8.8 kg

Transmier

RF ower Output: 50 / 20 / 5 W

Modulation Types: F1D, F2A, F2D, F3E Variable Reactance Modulation

F7W 4FSK (C4FM)

Spurious Emission: At least 60 dB below

Receiver

Circuit Type: Double conversion Super-heterodyne

Intermediate Frequencies: 1st: 47.25 MHz

2nd: 450 kHz

Receiver Sensitivity: 0.3 μV (Digital 2 m/70 cm) BER 1 %

0.2 μV (FM 2 m/70 cm) 12 dB SINARD

     Thereisnospecicationforfrequencyrangesnotlisted.

Adjacent Channel Selectivity: Beerthan65dBTYP(20kHzoset)

Selectivity:    FM12kHz/35kHz(−6dB/−60dB)

Intermodulation:   Beerthan65dBTYP(20/40kHzoset)

Audio Output:   4W(4Ω,THD10%,13.8V;internalspeaker)

Specications are subject to change, in the interest of technical improvement, without notice or obligation,

and are guaranteed only within the amateur bands.

DR-1X/XE Technical Supplement

Exploded View-1

REF. YAESU P/N Description Qty.

①RA1558800 GASKET(60x12) 1

②RA1558900 GASKET(35x12) 2

③RA1559000 GASKET(15x12) 1

④RA1559100 GASKET(5x12) 1

⑤U04515001 SEMS SCREW HSM5X15 4

⑥U03206001 SEMS SCREW ASM2.6X6 6

⑦U03305002 PAN HEAD SCREW ASM3X5NI 4

⑧S5000335 SPACER QBSB2610 4

⑨U20308002 BINDING HEAD SCREW M3X8NI 15

⑩U30308007 FLAT HEAD SCREW M3X8B 4

⑪U9900296 TORX SCREW TRX SLIM HEAD M4X6 3

YAESU P/N Description

Q0000143 FUSE 0218 005.MXP 5A

Q0000075 BLADE FUSE ATC 15A

T9017882 (for USA) AC-CABLE 117V3WP YFC-18K

T9013285 (for EXP) AC CABLE 220V 3W YFC-14K

T9027285 (for CHN, Lot. -6) AC CABLE CHN YP-03/YC-12 1830MM

T9027385 (for CHN, Lot. 7-) AC CABLE CHN VM0723-VM0725 1830MM

T9026115 DC CABLE 02P 15A UL

T9101621 CT CABLE SCU-20

S4000052 CASE LEG FF-004-AR791

N4090163

PUSH SWITCH 8W1021-N-Z

RA1339400 (Lot. 1-4)

RA133940A (Lot. 5-)

VOLUME KNOB (ASSY)

N2090065

ROCKER SWITCH SDDJE30300

RA1550100

DOUBLE FACE(LG)

RA1550000

LIGHT GUIDE

RA1340000

LCD SPACER (A)

RA154610A

TOP CASE

Q7000649

LCD MODULE UMSH-8513MD-T

JACK-UNIT

T9207602

T9207600

T9207601

T9207600

PANEL-1-UNIT

PANEL-2-UNIT

S5000241

HANDLE THA-216-02

(2 pcs)

RA154520B

SP NET

RA1544900 (Lot. 1)

RA154490A (Lot. 2-4)

RA154490B (Lot. 5-)

FRONT PANEL

⑤

⑩

⑤

⑦

⑥

⑪

⑥

②

③

④

①

⑨

⑧

⑧⑧

⑧

RA1545000

PANEL FRAME

RA1545100

SP HOLDER

RA1545300 (Lot. 1)

RA154530A (Lot. 2-3)

RA154530B (Lot. 4)

RA154530C (Lot. 5-)

MAIN FRAME

M4090167

SPEAKER 77F-F3205 12W/4-OHM

RA0962400

DOUBLE FACE (SP)

VR-UNIT

w/ *1, *2

Exploded View

DR-1X/XE Technical Supplement

Exploded View-2

REF. YAESU P/N Description Qty.

①U9900020 HEX HEAD BOLT HSM4X8B 4

②U04306002 SEMS SCREW HSM3X6NI 12

③U04330007 SEMS SCREW HSM3X30B 4

④U20308002 BINDING HEAD SCREW M3X8NI 2

⑤U66300002 FLANGE NUT N3NI 2

⑥S4000052 CASE LEG FF-004-AR791 4

RA1545700

BRACKET(TX) (2 pcs)

T9207594

T9101626

RA155920A

HOLDER(HEATSINK)

RA1559300

ThermalConductivePad

S5000336

HEAT SINK EG(138)L=10

T9207482

T9207483 (for CE version)

M2090053

FAN EC4010H12E

M2090052

FAN ASFN60371001

RA1546000

MOTOR HOLDER

RA1550200

BLIND SHEET

RA156490A

HOLDER(FAN60)

RA1580100

PAD(195x40)

⑤

⑥

②

③

④

①

Exploded View

DR-1X/XE Technical Supplement

Exploded View-3

REF. YAESU P/N Description Qty.

①U52415002 HEX HEAD BOLT M4X15NI 1

②U72004002 TOOTHED LOCK WASHER OW4NI 1

③U70005002 PLAIN WASHER FW5NI 2

④U20308002 BINDING HEAD SCREW M3X8NI 2

⑤U66300002 FLANGE NUT N3NI 2

⑥S5000268 SPACER QBSB310 4

⑦U04306002 SEMS SCREW HSM3X6NI 8

⑧U9900020 HEX HEAD BOLT HSM4X8B 4

⑤

⑥

⑦

⑧⑧

⑧

⑦⑦

⑥

②

③③

④

①

P2000067 (for INTERNAL PS)

FUSE HOLDER MF500

T9207596A (Lot. 1)

T9207596B (Lot. 2-)

RA154560A

FRAME

RA156650B

SHIELD CASE COVER

RA1545800

BRACKET(RX)

(2 pcs)

T9207597 (for INTERNAL PS)

T9207614 (for INTERNAL PS)

T9101625

Exploded View

DR-1X/XE Technical Supplement

Exploded View-4

②

③

④

①

T9207609

(for INTERNAL PS)

T9207612

T9207603

Q7000671 (for INTERNAL PS)

T9207615 (for INTERNAL PS)

T9207595 (for INTERNAL PS)

T9207598

RELAY-UNIT

REF. YAESU P/N Description Qty.

①U20406002 BINDING HEAD SCREW M4X6NI 2

②U72004002 TOOTHED LOCK WASHER OW4NI 2

③U9900296 TORX SCREW TRX SLIM HEAD M4X6 6

④U04306002 SEMS SCREW HSM3X6NI 6

L9190184 (for INTERNAL PS)

CORE ZCAT1325-0530A-BK

RA1562300

PLATE(D-SUB)

Exploded View

DR-1X/XE Technical Supplement

Exploded View-5

⑤

②

③

④④④

④

④④

①

RA1565000 (Lot. 1-2)

RA156500A (Lot. 3-)

CASE (H043U)

RA1406600

GROUND PLATE(FET)

RA1406500

SHIELD CASE COVER

RA1577800

ThermalConductivePad

RA140640A

FRONT COVER

REF. YAESU P/N Description Qty.

①U31208007 OVAL HEAD SCREW M2.6X8B 4

②U20205007 BINDING HEAD SCREW M2.6X5B 2

③U20308002 BINDING HEAD SCREW M3X8NI 2

④U44308001 PAN HEAD TAPTITE-B M3X8 15

⑤U03310002 SEMS SCREW ASM3X10NI 4

T9207610

T9101625

RA1565900

ThermalConductivePad

P1090547

CONNECTOR

S5000236

LUG WASHER FOR MDR-2

RA0438700

RUBBER

RA1316600

PLATE(FET)

RA026680C

CHASSIS

Exploded View

DR-1X/XE Technical Supplement

Exploded View-6

③

④

④④

①

RA1198800

PORON SHEET

RA1406700

SPONGE RUBBER(VU)

RA1566000

ThermalConductivePad

CQ0419000

RX CASE ASSY

P1090547

CONNECTOR

S5000236

LUG WASHER FOR MDR-2

RA026680C

CHASSIS

T9207613

T9207607

REF. YAESU P/N Description Qty.

①U31208007 OVAL HEAD SCREW M2.6X8B 4

②U20205007 BINDING HEAD SCREW M2.6X5B 2

③U20308002 BINDING HEAD SCREW M3X8NI 2

④U44308001 PAN HEAD TAPTITE-B M3X8 14

②

RA140640A

FRONT COVER

RA0438700

RUBBER

T9101625

Exploded View

DR-1X/XE Technical Supplement

BLOCK DIAGRAM-1

Block Diagram

DR-1X/XE Technical Supplement

CONNECTION DIAGRAM-1

Connection Diagram

Autres manuels pour DR-1X

Ce manuel convient aux modèles suivants

Table des matières

Manuels Répétiteur populaires d'autres marques

Gigaset

Gigaset 108 Manuel utilisateur

Ace TECHNOLOGY

Ace TECHNOLOGY USR-1900A Manuel utilisateur

Kenwood

Kenwood TKR-750-850 Manuel de la liste des pièces

Asus

Asus RP-AC51 Manuel utilisateur

Exibel

Exibel HRP0101 Manuel utilisateur

Kidde

Kidde Vega Manuel utilisateur

Telcosat

Telcosat RBB 850 Guide d'installation

York

York Universal LINC485 Manuel utilisateur

MIKOM

MIKOM MRx01B Power Series Manuel utilisateur

Simrad

Simrad RD 301 Manuel utilisateur

Tait

Tait TB7304 Manuel utilisateur

R-tron

R-tron RSN-CDMA-37-C Manuel utilisateur

Inventronics

Inventronics DALI REPEATER SO Manuel utilisateur

XFP

XFP 16 Manuel utilisateur

Andrew

Andrew MRx18 Manuel utilisateur

COMBA

COMBA RXA3748 Manuel utilisateur

ADRF

ADRF SDR-ICS-43 Manuel utilisateur

Teltonika

Teltonika WRP100 Manuel utilisateur