Whispbar K603W Manuel utilisateur

K603W

Fitting Kit

EN Fitting Instructions for Basic Carrier

x 4 x 8 x 4 x 1

x 8 x 4 x 4 x 4

x 4 x 1

Revision No: 4C 1

Fitting Kit K603W

MAX kgs (lbs)

W/P WHD

Nissan

Navara D40 Double Cab, 4dr Truck 05-+ US 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute 05-+ EU 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute Dec 05-+ NZ 75 kgs (165 lbs) 75 kgs (165 lbs)

Navara D40 Double Cab, 4dr Ute Nov 05-+ AU 75 kgs (165 lbs) 75 kgs (165 lbs)

Fitting Kit EN

K603W

Items you will require:

●Tape measure

Pen

Cordless drill

Depth stop

Vacuum cleaner

Rust inhibitor

Small paint brush

Neutral cure silicon sealant

Rivet gun

Attention:

●Attaches with permanent mount blocks

riveted to roof. Bar can be removed.

Professional installation advised.

Fitting Kit EN

K603W

First Time Installation

●Remove parts from inside the package and

check. Contact your dealer if any parts are

missing or damaged.

●This kit fits type A, B, C and D.

●These instructions show type D crossbar

fitted. They also apply to type A, B and C.

●Use keys to remove covers.

Fitting Kit EN

K603W

●Remove Hex Key from right hand cover.

●Use hex screwdriver to reverse adjusting

screw 10 turns.

●Press adjusting screw and pull crossbar

legs out. Refer to the crossbar instructions

for crossbar adjustment method.

●Ensure each end of the crossbar is

adjusted equally.

Fitting Kit EN

K603W

●Adjust crossbar in or out to suit vehicle.

●Please check the rear of this manual for

information relating specifically to your

vehicle.

●Remove plastic clamp block by gripping bar

leg with fingers and push firmly with

thumbs until clamp block drops out behind

leg.

●Select plastic internal block (from fitting kit)

and insert into foot.

●Repeat for all legs.

Fitting Kit EN

K603W

●Tighten adjusting screw to 5 Nm (3.7 ft lb)

hand tight.

●Fit rubber pads (supplied with fitting kit) to

foot. Pad may vary in shape to that shown.

●Make sure the pad fits into the holes

underneath the foot.

●This setup is applicable for two crossbars

only.

●Recommended crossbar placement is as

shown.

Fitting Kit EN

K603W

●This setup is applicable for one crossbar

only.

●Recommended single crossbar placement

is above door pillar.

●Apply masking tape to vehicle roof in all

four positions.

●Position the permanent mount block so the

inner edge of the block is on the outer edge

of the ditch channel.

Fitting Kit EN

K603W

●With the drill, lightly mark both permanent

mount hole positions while holding the

mount firmly on roof.

●CAUTION: Maximum depth 7mm.

Use 7mm drillstop over supplied 4.9mm

drill bit.

Drill two outside holes at marked positions.

●Remove masking tape.

Fitting Kit EN

K603W

●Treat holes to prevent corrosion.

●Apply neutral cure silicon sealant in and

around drilled holes.

●Install rivets through permanent mount

blocks.

Autres manuels pour K603W

Table des matières

Autres manuels Whispbar Accessoires automobiles

Whispbar

Whispbar K602W Manuel utilisateur

Whispbar

Whispbar K112W Manuel utilisateur

Whispbar

Whispbar K387W Manuel utilisateur

Whispbar

Whispbar K082W Manuel utilisateur

Whispbar

Whispbar K492W Manuel utilisateur

Whispbar

Whispbar K678W Manuel utilisateur

Whispbar

Whispbar PR3090 Manuel d'utilisation et d'installation

Whispbar

Whispbar K365W Manuel d'utilisation et d'installation

Whispbar

Whispbar K320W Manuel utilisateur

Whispbar

Whispbar K447 Guide d'installation

Whispbar

Whispbar K511W Manuel utilisateur

Whispbar

Whispbar K312W Manuel utilisateur

Whispbar

Whispbar K467W Manuel utilisateur

Whispbar

Whispbar K677W Manuel utilisateur

Whispbar

Whispbar K353W Manuel utilisateur

Whispbar

Whispbar K120W Manuel utilisateur

Whispbar

Whispbar K539W Manuel utilisateur

Whispbar

Whispbar K549W Manuel utilisateur

Whispbar

Whispbar K580W Manuel utilisateur

Whispbar

Whispbar K855W Manuel utilisateur

Whispbar

Whispbar K457W Manuel utilisateur

Whispbar

Whispbar K504W Manuel utilisateur

Whispbar

Whispbar K505W Manuel utilisateur

Whispbar

Whispbar K639W Manuel utilisateur

Manuels Accessoires automobiles populaires d'autres marques

James Baroud

James Baroud Odyssey Manuel utilisateur

Motorola

Motorola i50sx Manuel utilisateur

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manuel utilisateur

Feniex

Feniex T3 Manuel utilisateur

Renault

Renault 77 11 423 180 Manuel utilisateur

Kia

Kia E8300-4D000 Manuel utilisateur

Brink

Brink 756843 Manuel utilisateur

v.link

v.link CI-VL2-PC-HSD Manuel utilisateur

Viking

Viking Stack-Rack Guide de configuration rapide

Aries

Aries 203015 Manuel utilisateur

Choetech

Choetech AT0005 Manuel utilisateur

ZZ2

ZZ2 ZZAIR-PRO Manuel utilisateur

Holman

Holman 4A80L Manuel utilisateur

Thule

Thule 2075 Manuel utilisateur

Motorola

Motorola T325 Manuel utilisateur

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guide d'installation

DV8

DV8 FBJL-02 Manuel utilisateur

Prorack

Prorack K1163 Manuel utilisateur