TJERNLUND CS1 Manuel utilisateur

DESCRIPTION

The Tjernlund UnderAire™ Series Fresh Air Supply Fans for Crawl Spaces are designed to boost fresh outdoor air under-

neath homes and porches. Use in conjunction with Tjernlund UnderAire™ Crawl Space Exhaust Fans to remove moisture in

Crawl Spaces with too few or undersized passive vent openings, overall lengths of over 40 feet, or in “dead zones” or stag-

nant areas that are not served by existing foundation vents.

Excessive humidity levels in Crawl Spaces is the leading cause of premature rotting of support columns, joists, floors and

beam supports. Humidity can promote fungus growth and increased termite activity. Humidity may also cause plumbing

failures due to rust and corrosion. Helps dilute radon gases, treated wood off-gassing and other odors that might migrate

into living areas.

All models are equipped with a factory installed and pre-wired freeze protection thermostat which will prevent operation of

the fan below 35°F.

SPECIFICATIONS

SPECIFICA-

TIONS

GENERAL INFO

GENERAL INFORMATION

Each UnderAire™ Powered Fresh Air Supply Fan is electrically factory line tested before shipment.

After opening carton, inspect thoroughly for shipment damage. Fan should rotate freely and all electrical wires and connec-

tions should be secured. If any damage is found, notify freight carrier and your distributor immediately and file a concealed

damage claim.

RECOMMENDED APPLICATION

The CS1 & CS2 Powered Fresh Air Supply Fans are designed to be used in conjunction with Tjernlund V-Series exhaust

Crawl Space Ventilators (V1, V1D, V2D). Use without exhaust fans may limit the effectiveness of these fans and cause pos-

itive pressurization of the space which can could result in property damage. For optimal performance match CFM of supply

fan to CFM of exhaust fan. For example: (1) CS1 per V1 or V1D and (1) CS2 per V2D.

Powered Fresh Air Supply Fans for Crawl Spaces

TJERNLUND PRODUCTS, INC.

1601 Ninth Street • White Bear Lake, MN 55110-6794

PHONE (800) 255-4208 • (651) 426-2993 • FAX (651) 426-9547

Visit our web site • www.tjernlund.com

READ OWNERS INSTRUCTIONS CAREFULLY PRIOR TO INSTALLATION.

THESE INSTRUCTIONS MUST REMAIN WITH EQUIPMENT. DO NOT DESTROY.

MODEL CS1

MODEL CS1 Fresh Air Supply Fan:

Capacity: 110 CFM

Motor: 115 Volts ~ 50/60 Hz

0.30 amps maximum

Thermostat: On at 50°F

Off at 35°F

Dimensions: 18” x 9” x 2”

Mounting Plate Smallest

Trimmable Dimensions: 7” x 6”

MODEL CS2 Fresh Air Supply:

Capacity: 220 CFM

Motors: 2 @ 115 Volts ~ 50/60 Hz

0.60 amps maximum

Thermostat: On at 50°F

Off at 35°F

Dimensions: 18” x 9” x 2”

Mounting Plate Smallest

Trimmable Dimensions: 13” x 6”

MODEL CS2

INSTALLATION

The Fresh Air Supply Fan must be installed by a qualified installer in accordance with these instructions and all local codes

or in their absence in accordance with the latest editions of the International Residential Code and International Electrical

Code. Improper installation can create a hazardous condition such as fire, electric shock or personal injury. To reduce

these risks significantly, use this unit only in the manner intended by the manufacturer. If you have questions, contact

Tjernlund Products. Always disconnect the Fresh Air Supply Fan from its power source before installation and servicing.

CAUTION: For general ventilation use only. Do not use to exhaust hazardous or explosive materials and vapors.

WARNING: To reduce the risk of fire or electric shock, do not use this fan with any solid-state speed control device.

TOOLS REQUIRED

• 5/16" Nut Runner or Flat Head Screw Driver

• Drill with 5/16" Masonry Bit if mounting on brick or foundation block

• Grounded Electrical Outlet within 6 feet of fan location.

INSTALLATION

LOCATION

Mount Fresh Air Supply Fan from the outside (remove existing vents if necessary) or inside the crawl space behind existing

foundation ventilation openings, (See Diagram A). Alternately, attach to joist to act as a “dead zone” circulation or stagnant

area fan, (See Diagram B).

IMPORTANT: Crawl Space Supply Fan must be mounted with the electrical control box and motor facing the interior of the

crawl space. Improper installation can create a hazardous condition such as fire, electric shock or personal injury.

1. Remove existing doors or covers on ventilation openings around the perimeter of the building.

2. Position the Crawl Space Supply Fan over the ventilation opening. To minimize moisture accumulation near power

supply, the unit should be oriented with the cord coming out on the top side of the fan(s), (See Diagrams Below).

3. If installing on foundation block or brick, mark location in the (6) mounting locations of the metal face plate and drill 5/16"

holes with masonry bit. Install wall anchors into openings and secure Fresh Air Supply Fan to the wall with (6) screws.

If installing on rim joist or mesh on existing crawl space vent, secure Fresh Air Supply Fan with (6) screws, washers and

nuts in the (6) mounting locations on metal face plate, (See Diagram A).

If installing on a joist / truss secure Fresh Air Supply Fan with (3) screws and washers in the top (3) mounting locations on

metal face plate, (See Diagram B).

4. Plug unit(s) into electrical outlet or use the optional Tjernlund DH2P Dehumidistat Control.

TYPICAL MODEL CS1 & CS2 MOUNTING

FOUNDATION OPENING (Model CS1 Shown) - DIAGRAM A

TYPICAL MODEL CS1 & CS2 JOIST / TRUSS

INSTALLATION (Model CS1 Shown) - DIAGRAM B

WIRING

ONOFF

OPTIONAL ON-OFF SWITCH-OUTLET

PROVIDED BY INSTALLER

50/60 Hz

120 VAC 50/60 Hz

120 VAC

CS1 ELECTRICAL BOX

BLACKBLACK

T-STAT

WHITE

GREEN

FAN

FIGURE 8050025 3-14-11

PROVIDED BY INSTALLER

OPTIONAL ON-OFF SWITCH

OFF ON

OUTLET

PROVIDED BY INSTALLER

120 VAC

50/60 Hz

120 VAC

50/60 Hz

GREEN

FAN

WHITE

T-STAT

BLACK BLACK

CS2 ELECTRICAL BOXES

BLACKBLACK

T-STAT

WHITE

FAN

GREEN

CS1

120 VAC

50/60 Hz

PROVIDED BY INSTALLER

OPTIONAL ON-OFF SWITCH-OUTLET

OFF ON

DE-HUMIDISTAT

V1D ELECTRICAL BOX

BLKBLK

T-STAT

WHITE

BLK

FAN

OUTLET

PROVIDED BY INSTALLER

GRN

50/60 Hz

120 VAC

50/60 Hz

2 WIRE NUTS

PROVIDED BY

INSTALLER

GRN

FAN

WHITE

BLACK

50/60 Hz

120 VAC

50/60 Hz

GRN

PROVIDED BY INSTALLER

OUTLET

FAN

BLK

WHITE

T-STAT

BLK BLK

V2D ELECTRICAL BOX

DE-HUMIDISTAT

ONOFF

OPTIONAL ON-OFF SWITCH-OUTLET

PROVIDED BY INSTALLER

50/60 Hz

120 VAC

CS2

2 WIRE NUTS

PROVIDED BY

INSTALLER

SWITCHED OUTLET, NON-HUMIDITY CONTROLLED OPTION FOR MODEL CS1

CONTROLLING MODEL CS1 IN CONJUNCTION WITH V1D CRAWL SPACE EXHAUST FAN

CONTROLLING MODEL CS2 IN CONJUNCTION WITH V2D CRAWL SPACE EXHAUST FAN

SWITCHED OUTLET, NON-HUMIDITY CONTROLLED OPTION FOR MODEL CS2

REPLACEMENT PARTS

Component Part Number

Thermostat 950-8302

Fan 950-0020

DH2P Dehumidistat (Optional) DH2P

WARRANTY

120 VAC

50/60 Hz

WHITE

BLACK

DE-HUMIDISTAT

BLACK

CONTROLLING MODEL CS1 OR CS2 WITH OPTIONAL MODEL DH2P DEHUMIDISTAT CONTROL

Plug up to (2) CS1 or CS2

models into optional model

DH2P dehumidistat control

which plugs into standard

120 VAC outlet.

TJERNLUND LIMITED ONE YEAR WARRANTY

Tjernlund Products, Inc. warrants to the original purchaser of this product that the product will be free from defects due to faulty material or workmanship for a period of (1) year from the date of original

purchase or delivery to the original purchaser, whichever is earlier. Remedies under this warranty are limited to repairing or replacing, at our option, any product which shall, within the above stated war-

ranty period, be returned to Tjernlund Products, Inc. at the address listed below, postage prepaid. THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE

HEREOF, AND TJERNLUND PRODUCTS, INC. EXPRESSLY DISCLAIMS LIABILITY FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE USE OF THIS PRODUCT. THIS

WARRANTY IS IN LIEU OF ALL OTHER EXPRESS WARRANTIES AND NO AGENT IS AUTHORIZED TO ASSUME FOR US ANY LIABILITY ADDITIONAL TO THOSE SET FORTH IN THIS LIMITED

WARRANTY. IMPLIED WARRANTIES ARE LIMITED TO THE STATED DURATION OF THIS LIMITED WARRANTY. Some states do not allow limitation on how long an implied warranty lasts, so that

limitation may not apply to you. In addition, some states do not allow the exclusion or limitation of incidental or consequential damages, so that above limitation or exclusion may not apply to you. This

warranty gives you specific legal rights and you may also have other rights which may vary from State to State. Send all inquiries regarding warranty work to Tjernlund Products, Inc. 1601 9th Street,

White Bear Lake, MN 55110-6794. Phone (651) 426-2993 • (800) 255-4208 • Fax (651) 426-9547 • Email [email protected].

OPTIONAL

DH2P CONTROL DH2P FACTORY WIRED CONTROL

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels TJERNLUND Ventilateur

TJERNLUND

TJERNLUND DB-2 DUCT BOOSTER 8504030 REV B 0900 Manuel utilisateur

TJERNLUND

TJERNLUND 950-2064 L-185 SAFETY INTERLOCK KIT 8504020 REV 3... Manuel utilisateur

TJERNLUND

TJERNLUND 950-8302 T-STAT KIT 8504132 Manuel utilisateur

TJERNLUND

TJERNLUND SS2G SIDESHOT (DISCONTINUED) 8504075 REV 1... Manuel utilisateur

TJERNLUND

TJERNLUND WARRANTY POLICY 8500115 Manuel utilisateur

TJERNLUND

TJERNLUND AD-1 DRAFT INDUCER FOR WOOD BURNING STOVES 8500672 REV. 1... Manuel utilisateur

TJERNLUND

TJERNLUND 950-2420 24SP200 SPILLAGE KIT 8504056 REV 1... Manuel utilisateur

TJERNLUND

TJERNLUND DRAFT INDUCER DJ-3 Manuel utilisateur

TJERNLUND

TJERNLUND GPAK-J Manuel utilisateur

TJERNLUND

TJERNLUND V1, V1D, V2D CRAWL SPACE VENTILATORS 8504129 Manuel utilisateur

TJERNLUND

TJERNLUND WHKI MILLIVOLT APPLIANCE INTERLOCK (RECOMMEND WHKE FOR USE WITH UC1) 8504055 REV 3... Manuel utilisateur

TJERNLUND

TJERNLUND aireshare as1p Manuel utilisateur

TJERNLUND

TJERNLUND SS2 SIDESHOT (DISCONTINUED VERSION-PRE UC1 UNIVERSAL CONTROL) 8504063 REV B... Manuel utilisateur

TJERNLUND

TJERNLUND DB2 DUCT BOOSTER Manuel utilisateur

TJERNLUND

TJERNLUND SS1 SIDESHOT WITH UC1 UNIVERSAL CONTROL (VERSION X.02) 8504102 REV... Manuel utilisateur

TJERNLUND

TJERNLUND HSJ Manuel utilisateur

TJERNLUND

TJERNLUND HS-3 Manuel utilisateur

TJERNLUND

TJERNLUND SS1R SIDESHOT (DISCONTINUED VERSION-PRE UC1 UNIVERSAL CONTROL) 8504046 REV... Manuel utilisateur

TJERNLUND

TJERNLUND EA5 DUCT BOOSTER FAN 8504029 Manuel utilisateur

TJERNLUND

TJERNLUND DRAFT INDUCER DJ-3 Manuel utilisateur

TJERNLUND

TJERNLUND DRAFT INDUCER DJ-3 Manuel utilisateur

TJERNLUND

TJERNLUND SS1C SIDESHOT (DISCONTINUED VERSION-PRE UC1 UNIVERSAL CONTROL) 8504040 REV 4... Manuel utilisateur

TJERNLUND

TJERNLUND XCHANGER X2D Manuel utilisateur

TJERNLUND

TJERNLUND SS1C SIDESHOT WITH UC1 UNIVERSAL CONTROL (VERSION X.06) 8504103 REV D... Manuel utilisateur

Manuels Ventilateur populaires d'autres marques

ELTA FANS

ELTA FANS H03VV-F Manuel utilisateur

Hunter

Hunter 20714 Manuel d'instructions

Emerson

Emerson CARRERA VERANDA CF542ORB00 Manuel utilisateur

Hunter

Hunter Caraway Manuel d'instructions

Panasonic

Panasonic FV-15NLFS1 Manuel utilisateur

Kompernass

Kompernass KH 1150 Manuel utilisateur

VES

VES FALA100/12V/TR Manuel utilisateur

Vertiv

Vertiv Liebert DCD Manuel utilisateur

Westinghouse

Westinghouse GFP Series Manuel utilisateur

Venmar

Venmar KUBIX HRV PLUS Series Manuel utilisateur

Maico

Maico ECR 31 Manuel utilisateur

Sonnenkonig

Sonnenkonig Dinky Manuel utilisateur

S&P

S&P ECOWATT HXBR Manuel utilisateur

Wider

Wider IMP03369BH Manuel utilisateur

Panasonic

Panasonic F-60DHN Manuel utilisateur

Hinkley

Hinkley HIGHLAND Manuel utilisateur

Broan

Broan 766BN Manuel utilisateur

Premium

Premium PFS16022 Instructions de montage