Stud welding products StudPro 2500 Manuel utilisateur

OPERATION MANUAL

MODELS

TWE-250

TWE-321

TWE-375

TRU‐WELDEQUIPMENTCOMPANY

6400N.HONEYTOWNROAD

SMITHVILLE,OHIO44677

(330)669‐2773

MODELS

StudPro 2500

StudPro 3125

StudPro 3750

Downey, CA

9459 Washburn Rd.

Downey, CA 90242

Phone- 800.252.1919

Fax- 562.862.3022

Hayward, CA

2391 American Ave.

Hayward, CA 94545

Phone- 510.782.7883

Fax- 510.782.7918

Renton, WA

927 Thomas Ave. SW

Renton, WA 98057

Phone- 425.656.9787

Fax- 425.656.9786

Phoenix, AZ

3535 East Wier Ave., Ste. #4

Phoenix, AZ 85040

Phone- 602.305.9350

Fax- 602.305.4890

Toll free customer support: 1.800.252.1919

CONTENTS

SectionDescriptionPages

1Introduction3

2ExternalFeatures4‐5

3Safety6‐8

4SetupandWelding9‐15

5TestingWeldSettings16

6InspectingTheWeld17

7CDStudGunViews18

8CDStudGunExplodedView19

9CDStudGunPartsList20

10CDControllerExplodedView21

11CDControllerPartsList22

1 Introducon 3

2 External Features 4-5

3 Safety 6-8

4 SetupandWelding 9-15

5 TesngWeldSengs 16-19

6 TypesofFractures 20

7 ArcBlowEect 21

8 CDStudGunExplodedView 22

9 InternalComponents 23-25

10 CDAccessoreis 26-29

11 TorqueBendingTest 30-31

12 CDGunSetUp’s 32-33

Thecompleterangeofthecapacitordischargeequipmentiscompact,portablestud

weldingequipment.Theunitsarespecificallydesignedtoenableasmalldiameter

rangeofferrousandnonferrousweldstudstobeweldedtolightgaugemetalmateri‐

alswithlittleornoreverse‐sidemarking.



Theequipmentconsistsofacontrolunit,aweldinghandgun,andallnecessaryinter‐

connectingcables.



THEPROCESS

CapacitorDischarge(CD)studweldingisaformofweldinginwhichtheenergyre‐

quiredfortheweldingprocessisderivedfromabankofchargedcapacitors.This

storedenergyisdischargedatthebaseofthespeciallydesignedCDstudanditfuses

thestudtothebasematerial.Thetimeoftheweldisdeterminedinsuchashortdu‐

rationthatnoburnthroughmarkingismadeonthefinishsideofthematerial.



CONTACT

IncontactCDwelding,thestudisplacedunderspringpressureonthematerialtobe

welded.Whenthecapacitorsaredischarged,thespecialtipoftheCDstudmeltsand

thespringpressureforcesthestudtofusewiththebasematerial.



GAP

IngapCDwelding,thestudisplacedontothematerialtobewelded.Asthestudgun

isengaged,thestudliftsfromthebasematerialandthenreturnstothepointofcon‐

tactatthetimeofthedischargeofthecapacitors.Asthecapacitorsdischarge,melt‐

ingthetipoftheweldstud,thepressurecreatedbythemovementofthestudtothe

basematerialbythestudgunfusesthestudtothebasematerial.

INTRODUCTION



FRONTPANEL



1.WeldVoltageSelector‐rotatetochangetorequiredvoltage.

2.WeldingVoltageDigitalDisplay‐displaysselectedvoltage.

3.LEDLights‐Charging(capacitorsarebeingchargingtodesiredvoltage),Ready

(unitisreadytoweld),Reset(indicatesanerrorandunitshouldbeturnedoff).

4.WeldingGroundCableConnector(+)

5.StudGunControlConnector

6.WeldingStudGunCableConnector(‐)



EXTERNAL FEATURES

1

4

2

56

3

654

REARPANEL

1.On/OffSwitch

2.FuseHolder(10amp)

3.ACPowerCord

4.ManufacturerModelNumberandSerialNumberPlate



WARNING!

Thisunitoperatesfroma110VAC60Hertz@10ampcircuit.

Donotobstructtheventilationfan,asthismaycauseunittooverheat.

Donotremoveanyportionoftheunithousingwithoutfirstdisconnectingtheunit

fromthepowersupply.



EXTERNAL FEATURES

ON/OFFSwitch

15AmpFuse

PowerSupplyFan

ACCord

ON/OFF Switch

15Amp Fuse

Power Supply Fan

AC Cord



PROTECTYOURSELFANDOTHERS!

Readthesafetynoticesbeforeusingwelder.



ELECTRICAL

Noportionoftheoutercoveroftheweldingcontrollershouldberemovedbyany‐

oneotherthanqualifiedpersonnel.Alwaysdisconnecttheunitfromthemainpower

priortoremovingcover.

• Thisequipmentcontainsatransformerpowersupplysystem,whichisenergized

byACcurrentandtransformstheACtoDCcurrent.Duetopotentialdangerous

electricalinputandoutputtheequipmentmustbedisconnectedfromallincom‐

ingpowerwhenservicing.

• Capacitorsstoreelectricalenergy.Checkforresidualchargebeforeperforming

anymaintenance.

• Donotusefluidstocleanelectricalcomponentsasthesemaypenetratetheelec‐

tricalsystemandcauseshorts.



Connectionoftheunitintoservicemustbeinaccordancewiththesetupprocedures

asdetailedinthismanual.Operationofthisequipmentmustbeinaccordancewith

alllocal,regional,andnationalsafetycodes.



SAFETY



FIRE

Duringwelding,smallparticlesofhotmetalcanbeexpelled.Ensurethatnocombus‐

tiblematerialsareneartheweldingarea.



PERSONALSAFETY

Arcrayscanburnyoureyesandskin.Wearprotectiveclothingandeyeprotection

whenwelding.

Loudnoisesfromweldingcandamagehearing.Wearearplugsorotherprotective

gear,ifapplicable.

Fumesandgasesexpelledduringweldingcanbehazardoustoyourhealth.Make

sureweldingisdoneinawell‐ventilatedarea.

Hotmetalsplattercancausefiresandburns.Wearprotectiveclothing,freeofcom‐

bustiblematerials.Haveafireextinguishernearbyandknowhowtouseit.

MAINTENANCE

Allcablesmustbeinspectedregularlytoensurethatnodangerexistsfromwornor

damagedinsulationorunsafeelectricalconnections.Takespecialnotetothecables

nearthestudgun‐thisiswheremaximumwearoccurs.

Worncablesnotonlyproduceinconsistentwelds,butcanoverheatorspark.



SAFETY

FIRE HAZARD

FROM SPARKS



TRAINING

Useofthisequipmentmustbelimitedtoauthorizedpersonnelonly.Theymustbe

adequatelytrained,andhavereadandunderstoodeverythinginthismanual.The

manualmustbeavailabletooperatorsatalltimes.



INSTALLATION

Selectasitefortheequipmentwhichiscapableofsupportingtheweightofthe

equipment,whichisclearfromtrafficrouteswherepeoplemaytripovercables,or

theymaybedamagedbyotherequipmentorvehicles.

Donothangconnectingcablesoversharpedgesorhavenearheatsources.

DISPOSAL

Theequipment,initsentiretyorascomponents/partsmaybedisposedofasgeneral

industrialwasteorscrap.Noneofthecomponentsusedinthemanufacturingofthe

CDWeldersaretoxic,carcinogenic,orotherwiseharmfultoyourhealth.



SAFETY

AUTHORIZED

PERSONNEL ONLY

POWERINGUPTHEEQUIPMENT

Setuptheequipmentpowersupply(ControlUnit)andconnecttothemainpower,

makingcertainofthepropervoltagerequirementoftheparticularunit.

CapacitorDischarge(CD)unitsgenerallyrequire110VAC@60Hzincomingpower.

Refertothesafetyrecommendationsbeforepluggingthisunitin.



ON/OFFSwitch



Fuse



PowerCord(110VAC)



CONNECTINGTHEWELDINGLEADS

Connecttheweldinggroundcableintothe(+)terminalmountsocketonthefrontof

theweldingunit.

***NOTE‐thecableendplughasaflatwhichalignswithadotonthepanelmount

socket.Securetheconnectorintothepanelmountsocket,andthenturnitclockwise

untilitlocksintoproperposition.Failuretodosocouldresultindamagetothecon‐

nector.



GroundCableSocket

SET-UP AND WELDING

Ground Cable Socket

ON/OFF Switch

Fuse

Power Cord (110 VAC)

CONNECTINGTHEWELDINGLEADS

Connecttheweldingstudgunpowercableintothe(‐)terminalpanelmountsocket

(designatedbythegunsymbol)onthefrontoftheweldingunit.

***NOTE‐thecableendplughasaflatwhichalignswithadotonthepanelmount

socket.Securetheconnectorintothepanelmountsocket,andthenturnitclockwise

untilitlocksintoproperposition.Failuretodosocouldresultindamagetothecon‐

nector.





WeldingGunPowerConnector



WeldingGunControlCableConnector



Connecttheweldguncontrolcableintothecenterpanel2‐pinsocket.

**NOTE‐theplughasalargepinandasmallpinthatmatchthesocketontheunit.

Thisistopreventincorrectconnections.Pushtheplugfirmlyintothesocketand

twistclockwisetosecuretheplugintothecorrectposition.

SET-UP AND WELDING

Welding Gun Control Cable Connector

Welding Gun Power Connector

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels stud welding products Système de soudage

stud welding products

stud welding products StudPro LiteXI Manuel utilisateur

stud welding products

stud welding products StudPro 2500i Manuel utilisateur

stud welding products

stud welding products StudPro 2500XI Manuel utilisateur

stud welding products

stud welding products STUDPRO Series Manuel utilisateur

stud welding products

stud welding products StudPro LiteXI Manuel utilisateur

Manuels Système de soudage populaires d'autres marques

Berner

Berner PLASMACUT 54 Manuel utilisateur

Pro Spot

Pro Spot PR-155 Manuel utilisateur

Forney

Forney 210 Manuel utilisateur

Thermal Arc

Thermal Arc 400S Manuel utilisateur

Lincoln Electric

Lincoln Electric HANDYMIG 170I Manuel utilisateur

GYS

GYS PROTIG 201 AC/DC Manuel utilisateur

TAFA

TAFA 30*8B35 Manuel utilisateur

Lincoln Electric

Lincoln Electric INVERTEC V350-PRO CE Manuel utilisateur

ESAB

ESAB Buddy Arc 145 Manuel utilisateur

CIGWELD

CIGWELD 636804 Guide rapide

Red-D-Arc

Red-D-Arc DC-400 Manuel utilisateur

Hobart Welding Products

Hobart Welding Products Spool Gun DP 3035-10 Manuel utilisateur

Elettro

Elettro HI-MIG 3000 SYNERGIC Manuel utilisateur

WIA

WIA Weldmatic 270 CP132-2 Manuel utilisateur

Sonics

Sonics H520T Manuel utilisateur

Miller

Miller Big Blue 400D Manuel utilisateur

NewArc

NewArc RT2000 Guide de démarrage rapide

Hypertherm

Hypertherm powermax1000 Manuel utilisateur

stud welding products StudPro 2500 Manuel utilisateur

Manuels Système de soudage populaires d'autres marques