STS DTC01 Manuel utilisateur

Operating Instructions

DTC01

Universal Drum Trolley

E-mail: [email protected]

Tel: +44 (0)1736 851050

Fax: +44 (0)1736 851023

Operation and maintenance manual

Product code: DTC01 (Ex)

Product description: Universal Drum Trolley

BESPOKE HANDLING EQUIPMENT LTD

Technical Support Line: +44 (0)1736 851050

The Universal Drum Trolley is used for transporting steel and plastic drums and barrels, 50-

205 litres around the workplace.

Instructions should be adhered to at all times, failure to do so can result in serious injury to

the operator or other personnel

Key safety requirements

1. Do not use the unit unless you have read and fully understood the

operation and maintenance manual.

2. This equipment is designed for use on level ground.

3. Only handle drums that are in a good condition. Should the lip or any

other part of the drum be damaged, these should not be handled.

4. When not in use the equipment should be parked in a safe location; if the

unit has brakes these should be applied.

5. This product is to be used by one operator at a time and they must be

behind the unit at all times.

6. For equipment which lifts drums, do not transport the drum at

unnecessary heights; the drum should be as close to the floor as possible

at all times.

7. Do not allow other personnel to be in front of the unit when in use.

8. The safe working load (SWL)/rated capacity should not be exceeded in

any circumstances.

9. The equipment should be inspected at regular intervals, decided by the

operator’s company, for signs of damage or defects.

10.The unit must be inspected at least annually or after any unusual event by

a suitably competent person.

11.Ensure damaged or missing safety notices are replaced; these are

available from STS.

12.The manual forces relating to the use of this equipment are relatively low;

any doubts in this should be reported to STS.

13.If any operator is in any doubt of the correct suitability of the equipment

or has any problem understanding the instruction manual then they

should contact STS for technical support.

14.Installation of third-party equipment which affects the performance of the

equipment requires the written permission of the manufacturer.

15.Upon delivery equipment should be inspected for transit damage. Any

damage should be reported to STS and the equipment should be

quarantined and not used.

16.If the unit supplied is the ATEX model, ensure earthing chains are securely

fitted and are in contact with the ground at all times; also wheels should

be kept clean and free from debris.

17.The manufacturer shall not be held liable in case of faults or accidents due

to negligence, incapacity, installation by unqualified personnel or improper

use.

Operation and maintenance manual

Product code: DTC01 (Ex)

Product description: Universal Drum Trolley

BESPOKE HANDLING EQUIPMENT LTD

Technical Support Line: +44 (0)1736 851050

Section 1 - Connecting to a drum

1. Place the drum on flat level ground.

2. Squeeze the two catch plates together to slide up and down to adjust gripping height.

Once released, the catch gripper will lock in place.

3. Adjust the catch settings, see section: ‘drum catch variations.’

4. Manoeuvre the trolley up to the drum and position in line with the catch.

5. Adjust catch so top hook latches over the drum lip and the bottom toggle will drop

beneath drum lip

6. The safety chain is only required for round sides plastic drums and small drums. The

chain it is not required for parallel-sided drums

7. When the chain not in use fasten to the hook provided.

Section 2 - Preparing drum for transport

1. Ensuring both hands are on the handles of the trolley at all times.

2. Stand upright and place one foot on the foot bar.

3. Pull backwards on the handles whilst at the same time pushing the foot bar towards the

base of the drum

4. Once the foot bar is touching the drum remove your foot and push down on the handles

until the top of the drum is level.

5. The trolley and drum can now be moved.

Operation and maintenance manual

Product code: DTC01 (Ex)

Product description: Universal Drum Trolley

BESPOKE HANDLING EQUIPMENT LTD

Technical Support Line: +44 (0)1736 851050

Section 3 - Placing the drum back on the floor

1. Hold the handles securely, tip the trolley forward until the front of the drum is in contact

with the floor.

2. Place one foot on the foot bar and raise the handles slowly, controlling the speed of the

action with your foot until the drum is placed upright on the ground. Do not remove your

foot from the foot bar when you are lowering the drum until it is flat on the floor.

3. The catch can now be unhooked from the drum and the trolley can be wheeled away.

Drum catch variations

WARNING –Due to variations in the manufacture of drums it is important that

the correct hook position is selected. Failure to do so could result in the catch

disconnecting from the drum.

The drum catch has been designed so that there a various number of positions it

can be used in to fit different sized drums. By removing the top ‘R’ clip the top

catch can be turned over so that the sticker is upside down. This gives the catch

a further 5mm of reach. By changing the hole that the top catch is located on

increases the reach by a further 10mm by each hole placement. The top hook

must always be placed in the shortest possible position.

The following examples are for guidance only.

Most Drum Types

The top hook

should be mounted

the correct way up

and in the bottom

hole.

Steel Open Top

The top hook

should be mounted

with the labels

inverted and in the

bottom hole.

Mauser Open Top

The top hook

should be mounted

the correct way up

and in the third

hole.

Operation and maintenance manual

Product code: DTC01 (Ex)

Product description: Universal Drum Trolley

BESPOKE HANDLING EQUIPMENT LTD

Technical Support Line: +44 (0)1736 851050

Decommissioning and disposal

Final de-commissioning or disposal of the unit must be performed in accordance

with the regulations of the country of use, meeting the countries regulations for

disposal of hazardous materials. In particular, regulations governing the disposal

of batteries, fuels and electronic and electrical systems must be observed.

Maintenance

Any maintenance needs to be carried out by a competent individual.

The unit is designed to be maintenance free.

•Before use inspect unit thoroughly for signs of damage.

•For cleaning it is recommended that if any degreasing agents or high

pressure cleaners are to be used then they should be used with great caution

as to avoid the degreasing of any mechanical components.

If you do not understand any part of this manual and/or need assistance, please

Bespoke Handling Equipment Ltd.

Leedstown

Hayle

Penzance

TR27 6DS

Table des matières

Autres manuels STS Système de levage

STS

STS STP01-DRU01-EX Manuel utilisateur

STS

STS STP08-FAC01-HDLC-E Series Manuel utilisateur

STS

STS STP01-RRH01-Ex Manuel utilisateur

STS

STS STP12-FAC01-1300KG-Ex Manuel utilisateur

STS

STS DPC01-R500 Manuel utilisateur

STS

STS STE01-DRU01 Manuel utilisateur

STS

STS STM01-DRU01-Ex Manuel utilisateur

STS

STS DTP05 Manuel utilisateur

Manuels Système de levage populaires d'autres marques

morse

morse 82H-124 Manuel utilisateur

Braun

Braun NL955 Series Manuel utilisateur

haacon

haacon 1889.10 Manuel utilisateur

Protekt

Protekt AT 252 Manuel utilisateur

R. Beck Maschinenbau

R. Beck Maschinenbau HS 600 Manuel utilisateur

Nova Technology International, LLC

Nova Technology International, LLC NAS Series Manuel utilisateur

Genie

Genie Z-60/34 Manuel utilisateur

Screen Technics

Screen Technics INTERFIT Vertical Up Lift Manuel utilisateur

Mortuary Lift

Mortuary Lift ULTIMATE 1000 Manuel utilisateur

Custom Equipment

Custom Equipment Hy-Brid 3 Series Manuel de programmation

Custom Equipment

Custom Equipment Hy-Brid Lifts 2 Series Manuel de programmation

Hy-Brid Lifts

Hy-Brid Lifts HB-P3.6 Manuel de programmation

BERG

BERG BeNomic EasyLeaf Manuel utilisateur

Powermate

Powermate LiftGate LG-3 Manuel utilisateur

Snorkel

Snorkel TM12 Series Manuel utilisateur

Terberg

Terberg OMNIDEKA Manuel utilisateur

Harmar Mobility

Harmar Mobility AL625 Mode d'emploi

Rotary

Rotary SPO16 Manuel utilisateur