stellar labs Slider Manuel utilisateur
Slider Hooklift
Owner’s Manual
Stellar Industries, Inc.
190 State Street
PO Box 169
Garner, IA 50438
800-321-3741
Fax: 641-923-2811
www.stellarindustries.com
Subject to Change without Notication.
© 2013 Stellar Industries, Inc. Last Revision: 10/21/13
Safety • Operation • Maintenance • Troubleshooting
Page ii | Stellar®Slider Owner’s Manual
Slider Hooklift Manual Revisions
Date of Revsion Section Revised Description of Revision
Stellar®Slider Owner’s Manual | Page iii
Table of Contents
For Technical Questions, Information, Parts, or Warranty, Call Toll-Free at
800-321-3741
Hours: Monday - Friday, 8:00 a.m. - 5:00 p.m. CST
Or email at the following addresses:
Order Parts [email protected]
Warranty Information [email protected]
Introduction .........................................................................................................iv
Hooklift Nomenclature ........................................................................................v
Chapter 1 - Operation ........................................................................................... 1
General Operation ..............................................................................................1
Operator Requirements ......................................................................................1
Pre-Operation Inspection ...................................................................................2
Job Site Setup ......................................................................................................2
Hooklift Controls ...................................................................................................3
Hydraulic Hook Height Adjustment - Raise .......................................................4
Hydraulic Hook Height Adjustment - Lower ......................................................4
Loading Operation ..............................................................................................5
Unloading Operation ..........................................................................................7
Unloading Operation Continued... ...................................................................8
Dumping Operation ............................................................................................9
Safety Decals of Note .......................................................................................10
Chapter 2 - Maintenance.................................................................................... 13
Basic Hooklift Inspection Schedule ..................................................................13
General Maintenance Guidelines ..................................................................14
Hydraulic Oil/Filter Maintenance .....................................................................14
PTO and Pump Maintenance ..........................................................................14
Choice Lubricants for DX Bearings ..................................................................15
Chapter 3 - Troubleshooting................................................................................ 17
Serial Tag Location ............................................................................................17
General Troubleshooting ..................................................................................18
Page iv | Stellar®Slider Owner’s Manual
Introduction
Stellar® Hooklifts are designed to provide safe and dependable service for a variety of
operations. With proper use and maintenance, these hooklifts will operate at peak perfor-
mance for many years.
To promote this longevity, carefully study the information contained in this manual before
putting the equipment into service. Though it is not intended to be a training manual for
beginners, this manual should provide solid guidelines for the safe and proper usage of the
hooklift.
Once you feel comfortable with the material contained in this manual, strive to exercise
your knowledge as you safely operate and maintain the hooklift. This process is vital to the
proper use of the unit.
A few notes on this manual:
A copy of this manual is provided with every hooklift and can be found in the hard plastic
manual case that is installed on the chassis. A copy of this manual shall remain with the
hooklift at all times.
Throughout the manual, three signal words will be used to bring attention to important
items:
A NOTICE signal word indicates a practice not related to physical injury.
A WARNING signal word indicates a hazardous situation which, if not
avoided, could result in death or serious injury.
A DANGER signal word indicates a hazardous situation which, if not
avoided, will result in death or serious injury.
Information contained within this manual does not cover all maintenance, operating, or
repair instructions pertinent to all possible situations. Please be aware that some sections
of this manual contain information pertaining to Stellar® manufactured hooklifts in general
and may or may not apply to your specic model.
This manual is not binding. Stellar Industries, Inc. reserves the right to change, at any time,
any or all of the items, components, and parts deemed necessary for product improve-
ment or commercial/production purposes. This right is kept with no requirement or obliga-
tion for immediate mandatory updating of this manual.
In closing:
If more information is required or technical assistance is needed, or if you feel that any part
of this manual is unclear or incorrect, please contact the Stellar Customer Service Depart-
ment by phone at 800-321-3741 or email at [email protected].
WARNING
NOTICE
DANGER
Stellar®Slider Owner’s Manual | Page v
Hooklift Nomenclature
The Stellar® Slider is a hydraulic, body-loading device when mounted on a truck chassis. It
can handle a multitude of bodies ranging from atbeds to recycling containers and dump
bodies.
The Slider consists of four basic parts: the base, dump, secondary, and jib sections. Please
take the time to familiarize yourself with the various components. Knowing the proper ter-
minology is necessary to get the full benet of this manual.
BASE
DUMP
JIB
SECONDARY
HOOKLIFT
Page vi | Stellar®Slider Owner’s Manual
This page intentionally left blank.
Stellar®Slider Owner’s Manual | Page 1
Operation is limited to the following people:
A. Qualied individual.
B. Trainees under direct supervision of the qualied individual.
C. Test or maintenance individual.
D. Hooklift Inspector.
Qualied individuals must:
A. Demonstrate the ability to understand all decals, the owner’s manual, and any other
information required for safe operation of the hooklift.
B. Be able to demonstrate the ability to safely control the hooklift.
C. Know all safety regulations.
D. Be responsible for maintenance requirements.
E. Understand and be fully capable of implementing all emergency procedures.
F. Understand all operating procedures as outlined by this manual.
Operator Requirements
It is the responsibility of the owner to instruct the operator in the safe operation of the
equipment and to provide the operator with properly maintained equipment.
Stellar® Hooklift operators must conform to the qualications specied in
this manual. Trainees or untrained persons shall be under the direct supervision of qualied
persons.
Operators shall consult with the owner of the equipment regarding current safety regula-
tions and required personal protective equipment.
Operators should never operate the hooklift while under the adverse inuence of alcohol,
drugs, or medication.
Please take note that Stellar Industries, Inc. is not liable for accidents incurred by the hook-
lift because of non-fulllment from the operator’s side of current rules, laws, and regula-
tions.
WARNING
General Operation
Chapter 1 - Operation
Safety should be the n umber one thought on every operator’s mind. Three factors should
exist for safe operation: a qualied operator, well-maintained equipment, and the proper
use of this equipment.
This chapter contains information regarding the safety and operation of Stellar® manufac-
tured Hooklifts and should be read and understood completely by everyone working with
or near the hooklift before putting the unit into operation.
Failure to follow operating, maintenance, or safety instructions can result
in death or serious injury.
WARNING
Page 2 | Stellar®Slider Owner’s Manual
Thoroughly plan the lift by understanding the work site area and your loads before position-
ing the vehicle. Consider the following:
• Know the weight of your load to avoid overloading the equipment. Deduct the weight
of the body from the maximum load rating to determine how much weight can be lifted.
• Only use the hooklift to lift Stellar approved skids, bodies, or containers.
• Do not overload the hooklift. Never exceed manufacturer’s load rat-
ings. These ratings are based on the machine’s hydraulic, mechanical, and structural
design rather than stability. Know the hooklift components and their capabilities and lim-
itations. Overloading the hooklift may result in serious damage of self, others, equipment
or the surroundings.
• Do not allow unauthorized personnel or equipment to enter within 10
feet of hooklift operating area. The vehicle should be positioned in an area free from
bystanders and overhead obstructions. Use a signal person if necessary.
• Always maintain safe clearance from high voltage power lines. Death
or serious injury will result from inadequate clearance if hooklift, load, or vehicle becomes
electrically charged.
• Make certain that the vehicle is parked on stable, at ground as close to the job as
possible. The surface under the service truck must be able to support the weight of the
machine and its load. Take care when operating in areas supported by vehicle tires, be-
cause of the cushioning effect of springs and tires.
• Do not operate the hooklift during electrical storms.
• In dusty work areas, every effort must be taken to keep dust and sand out of the moving
parts of the machinery.
• In high humidity work areas, keep parts as dry as possible and well lubricated.
Job Site Setup
WARNING
WARNING
WARNING
DANGER
Before operating the equipment, make sure all regular maintenance has been performed.
Each day, inspect the hooklift for all of the following:
• Hydraulic reservoir oil level.
• Hydraulic hoses and tubing for evidence of damage such as blistering, crushing, or abra-
sion.
• All safety covers for proper installation.
• Equipment for missing, illegible, or defaced operating decals and safety signs.
• Structural weldments for bends, cracks, or breaks
• All pins and keepers for proper installation
• Presence of this owner’s manual
• All pins, bushings, shafts, and gears for wear, cracks, or distortion to include all pivot
points, and bushings
• Replace/repair as necessary prior to operation.
Pre-Operation Inspection
Stellar®Slider Owner’s Manual | Page 3
Be familiar with the sequence and operation of the hooklift controls.
Each individual hooklift function should have control function decals. Replace them im-
mediately if they are missing or illegible.
Keep hands, feet and control levers free from mud, grease and oil.
Be familiar with the control levers and how they operate before attempting to operate the
hooklift.
Move the control lever slow and smooth for steady oil ow. Avoid jerky or sudden move-
ment of the controls.
Be constantly aware of the hooklift position when operating the controls.
In extreme cold, operate the controls slowly to allow for viscosity changes.
Hooklift Controls
WARNING
Stellar®Slider Controls
55755 - Rev A
Be familiar with the control functions and
sequence of operation. See owner’s manual
for specific information regarding operation.
LIFT
SLIDE HOOK
Do not attempt to load
container unless hook
and bail heights match.
Failure to match hook
and bail heights can
result in death or serious
injury.
Misuse Hazard
Page 4 | Stellar®Slider Owner’s Manual
With the hooklift in the stowed position with-
out a body, put the truck in neutral and
engage the PTO.
Push the control lever labeled ‘hook’ to
lower the hook height. When lowered com-
pletely, release the lever and disengage the
PTO.
PTO ON PTO OFF
Hydraulic Hook Height Adjustment - Lower
With the hooklift in the stowed position with-
out a body, put the truck in neutral and
engage the PTO.
Hydraulic Hook Height Adjustment - Raise
Pull the control lever labeled ‘hook’ to raise
the hook height. When raised completely,
release the lever and disengage the PTO.
PTO ON PTO OFF
Table des matières
Autres manuels stellar labs Système de levage
stellar labs
stellar labs Slider50 Manuel utilisateur
stellar labs
stellar labs Slider26 Manuel utilisateur
stellar labs
stellar labs 108-11-32 Manuel utilisateur
stellar labs
stellar labs SHUTTLE 120-15-9 G Guide de configuration
stellar labs
stellar labs Slider65 Manuel utilisateur
stellar labs
stellar labs SHUTTLE 120-15-13 G Guide de configuration
stellar labs
stellar labs Slider40 Manuel utilisateur
stellar labs
stellar labs SI-60 Manuel utilisateur
stellar labs
stellar labs 108-11-32 Manuel utilisateur
stellar labs
stellar labs Slider40 Manuel utilisateur
stellar labs
stellar labs 84-12-9 G Guide de configuration
stellar labs
stellar labs ECCR Manuel utilisateur
stellar labs
stellar labs Slider34 Manuel utilisateur
stellar labs
stellar labs 108-12 Flex Manuel utilisateur
stellar labs
stellar labs Slider20 Manuel utilisateur
stellar labs
stellar labs 108-14-32 Manuel utilisateur
stellar labs
stellar labs SHUTTLE 84-12-13 G Guide de configuration
stellar labs
stellar labs Flex36 60-8 Manuel utilisateur
stellar labs
stellar labs Slider 20-S Manuel utilisateur
stellar labs
stellar labs Slider20-S Manuel utilisateur
Manuels Système de levage populaires d'autres marques
morse
morse 82H-124 Manuel utilisateur
Braun
Braun NL955 Series Manuel utilisateur
haacon
haacon 1889.10 Manuel utilisateur
Protekt
Protekt AT 252 Manuel utilisateur
R. Beck Maschinenbau
R. Beck Maschinenbau HS 600 Manuel utilisateur
Nova Technology International, LLC
Nova Technology International, LLC NAS Series Manuel utilisateur
Genie
Genie Z-60/34 Manuel utilisateur
Screen Technics
Screen Technics INTERFIT Vertical Up Lift Manuel utilisateur
Mortuary Lift
Mortuary Lift ULTIMATE 1000 Manuel utilisateur
Custom Equipment
Custom Equipment Hy-Brid 3 Series Manuel de programmation
Custom Equipment
Custom Equipment Hy-Brid Lifts 2 Series Manuel de programmation
Hy-Brid Lifts
Hy-Brid Lifts HB-P3.6 Manuel de programmation
