Ski-Doo MX Z X 440 Manuel

Mmo-2005 MX Z X 440 suppl.FH8 Fri Aug 13 13:26:44 2004 Page 1

Composite

C M Y CM MY CY CMY K

SAFETY WARNING

Disregarding any of the safety precautions and instructions

contained in this Operator’s Guide Supplement,Safety Videocas-

sette or on-product warnings may result in injury, including the

possibility of death.

This Operator’s Guide Supplement and Safety Videocassette

should remain with the unit at time of resale.

In USA, products are distributed by BRP US Inc.

In Canada, products are distributed by Bombardier Recreational Prod-

ucts Inc.

The following are trademarks of Bombardier Recreational Products

Inc. or its subsidiaries.

SKI-DOO ADRENALINETM LEGENDTM

REV®ROTAX®DESSTM

GSXTM RERTM SUMMIT®

GTX†MX-Z®

† GTX is a trademark of Castrol Ltd. Used under license.

Printed in Canada. (MMO2005-006 SH)

©Bombardier RecreationalProductsInc.andBRPUSInc.Allrightsreserved.

®™Trademarks of Bombardier Recreational Products Inc. or its affiliates.

*Trademarkof Bombardier Inc.used underlicense.

Dear 2005 MX Z XTM 440 owner, informations in the 2005

ZXTM/REV®Series Operator's Guide (P/N 520 000 499) also

apply to your MX Z X 440 except for the following.

__________________________ 1

TABLE OF CONTENTS

4) Brake/Parking Brake Pilot Lamp (Red)...................... 5

11) Tether Cord Cut-Out System .............................. 6

13) Engine Cut-Out Switch .................................... 6

28) Fuel Level .................................................. 7

60) Adjustable Suspensions ................................... 7

61) Primer Button .............................................. 8

62) Pre-Heat Switch............................................ 9

Recommended Fuel ........................................... 10

Recommended Oil ............................................. 11

METRIC (SI) .................................................... 13

IMPERIAL ...................................................... 13

UNITED STATES ............................................... 13

Brake System .................................................. 15

Coolant Pump Shaft Oil Reservoir............................. 15

Coolant Reservoir .............................................. 15

Drive Belt Removal/Installation................................ 17

2__________________________

LIMITED WARRANTY VALIDATION

Because of its racing application, the 2005 MX Z X 440 is shipped

from the factory with high compression ratio (CR) combustion cham-

ber inserts installed.

To validate limited warranty coverage and to run engine with 91 oc-

tane number gasoline (R + M)/2 inside North America (95 RON out-

side North America), the following modifications must be done at

predelivery before using the vehicle.

1. Low CR combustion chamber inserts must be installed on en-

gine. The high CR combustion chamber inserts must be returned

to BOMBARDIER Warranty Department.

2. Replace the main jets with the ones recommended in the Prede-

livery bulletin.

3. Replace the needle jets with the ones recommended in the Pre-

delivery bulletin.

4. Disconnect the pre-heat switch as explained in the Predelivery

bulletin.

__________________________ 3

RACING APPLICATION

For racing application, the main jets have to be replaced according to

thechartfoundonbeltguard.

4__________________________

CONTROLS/INSTRUMENTS

A33A1RA

2 3 8 13

NOTE: See description of numbered items in 2005 ZX/REV Series

Operator’s Guide (P/N 520 000 499) except for the following.

4) Brake/Parking Brake Pilot Lamp (Red)

This pilot lamp is disabled (does not light up) on the MX Z X 440.

WARNING

Make sure parking brake is fully disengaged before operating

the snowmobile.

When you ride the vehicle, brake that are caused to drag by

a continuous pressure on the lever may cause damage to the

brake system and cause loss of braking capacity and/or fire.

__________________________ 5

11) Tether Cord Cut-Out System

General

The tether cord cut-out system prevents snowmobile to runaway, if

the operator accidently falls off, by shutting off the engine.

WARNING

Always disconnect tether cord when leaving vehicle unattend-

ed and keep in a secured location.

Operation

Attach tether cord to clothing eyelet then snap tether cord cap over

post before starting engine.

To stop engine, completely pull cap from post.

13) Engine Cut-Out Switch

Locatedonrightsideofhandlebarthisswitchisusedtostopthe

engine.

OFF

A33E0HB

OFF

6__________________________

28) Fuel Level

Open fabric door to see the fuel level through the translucent fuel

tank.

A33H1OA 1

1. Fabric door

60) Adjustable Suspensions

NOTE: There is no rear shock motion ratio adjustment on the

MX Z X 440.

In addition to all suspension adjustments described in ZX/REV Series

Operator’s Guide, take note of the 2 following points.

Shocks

All 4 shocks feature 2 adjustments.

Low Speed Compression Adjuster

The low speed adjuster modifies the damping force for small suspen-

sion velocities —less than 0.75 m/s (2.5 ft/s). It tunes the vehicle

for braking, cornering, hole shot and all the bumps that create low

speed movement in the suspension. This adjuster has 4 turns of

adjustment. Use a flat screwdriver to adjust it. Turning it clockwise

increases shock damping action (stiffer) for these low compression

speeds.

__________________________ 7

High Speed Compression Adjuster

The High speed adjuster modifies the damping force for high sus-

pension velocities —more than 0.5 m/s (1.6 ft/s). It tunes the ve-

hicle for hoops or bumps that create high speed movement in the

suspension. This adjuster has 3 turns of adjustment. Use a 17 mm

wrench to adjust it. Turning it clockwise increases shock damping

action (stiffer) for these high compression speeds.

A33F0DA 12

1. Low speed compression adjuster (flat screwdriver)

2. High speed compression adjuster (17 mm wrench)

Center and Front Springs

CAUTION: Make sure that center spring and both front springs

are still preloaded when front of vehicle is off the ground. Max-

imum spring preload is 25 mm (1 in). Otherwise, spring will be

coil bound when fully compressed.

61) Primer Button

Pull and push button. It is not necessary when engine is warm.

To prime, activate button until a pumping resistance is felt. From

this point, pump 2 or 3 times to inject fuel in intake manifold. After

priming, ensure that primer button is pushed back.

NOTE: In very cold temperature, it is recommended to rotate primer

button 3-4 turns prior to pull it. This will eliminate the possibility of

sticking.

8__________________________

Table des matières

Autres manuels Ski-Doo Véhicule tout-terrain

Ski-Doo

Ski-Doo EVEREST L/C ELECTRO 1981 Manuel utilisateur

Ski-Doo

Ski-Doo RV 340 Manuel utilisateur

Ski-Doo

Ski-Doo Tundra Skandic Series Manuel

Ski-Doo

Ski-Doo Scandic WT 550F Manuel

Ski-Doo

Ski-Doo 2006 MX Z Manuel

Ski-Doo

Ski-Doo MX Zx 600 RS Manuel

Ski-Doo

Ski-Doo Expedition Series Manuel

Ski-Doo

Ski-Doo ELITE SERIES Guide d'installation

Ski-Doo

Ski-Doo CK 3 Manuel

Ski-Doo

Ski-Doo 750 Plus 1979 Manuel utilisateur

Ski-Doo

Ski-Doo 2006 RF series Manuel

Ski-Doo

Ski-Doo Tundra Skandic Series Manuel

Ski-Doo

Ski-Doo Legend Manuel

Ski-Doo

Ski-Doo RT series Manuel

Ski-Doo

Ski-Doo 1972 Elan Manuel utilisateur

Ski-Doo

Ski-Doo 2005 SUMMIT HIGHMARK X Guide d'installation

Ski-Doo

Ski-Doo 2006 RT series Manuel

Ski-Doo

Ski-Doo CITATION LS 1986 Manuel utilisateur

Ski-Doo

Ski-Doo 440 Manuel utilisateur

Ski-Doo

Ski-Doo 2008 Rev series Manuel

Ski-Doo

Ski-Doo REV Series Manuel

Ski-Doo

Ski-Doo 2005 ZX series Manuel

Ski-Doo

Ski-Doo Mini Z Manuel

Ski-Doo

Ski-Doo REV-XP 2009 Manuel

Manuels Véhicule tout-terrain populaires d'autres marques

Polaris

Polaris RANGER XP 1000 EPS 2018 Manuel utilisateur

Yamaha

Yamaha Tri Moto 125 Manuel utilisateur

Yamaha

Yamaha YFM350X Warrior Manuel utilisateur

APRILIA

APRILIA QUASAR 100 Manuel utilisateur

Polaris

Polaris RZR 900 Manuel utilisateur

Suzuki

Suzuki LT-A700X Manuel utilisateur

Suzuki

Suzuki LT-Z400 Manuel utilisateur

Arctic Cat

Arctic Cat 120 sno pro Manuel utilisateur

Yamaha

Yamaha RS90PB Manuel utilisateur

Yamaha

Yamaha FX Nytro FX10X Manuel utilisateur

Dinli

Dinli DL702 Manuel utilisateur

Yamaha

Yamaha SXV70ML Manuel utilisateur

Baja motorsports

Baja motorsports ATV 90 Manuel

Polaris

Polaris Sportsman 550 XP EPS Manuel utilisateur

Arctic Cat

Arctic Cat ALTERRA 450 Manuel utilisateur

Polaris

Polaris Sportsman 9922233 Manuel utilisateur

Yamaha

Yamaha YFM45FAT Manuel

Polaris

Polaris RZR XP 1000 Manuel utilisateur