Seresco NE Series Manuel utilisateur

OPERATION AND

MAINTENANCE MANUAL

NE SERIES

DEHUMIDIFIERS

NE-008 to NE-016

NE-216toNE-232

Classic Indoor Model

serescodehumidifiers.com

B–TableofContent

OMM.B.S.BI.01

B‐

February

2020



TableofContent

ChapterC‐GeneralInformation C–1



OperatingSafety

C–1



ReferenceandAdditionalInformation

C–2

ContactUs

C–2



BasicInformation

C–3

oDehumidifierViewandOptions

C–3

DehumidifierExternalSystemsConnection

C–5

oDehumidifierOptionalArrangement

C–6

oAirConditioningOptions–OutdoorAirCondensersandFluidCoolers

C–6

EquipmentSpecificData

C–8

ChapterD‐LayoutandComponents D–1



DehumidifierMainComponents

D–1



ControlSystem

D–3

OutdoorAirCondensersandFluidCoolersLayoutandComponents

D–5

ChapterE‐SequenceofOperation E–1



SetPoints

E–1

Ventilation



SpaceHeating

E–1



AirConditioning,DehumidificationandPoolHeating

E–1

Compressor(s)

E–1

ChapterF‐InterfaceandCommunication F–1



TouchDisplayOperatorPanel

F–1

oAlarms F–2



RemoteCommunication

F–3

ChapterM‐BasicMaintenanceM‐1



MaintenanceandSafety

M–1



MaintenanceKeyPoints

M–1



RoutineMaintenanceProgram

M–2



SpecificComponentsMaintenance

M–3

ChapterW‐Warranty W–1

B–TableofContent

B‐





Thispageisleftblank



C–GeneralInformation

OMM.C.S.BI.01

C‐

February

2020



GeneralInformation

ThismanualprovidesbasicinformationabouttheapplicableSerescodehumidifieranditsoperation.

Importantinformationregardinginstallation,maintenance,andstartupaswellasadditionalandauxiliarysystems

anddevices(outdoorcondenser,communicationinterfaces,etc.)isnormallyprovidedwiththedehumidifierand

canalsobeobtainedfromthemanufacturer(seeContactUsbelow).

OperatingSafety(Warnings,Cautions,andNotes)



FORYOURSAFETY:READBEFOREPERFORMINGANYOPERATIONS,MAINTENANCEORSERVICETASKS!



Onlyqualifiedtechniciansshouldinstall,operate,maintainorservicemechanicalequipment

includingcurrentdehumidificationsystem.

Makesuretoreadthismanualbeforeperforminganytaskstofamiliarizeyourselfwiththe

equipmentaswellaswithanypotentialhazards.Alwaysexercisecaution!



Bewareofelectricalpowerandhighelectricalvoltage!

• Followpropersafetyprocedures–lockout,tagout,andotherrespectiveprocedures

• Failuretofollowsafetyprocedurescanresultinseriousinjuryordeath



Bewareofmovingpartsandhotsurfaces!



• Makesuretostopallmovingparts(fans,blowers,etc.)beforeaccessingtheequipment’s

internalspace

• Beawareofhotsurfaces(hotrefrigeration,spaceheatingpipes,coils,heaters,etc.)



Bewareofhighpressuresandchemicals!



• Dehumidifiers,equippedwithcompressors,containrefrigerantunderhighpressure;oilis

alsocontainedinthecompressorandrefrigerationcircuit(s)

• Somedehumidifiersmayalsocontainotherliquidssuchasglycolmixturesandpoolwater



Thefollowingwarnings,cautions,andnotesappearthroughoutthismanualandreferenceddocumentation

wheneverspecialcaremustbetakentoavoidpotentialhazardsthatcouldresultinequipmentmalfunctionor

damage,personalinjury,ordeath.



WARNING



Indicatesapotentiallyhazardous

situationwhichcouldresultin

seriousinjuryordeathifhandled

improperly.

CAUTION



Indicatesapotentiallyhazardous

situationwhichcouldresultin

moderateinjuryorequipment

damageifhandledimproperly.



Note

Indicatesasituationthatcould

resultinequipmentdamageor

improper/ineffectiveoperationif

handledimproperly.

C–GeneralInformation

C‐



ReferenceandAdditionalInformation



Forsafe,efficientandproblem‐freeoperation,itiscriticaltohandlethedehumidifier(aswellasrelatedsystems

andcomponents)properlyateachstep‐fromreceivingandstoragetoinstallationandstartup.Relevant

informationcanbefoundintherespectivedocuments(likeInstallationManual)providedwiththedehumidifier.

Thismanualandotherrelateddocumentscouldbeobtainedfromthemanufacturer(seeContactUsbelow).



ContactUs



Seresco



1071AgesDrive

Ottawa,ONK1G6L3

Canada

http://serescodehumidifiers.com

Forimmediateassistance:1‐833‐DAS‐POOL(327‐7665)



Start‐upRequests:Start‐ups@dehumidifiedairservices.com

MiscellaneousInquiries:[email protected]

PartsRequests: Parts@dehumidifiedairservices.com

Warranty: Warranty@dehumidifiedairservices.com





Attention:InstallationandServiceContractors



WARNING!

Anywork(installation,startup,service,maintenance,repair,etc.)onanymechanical

equipment(dehumidifier,outdoorcondenser,fluidcooler,etc.)mustbeperformedinaccordancewith

respectivemanufacturer’srecommendationsaswellassubmittaldocumentation,localCodesandRegulations,

andappropriatefieldpractices.Failuretodosocouldresultinpersonalinjury,equipmentdamageor

malfunction,andwillvoidequipmentwarranty.Onlyqualifiedandproperlytrainedindividualsshouldperform

tasksonthisequipment.



Attention:MaintenanceTeam

CAUTION.

Toensureequipmentlongevityandproperandefficientoperation,thedehumidifierandits

auxiliarysystemsanddevices(outdoorcondenser,fluidcooler,boilerpackage,etc.)shouldbemaintained

properlyandregularly.Failuretodosocouldnegativelyaffectpremisecomfortlevelsandpeople’shealth.It

couldalsoleadtoequipmentdamage,malfunction,prematuretearandwareandmayvoidequipmentwarranty.

C–GeneralInformation

OMM.C.S.BI.01

C‐

February

2020



BasicInformation

DehumidifierViewandOptions

StandardNE008–NE016dehumidifierscomeinhorizontal(Pic.C.1‐A)orvertical(Pic.C.1‐B)composition:



Pic.C.1‐A

HorizontalComposition



ReturnAir(RA)ductworkconnection‐

horizontal.

SupplyAir(SA)ductworkconnection

options–top,bottom,horizontalside

(leftorright).

OutdoorAir(OA)intakeductwork

connectionoptions–top,horizontalside

(leftorright).



PipingConnections

① CondensateDrain

② AC–Air‐Cooled(refrigeration)

③ AC–Water‐Cooled(water/glycol)

④ PoolHeatingWater

⑤ SpaceHeatingHotWater

Electricalconnection

C–GeneralInformation

C‐



DehumidifierOptions(applicabletoboth,verticalandhorizontal,configurations):

Indoor,single‐compressordehumidifiers,8to16toncoolingcapacity(apprx.)‐modelsNE008toNE016*.

oTwo‐compressordehumidifieroption(seeDehumidifierOptionalArrangementbelowfordetails):

16to32toncoolingcapacity(appx.)‐modelsNE216toNE232;

Airflowandductworkconnectionoptions(ReturnAir(RA),SupplyAir(SA)OutdoorAir(OA))*‐asshownon

Pic.C.1‐AandC.1–B.

OptionalPoolWaterHeating**.

OptionalSpaceHeating‐hotwatercoil,electricorgasheater***.

AirConditioning(AC)*–externalwatercooling,outdoorcondenserorfluidcooler.

*

Allavailableoptions(tonnage,ductworkconnections,ACoptionsetc.)areshown.Refertothesubmittal

andotherrelevantdocumentationforyourdehumidifier’soptions.

VerticalComposition



ReturnAir(RA)ductworkconnection‐

horizontal.

SupplyAir(SA)ductworkconnection

options–top,horizontalside(leftor

right).

OutdoorAir(OA)intake–top,horizontal

side(leftorright).



PipingConnections

① CondensateDrain

② AC–Air‐Cooled(refrigeration)

③ AC–Water‐Cooled(water/glycol)

④ PoolHeatingWater

⑤ SpaceHeatingHotWater

Electricalconnection

Pic.C.1‐B

C–GeneralInformation

OMM.C.S.BI.01

C‐

February

2020



**Thepoolwaterheatingoptionreliesoncompressor‐createdexcessheatandisusedasanadditional

heatingsource.Itdoesnoteliminatetheneedforamainpoolwaterheater.

***Forspecificdetailsonspaceheating(hotwater,gas,electric)option,refertothesubmittalandother

documentation:



Gas‐firedductheatercanbeprovidedforfieldinstallation(tobefittedinthesupplyairductwork).

Electricheaterorhotwatercoil,dependingoncapacity,model,size,etc.,canbeinstalledexternally(mountedonthe

topofSAopeningorfittedinthesupplyairductwork)orinternally.Refertoyourdehumidifier’ssubmittal

documentation.



DehumidifierExternalSystemsConnection



Pic.C.1–AandBshowprovisionsforexternalsystemsconnections,includingductwork,electricpowerand

controlwiresandvariouspipingconnections.

Exceptforthecondensate,allotherpipingsystemsareoptionalandmaynotbepresentineachdehumidifier.

AirConditioning(AC)Connection.Normally,thedehumidifierhasonlyoneACoption–air‐cooled(requiring

connectiontotheoutdooraircondenser)orwater‐cooled(requiringconnectiontothefluidcoolerorother

externalwater‐cooledsystemsuchasgeothermal,coolingtower,etc.).Therefore,onlyoneoftheseoptions

presentwiththeactualdehumidifier.

Gasline.Ifthedehumidifierisequippedwithagasheater(boiler,gasfurnaceetc.)forspaceheating

purposes,thegaslineconnectionistobebroughttothegasheaterdirectly.



Attention!EquipmentClearancesandDimensions!

CAUTION!

Forequipmentproperoperation,maintenanceandservice,respectiveclearancesshouldbe

maintained.Generally,30”clearancestotheequipmentmustbekeptforthemaintenanceandservicepurposes.

Forthespecificrequiredclearancesinformation,aswellasdehumidifieroveralldimensions,distancestopipe

connections,ductconnectionsetc.,refertothesubmittaldocumentation.

NOTE.

DehumidifierMUSTbeequippedwithaP‐trapatthecondensateconnectionforproperoperation!If

dehumidifierisrequested/providedfromthefactorywithoutP‐trap,oneMUSTbeinstalledonsitepriorto

dehumidifierbeingcommissioned.RefertothedehumidifierstickersandInstallationManualfordetails.

CAUTION!

Currentmanualshowsgeneral/defaultconnections’location.Fordetailsregardingspecific

dehumidifier’sconnections(actuallocation,pipingsizesandpositiondimensions,circuittypeandflowdirection

etc.),refertothedehumidifier’ssubmittaldocumentationaswellasdehumidifier’slabelsandstickers.

WARNING!

GasLine.Thegaslinemustbeinstalledinaccordancewithrespectivedevicedocumentation

(boiler,furnace,etc.)andlocalcodesandregulations.

C–GeneralInformation

C‐



DehumidifierOptionalArrangement

Two‐CompressorArrangement

StandardNEseriesdehumidifierhasonecompressor,

howevertwo‐compressorarrangementisavailablealso.Note,

thatalloptionsanddetails,providedabove,applytoboth,

standardandtwo‐compressorarrangement:

“Double‐Decker”dehumidifierisshownonPic.C.3.

Itiscomposedoftwoidenticaldehumidifiers,one

installedontopofanotherandcontrolledasasingle

dehumidifier(eachdeckisequippedwithone

compressor/refrigerationcircuit).



SingleandTwo‐CompressorArrangement–Dehumidifier

Model

Dehumidifiertypicalarrangement,totalcapacity,andnumberofcompressorsarereflectedinitsmodel(for

specificdehumidifiermodelrefertoitsMainLabel–seeSpecificDataInfobelow),asillustratedinexamples

below:

NE008–single‐decksingle‐compressordehumidifier.



Two‐compressorNEseriesdehumidifier:

NE216‐double‐decktwo‐compressordehumidifier(composedoftwoidenticaldehumidifiersNE008).

Mostoften,“Double‐Decker”comesastwohorizontaldehumidifiers,one“stacked”onthetopofanother,

howeveritcouldalsobecomposedoftwodehumidifiers(horizontalORvertical)installedsidebysideor

separately,stillbeingcontrolledasone.

AirConditioningOptions‐OutdoorAirCondensers(OACC)andFluidCoolers(OAFC).

BasicviewsofstandardairconditioningoptionsareshownonPic.C.4(below);standardcombinationsofthe

dehumidifierandrespectiveairconditioningoption(basedontheircapacities)areshowninTableC.1.

*TableC.1showsstandarddehumidifierand

condenser/coolercombination;dependingonnumberof

factors,dehumidifiermayhavedifferentcondenser/cooler

providedwithit‐refertothedehumidifier’ssubmittal

documentationformoredetails.

**Two‐compressordehumidifierwouldnormallyhave

paired‐uptwooutdoorcondensersofrespectivesize(oneper

compressor).

Forexample,NE216wouldhavedouble‐condenser,

composedoftwoNC‐Z‐1(seePic.C.4,Fig.1).

***Thepumppackageisoptional‐thefluidcoolermaybeprovidedwithoutit.

TableC.1.Dehumidifier‐ACCombination*

Dehumidifier–OutdoorCondenser**Fig.#

NE008NC‐Z‐11

NE010–NE016NC‐Z‐22

Dehumidifier–FluidCooler***Fig.#

NE008–NE012,

NE208–NE212

NG‐V‐113

NE014–NE016,

NE214‐NE224

NG‐V‐124

NE228–NE232NG‐V‐225

Pic.C.3

C–GeneralInformation

OMM.C.S.BI.01

C‐

February

2020





Attention!EquipmentClearances!

Properclearancesshouldbemaintainedforadequateairflowandheatrejection!Generally,upto36”sideand

96”topclearancesarerequired.Formoreinformationonclearancesaswellasequipmentdimensionsandother

details

refertothesubmittaldocumentation.

Pic.C.4

Autres manuels pour NE Series

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Seresco Déshumidificateur

Seresco

Seresco NV Series Manuel utilisateur

Seresco

Seresco NE Series Manuel utilisateur

Seresco

Seresco CLASSIC NE Series Manuel utilisateur

Seresco

Seresco NE Series Manuel utilisateur

Seresco

Seresco NP Series Manuel utilisateur

Manuels Déshumidificateur populaires d'autres marques

Daitsu

Daitsu CD031IU-DFA Manuel utilisateur

Fehom

Fehom PDGT701BE Manuel utilisateur

Hitachi

Hitachi RD-190GX Manuel utilisateur

Westpoint

Westpoint MDF1-30AE Manuel utilisateur

SOLIS

SOLIS easy dry compact Manuel utilisateur

ENVIROBOSS

ENVIROBOSS EB240 Manuel utilisateur

Sinclair

Sinclair R-9112 Manuel utilisateur

Kenmore

Kenmore 580.54701 Manuel utilisateur

Demargo

Demargo DM828NF Manuel utilisateur

Altrad Lescha

Altrad Lescha LDH 600 Manuel utilisateur

BOMANN

BOMANN LE 1150 CB Manuel utilisateur

SPT

SPT SD-46 Manuel utilisateur

REMKO

REMKO SLN 40 Manuel utilisateur

Haier

Haier HD458 Manuel utilisateur

Logik

Logik L20DHW12 Manuel utilisateur

Frigidaire

Frigidaire FDR30S1 - 30 Pint Capacity Dehumidifier Guide de démarrage rapide

Blitz

Blitz HHD Series Manuel utilisateur

Prem-I-Air

Prem-I-Air PD14DEN Manuel utilisateur