Sealey CP20VGG Manuel utilisateur

20V CORDLESS GLUE GUN - BODY ONLY

MODEL NO: CP20VGG

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,

and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SAFETY

1.1. GENERAL SAFETY

9 Familiariseyourselfwiththisproductsapplicationandlimitations,aswellasthespecicpotentialhazardspeculiartothegluegun.

WARNING!Disconnectthechargingleadbeforechangingaccessories,servicingorperforminganymaintenance.

9 Maintaintheglueguningoodcondition(useanauthorisedserviceagent).

9 Replaceorrepairdamagedparts.Userecommendedpartsonly.Unauthorisedpartsmaybedangerousandwillinvalidatethe 

 warranty.

WARNING!Alwayswearapprovedeyeorfaceprotectionwhenoperatingthegluegun.

9 Keeptheworkareaclean,unclutteredandensurethereisadequatelighting.

9 Removeillttingclothing.Removeties,watches,rings,andotherloosejewellery,andcontainand/ortiebacklonghair.

9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnon-slipshoes,

9 Securenonstableworkpiecewithaclamp,viceorotheradequateholdingdevice.

8DO NOTtouchthehotnozzleorthesiliconcap.

8DO NOTusethegluegunforataskitwasnotdesignedtoperform.

8DO NOT operatethegluegunifanypartsaredamagedormissingasthismaycausefailureand/orpossiblepersonalinjury.

8DO NOT holdtheworkpiecebyhand.Useclampsoravice(notincluded)tosecuretheworkpiece.AvailablefromyourSealeystockist.

8DO NOT getthegluegunwetoruseindamporwetlocationsorareaswherethereiscondensation.

8DO NOT placenozzleclosetoyourface(especiallyeyes,ears,etc)orotherpersonsoranimals.

8DO NOTallowchildrenoruntrainedpersonstooperatethegluegun.

8DO NOT operatethegluegunwhenyouaretiredorundertheinuenceofalcohol,drugsorintoxicatingmedication.

8DO NOTgetglueonyourskin.

8DO NOTinhaleanyvapourgiveno󰀨bytheglue. 

8DO NOTcarrythegluegunwithyourngeronthetrigger.

8DO NOTusethegluegunwherethereareammableliquids,solidsorgasessuchaspaintsolvents,etc.

8DO NOTleavethegluegunoperating/heatingupunattended.

9 Protectworksurfacefromgluespiltduringwarmupphaseandwhilstbeingused.

9 Afteruseplacethegluegundowntocoolinasafemanner.Ensureithascooleddowncompletelybeforestorage.

9 Whennotinuseswitchtheglueguno󰀨,storethetoolinasafe,drychildproofarea.

NOTE:Thisapplianceisnotintendedforusebypersons(includingchildren)withreducedphysical,sensoryormentalcapabilitiesor

 lackofexperienceandknowledge,unlesstheyhavebeengivensupervisionorinstructionconcerningtheuseofthe  

 appliancebyapersonresponsiblefortheirsafety.Childrenshouldbesupervisedtoensurethattheydonotplaywiththeappliance.

2. INTRODUCTION

Readytousein3minutes.Cordlessoperationallowsuseanywhereintheworkshop.Compositehousingwithsoftgripforaddedcomfort.

SuitableforgluestickbetweenØ10-12mm.On/o󰀨switchandtriggerfeedcontrol.

3. SPECIFICATION

Model no............................................................... CP20VGG

Max.runningtime.........................................................3.5hr

Battery ..........................20V2Ah-4AhLi-ion(notincluded)

Glue stick diameter................................................. 10-12mm

Consumables..... AK292/2-Allpurposegluestickpackof25

Original Language Version

Refer to

instruction

manual

Wear

protective

gloves

Warning!

hot

surface

Wear eye

protection

CP20VGG|Issue:106/11/19

Original Language Version

4. OPERATION

WARNING!Riskofburns.Ifhotgluecomesintocontactwithskin,holdunderastreamofcoldwaterforseveralminutes.

4.1.  Saveenergy,onlyswitchonwhenbeingused.

WARNING! Ensure On/O󰀨 switch is in OFF position.

4.2. FIT BATTERY

4.3. SWITCH ON

 SlidebuttonOn/O󰀨toturnon,redLEDindicatorlightwillilluminate.DO NOTleaveunattended.Placeonaheatproofsurface.

4.4. SWITCH OFF

SlideOn/O󰀨buttonredLEDindicatorwillturno󰀨.

4.5.  Afteruseplacegluegundowninasafemannerandallowittocooldowncompletelybeforestorage.

4.6. PREPARATION FOR GLUING

4.6.1. Surfacesmustbefreefromgrease,cleananddry.

4.6.2. Materialstobegluedaswellasthesurfaceonwhichtheworkistakingplacemustnotbeeasilyignitableorammable.

4.6.3. Checkthesuitabilityofmaterialstobegluedonatestworkpiece.

4.6.4. Ambienttemperatureofaworkpiecemustbebetween+5°Cand+50°C.

4.6.5. Materialssuchasmetals,whichcoolo󰀨thegluequickly,shouldbepreheatedwithahotairgun.

4.7. GLUING

4.7.1. Inserttheappropriategluestickintotheopeningintherearofthegluegun.

4.7.2. Switchonandallowtoheatup.

4.7.3. Pressthefeedtrigger,applyingmoderatepressure.

4.7.4. Applyglueontoonesideonly,pressthegluedsurfacestogether.Itisstillpossibletoadjustthelocationofthetwopiecesatthispoint.

4.7.5. Thegluedjointcanbesubjectedtoloadafteracooldownperiodofapproximatelytwominutes.

4.7.6. Removeglueresidueaftercoolingwithabluntobject.Ifnecessarygluedjointscanbeseparatedagainbyapplyingheat.

8DO NOTuseinammablesolventsforcleaningthesurfacestobeglued.Solventresiduescanignitefromhotglueorhazardous 

 vapourscoulddevelop.

8DO NOTremoveapartiallyusedgluestickfromtheendofthegluegun.

5. MAINTENANCE

WARNING!Removebatterybeforeperformingmaintenance.

5.1.  Cleanwithadampcloth,DO NOTusesolvents.

.

CP20VGG|Issue:106/11/19

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR

01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids

accordingtolocalregulations.

Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior

notice.

Important:NoLiabilityisacceptedforincorrectuseofthisproduct.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

WEEE REGULATIONS

DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment

(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid

wasteauthorityforrecyclinginformation.

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Sealey Pistolet à colle