Schell Dual flush Manuel utilisateur

Dual flush WC flush valve

IMPORTANT

The SCHELL Dual flush WC flush valve must be installed to the following

specifications:

• Requires a minimum of 133 mm wall cavity to finished wall and

a maximum of 178 mm.

• Inwall coverplate is suitable for a maximum wall thickness of 25 mm.

• Water supply:

Minimum delivery pipe size 25 mm with left or right connection to valve

body for 1 flush valve. For > 1 flush valve 32 mm supply pipe or according

to water service rule calculations and simultaneous demand requirements.

• Minimum flow: 1,3 litres/second at the valve

• Maximum static pressure may not exceed 800 KPA

• Recommended operating pressure: 200-500 KPA (Flow pressure)

Assembly and instructions

903006200_a.qxd 22.12.2008 11:16 Uhr Seite 1

1. 2. 3. 4.

Dual flush WC flush valve

Assembly and instructions

903006200_a.qxd 22.12.2008 11:16 Uhr Seite 2

5. 6. 7. 8.

9. 10. 11. 12.

13. 14. 15. 16.

17.

DRAIN

Important:

Make sure that

supplied lock

nut is fixed

tightly!

903006200_a.qxd 22.12.2008 11:16 Uhr Seite 3

Disturbance Possible reason Remedy Fig.

Flushing time too short Sleeve dried-up Water sleeve 16

Sleeve defective Change cartridge 8

Continuous flushing Piston seal or relief Change cartridge 8

valve defective

Amount of water Stop ring missing or Correct assembly 11+

too high or too low wrong assembled of stop ring 12

Flush too low Preliminary shutoff Open preliminary 6

not fully opened shutoff

Cartridge sieve dirty Rinse cartridge 16

Flush adjustment too low Adjust flush 13

Flow pressure too low Check flow pressure

(p < 12 metres head)

Flush too strong Flush adjustment too strong Regulate flush 13

Flow pressure too high

(p > 50 metres head) Reduce flow pressure

Figure 1 –Install Styrofoam blackout box with drip tray, mount tunnel, seal and

airbrake nut to supplied telescopic flush pipe.

Figure 2 –Install supplied stop cock to the water supply pipe.

Figure 3 –Install flush valve to stop cock (shut off valve). Tighten airbrake nut,

tunnel, and seal to the flush valve.

Figure 4 –Close the blacklout box with Styrofoam cover provided.

Figure 5 –Finish wall

Figure 6 –Mount hose to plastic connector at valve, open the stop cock and flush

valve clean of any debris and impurities in the supply pipe.

Figure 7 –Remove plastic hose connector from valve.

Figure 8 –Install cartridge.

Figure 9 –Cut back excess Styrofoam to finished wall.

Figure 10 –Cut and remove excess of drip tray depending on wall thickness.

Figure 11 –Circlip location will determine flush volume 6/3l or 9/4.4l.

Figure 12 –Locate circlip for desired flush volume.

Figure 13 –Adjust flush velocity.

Figure 14 –Mount cover plate mounting frame.

Figure 15 –Mount actuating threaded rod to desired length.

Securewith supplied lock nut tightly.

Figure 16 –Install cover plate and ensure that there is no slack between button and actuator rod.

Secure cover plate by tightening grub screw at base of cover plate with supplied allen

key.

903006200 a

903006200_a.qxd 22.12.2008 11:16 Uhr Seite 4

Autres manuels Schell Produits de plomberie

Schell

Schell Masterbox WBW-E-M Manuel utilisateur

Schell

Schell PURIS 01 360 06 99 Manuel utilisateur

Schell

Schell WBD-SC-M Manuel utilisateur

Schell

Schell CELIS 01 271 06 99 Manuel d'instructions

Schell

Schell PURIS E HD-K Manuel utilisateur

Schell

Schell WALIS E 01 950 06 99 Manuel utilisateur

Schell

Schell 01 230 06 99 Manuel utilisateur

Schell

Schell EDITION 02 800 06 99 Manuel d'instructions

Schell

Schell PURIS E 01 200 06 99 HD-K Manuel utilisateur

Schell

Schell POLAR II 03 998 03 99 Manuel

Schell

Schell LINUS DP-C-T Manuel utilisateur

Schell

Schell COMPACT 01 158 06 99 Mode d’emploi

Schell

Schell SCHELLOMAT 02 202 06 99 Mode d'emploi

Schell

Schell 01 230 06 99 Manuel utilisateur

Schell

Schell WBD-E-V 01 822 00 99 Manuel utilisateur

Schell

Schell PURIS 01 362 06 99 Manuel utilisateur

Schell

Schell COMFORT 01 846 06 99 Mode d'emploi

Schell

Schell LINUS D-C-T Manuel utilisateur

Schell

Schell LINUS Masterbox WBW-E-M Manuel utilisateur

Schell

Schell EDITION E 02 806 06 99 Manuel d'instructions

Schell

Schell CELIS E HD-K Manuel utilisateur

Schell

Schell COMPACT INFRA Batterie 9 V 01 123 06 99 Mode d’emploi

Schell

Schell POLAR II 03 995 03 99 Manuel

Schell

Schell COMPACT 03 230 00 99 Manuel utilisateur

Manuels Produits de plomberie populaires d'autres marques

Weka

Weka 506.2020.00E Mode d'emploi

Kohler

Kohler K-6228 Instructions de montage

UBERHAUS DESIGN

UBERHAUS DESIGN 75175017 Manuel utilisateur

American Standard

American Standard DetectLink 6072121 Manuel utilisateur

Uponor

Uponor Contec TS Manuel utilisateur

Pfister

Pfister Selia 49-SL Manuel utilisateur

Fortis

Fortis VITRINA 6068700 Manuel utilisateur

Fortis

Fortis MILANO 78211JS Manuel utilisateur

Kohler

Kohler K-12183 Instructions de montage

Maxxus

Maxxus MX-M206-01 Manuel utilisateur

Moen

Moen 5922 Series Manuel utilisateur

Viega

Viega Prevista Pure 8512 Manuel utilisateur

Kohler

Kohler Centerset K-15240 Instructions de montage

Viega

Viega Prevista Dry 8522.33 Manuel utilisateur

Sanela

Sanela Lema SLP 59RB Manuel utilisateur

Elkay

Elkay EDF15AC Manuel d'installation

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Manuel

baliv

baliv WT-140 Manuel utilisateur