Samsung Generation 6 Manuel utilisateur

Heat Pump Installation Guide 1

Generation 6

Samsung Heat Pump

Installation Manual

ONLINE WITHIN 28 DAYS OF

COMMISSIONING

IRELAND

www.joule.ie/register-a-product

NORTHERN IRELAND

www.jouleuk.co.uk/register-a-product

JL-SAMHPG6-DS-24-010-2019

www.jouleuk.co.uk | www.joule.ie

Warranty Card

Please register your product online

Homeowner

Name

Address

Contact Tel.

Contact Email

Installer

Name

Address

Contact Tel.

Contact Email

Product Product

Installed

Serial Number Installation

Date

Cylinder Located on

cylinder badge

Solar Thermal Take from

solar controller

Solar PV Ser. No. from

String / Micro Inverter

Air Source Heat Pump Located on external

heat pump badge

Integrated Heat Pump

and Cylinder

Located on

cylinder badge

Underoor Heating Project ref. on

supplied schematic

Was a Pre-Plumbed

cylinder installed too?

If installed, please ll out the Heat Pump Commissioning

Sheet too

Joule Advance Installer

I accept the terms and conditions in the installation manual

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

Heat Pump Installation Guide 3

Heat Pump

Commissioning Sheet

Please register your product online

Site Contact

Address

Installer

Contact

Installer

Address

Outdoor Unit Information

Model Number

Unit Location

Serial Number

Strainer Glycol added Glycol Concentration

Fuse Rating Mains Cable Size Space around unit

Drainage For

Outdoor Unit Unit Correctly Mounted

Water System

Flushed

Water System Filled And

Purged

Flow Switch tted Flow And Return Lines

Insulated

*Glycol level around 20% check with glycol manufacture for details

Refrigerant Piping For Split System

Strength Pressure Tightness Test

Pressure kg Vacuum Level

Refrigerant Piping

Length

Additional Charge

Amount bar Total System Charge

Outdoor Unit Operation Data

Power Supply Running Amps Delta T (ΔT)

Ambient Temp Air On Temp Air O Temp

Flow Temp In Flow Temp Out

Please continue on next page

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

www.jouleuk.co.uk | www.joule.ie

Heat Pump

Commissioning Sheet

Please register your product online

Heating Controls

Ground Floor Heat

Emitter

Type of Control

Used Serial Number

1st Floor Heat

Emitter

Type of Control

Used Blending Valve Fitted

Type of control i.e. Underoor heating system, programmable room stat, etc.

Tank And Mim Unit Data

Tank Manufacture Model Number Serial Number

DHW Storage Solar Installed Blending Valve Fitted

Control Box

Location

Benchmark Book

Completed Tank Sensor Fitted

Fuse Rating For

Mim Unit Cable Size Vented or Unvented

Immersion Heater

Volts

Flow And Return

Lines Insulated

Space Heating Field Settings

Code Function Default Site Settings

2011 Low Ambient temp for weather comp -10

2012 High Ambient temp for weather comp +15

2021 Flow temperature at low ambient point (2011) Zone 1 +40

2022 Flow temperature at high ambient point (2012) Zone 1 +25

2031 Flow temperature at low ambient point (2011) Zone 2 +50

2032 Flow temperature at high ambient point (2012) Zone 2 +35

2091

External Run input for Zone 1 ( Room stat )

(Not Use, Recommended-Use

(Signal only ON/OFF), Use(Signal ON/OFF) or WL Interlink OFF(Water Pump1)

Use(Signal ON/OFF) or WL Interlink OFF(Water Pump2)

Use(Signal ON/OFF) or WL Interlink OFF(Water Pump3)

0 (No)

2092

External Run input for Zone 2 ( Room stat )

(Not Use, Recommended-Use

(Signal only ON/OFF), Use(Signal ON/OFF) or WL Interlink OFF(Water Pump1)

Use(Signal ON/OFF) or WL Interlink OFF(Water Pump2)

Use(Signal ON/OFF) or WL Interlink OFF(Water Pump3)

0 (No)

2093 Remote Controller Room Temp Control 1

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

Heat Pump Installation Guide 5

Settings for Twin Heat Pump Installation & Hybrid Systems

Menu Code Function Default Site Settings

4021 Enables control output for back up heat pump (0=No 1=Yes) 0

4024 Ambient temperature below which the slave will assist +10

4031 Tells the Master unit that a backup boiler is tted (0=No 1=Yes) 0

4032 Tells the Master unit to use the boiler as back up at the value of 4033. ( Set to 1) 0

4033 Ambient condition for the boiler to be enabled -15

Domestic Hot Water & Heat Pump Settings

Menu Code Function Default Site

Settings

3011 Hot water cylinder tted (0= No 1=Yes) 0

3021 Heat Pump Max Temp for DHW 50

3024 Min. space heating time 5

3025 Max. cylinder heating time from heat pump before turning back to heating zones* 30

3032 Max. cylinder heating time from heat pump before turning on immersion to support it** 20

3041 Anti-Legionella function ( 0=O 1=Yes) 1

3042 Day of Anti-Legionella Function Friday

3043 Start Time of Anti Legionella function 23 Hrs

3044 Target Temp 70

3045 Hold Time at 3041 10

3051 Hotwater Boost Function (0=O 1=On) 0

3052 Hotwater Boost Timer duration x10 Min 6 (1hr)

3081 Back Up Heater ( 1st Step ) 0

3082 Back Up Heater ( 2nd Step ) 0

3083 Booster Heater Capacity 3

**30 = Domestic Hot Water Tank ( additional function )

*3025 = 200 Ltr Cylinder = 50 *3025 =300 Ltr Cylinder = 90

**3032 = 200 Ltr Cylinder = 50 **3032 =300 Ltr Cylinder = 90

Installer’s Signature

Print Name

Date

Heat Pump

Commissioning Sheet

Please register your product online

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

www.jouleuk.co.uk | www.joule.ie

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

Is the unit installed the correct distance from nearest boundaries?

Is the unit secured correctly to antivibration mounts via rubber mounts?

Is the unit mounted plumb level?

Is condensate drain kit tted? (drain kit located inside HP access door)

If unit is mounted on wall brackets, is drip tray installed?

Heating Controls

Heat Pump

Installation Checklist

Please register your product online

Is correct size pipe work used?

Are exible antivibration hoses tted and washers used?

Are heat pump isolation valves tted out at the heatpump?

Is Y-Strainer tted on the return pipework to heat pump and tted in the correct orientation?

Is ow and return pipe work connected the right way around?

Is Primary ow and return pipework insulated?

Heat Pump Plumbing (Outdoor)

Is the ow switch installed on the primary pipework and tted in the correct orientation? (Smart

Plumb Compact not applicable)

Is the ow switch installed on the primary horizontal pipework with 150mm pipe work each side

free of a bend or appliance? (Smart Plumb Compact not applicable)

Is Flow and Return pipe work connected the right way around?

Is the heating expansion vessel correctly sized, secured and charged to correct pressure? (Smart

Plumb Compact not applicable)

Is the Potable expansion vessel secured and charged to the correct pressure?

Are all pump valves and isolating valves fully open?

Has system been completely ushed of air and charged to the correct operating pressure of 2 bar?

Are all safety valves and tundish drained through a metal pipe to an appropriate drain point?

Cylinder Plumbing (Indoor)

Heat Pump Installation Guide 7

Heat Pump

Installation Checklist

Please register your product online

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

Has all air been removed from emitters?

Have all emitters been balanced correctly?

If UFH is installed, have correct owrates been set?

If UFH is installed, are all valves on manifolds/pumps fully open?

Radiator/UFH Plumbing

Is the correct size breaker used for heatpump?

Is an isolation switch installed for the heat pump and mounted on a xed structure out beside

heatpump?

Is the correct size power supply cable used for heat pump?

Are all cable protrusions avoiding condensate tray?

Is the correct communication cable installed and wired into correct terminals?

Heat Pump Wiring

Is the correct size breaker used for controller on cylinder?

Is an isolation switch installed for controller and mounted on a xed structure beside Controller?

Is the correct size power supply cable used for controller on cylinder?

Is the correct communication cable installed and wired into correct terminals?

Is the owswitch wired back into correct terminal on control panel? (Smart Plumb Compact not

applicable)

Cylinder Wiring

Is each zone/oor corresponding with the correct zone valve?

Are all heating controls powered from controller on cylinder?

Are all heating controls wired and working?

Heating Controls/Stats Wiring

www.jouleuk.co.uk | www.joule.ie

MUST BE COMPLETED AND

THEN REGISTERED ONLINE

TO COMPLETE WARRANTY

Heat Pump

Installation Checklist

Please register your product online

Homeowner

Name

Address

Contact Tel.

Contact Email

Installer

Name

Address

Contact Tel.

Contact Email

Installer’s Signature

Print Name

Date

Heat Pump must be commissioned within 30 days of installation in order to avail of warrenty regis-

tration. If it is found that your system cannot be commissioned due to inadequate installation, the

client will have 2 weeks to get issues rectied and recommissioned to avail of warranty registration.

Charges may apply if a second call out is required by a Joule representative.

Heat Pump Installation Guide 9

Table Of Contents

10 Commissioning, Service & Maintenance Package

11 Heat Pump Warranty

16 Joule Cyclone Warranty

17 Pre Installation Notes

18 First Fix Notes

20 Locating The Outdoor Unit

22 Installing The Unit

24 Condensate Management

26 Initial Start Up

28 Air Source Heat Pump & Smartplumb - 1 Heating & 1 DHW

28 • Mechanical & Electrical Diagram

30 • Field Setting Parameters

32 Air Source Heat Pump & Smartplumb - 2 Heating & 1 DHW

32 • Mechanical & Electrical Diagram

34 • Field Setting Parameters

36 Air Source Heat Pump & High Gain Indirect (1 Heating & 1 DHW)

36 • Mechanical & Electrical Diagram

38 • Field Setting Parameters

40 Air Source Heat Pump & High Gain Indirect (2 Heating & 1 DHW)

40 • Mechanical & Electrical Diagram

42 • Field Setting Parameters

44 Air Source Heat Pump & High Gain Indirect (2 Heating & 1 DHW)

44 • Mechanical & Electrical Diagram

46 • Field Setting Parameters

48 Air Source Heat Pump & High Gain Indirect (2 Heating & 1 DHW)

48 • Mechanical & Electrical Diagram

50 • Field Setting Parameters

52 Air Source Heat Pump & Smart Plumb Compact (2 or 3 Heating & 1 DHW)

52 • Mechanical & Electrical Diagram

56 • Transport & Handling

58 • Suitable Location

59 • Pipe Connections & Electrical Entry Point

60 • Temperature & Pressure Relief Valve Pipework

63 • Piping Diagram

64 • Heating System Connection

66 • Potable Pipework

68 • Commissioning

69 • Maintenance

70 • Field Setting Parameters

72 Starting The Heat Pump

74 Controller Symbols

76 Button Functions

78 Fault Codes

81 Trouble Shooting

82 Control Kit EHS Monoblock Wiring

88 Service Record

www.jouleuk.co.uk | www.joule.ie

Commissioning

From as little as £480/€578 Inc VAT

Annual Servicing

From as little as £360/€434 Inc VAT per year

All Samsung Air Source Heat Pumps supplied by Joule must be serviced annually to validate the

product warranty under the terms of the EUW agreement. Items that must be inspected annually

to validate the warranty include,

• Check outdoor fan motor and lubricate if needed

• Check electrical wiring, contacts and terminals; repair as required

• Check all safety components

• Check compressor operation

• Check indoor thermostat operation

• Check defrost and heating modes (winter only)

• Check for excessive noise and vibration

• Check refrigerant charge

• Inspect air lters

• Check all safety and pressure switches

• Check motor and heaters/voltage/amperes

You must ensure that if you do not choose a Joule service package then the service must be car-

ried out annually by a suitable qualied engineer to validate the terms of the Joule EUW agreement.

Heat pump Maintenance Package

Joule’s heat pump maintenance package entitles you to an annual maintenance visit, during which

our engineer will ensure that your Samsung heat pump supplied by Joule is operating within the

optimum conditions to maximise energy eciency. Any potential issue can be dealt with by a Joule

engineer. You will also be entitled to a discount on the cost of spare parts and labour.

Maintenance Package Response Times

Joule will schedule the planned annual maintenance visit with you, usually during the o peak

(Summer, Autumn) season. In the unlikely event of a fault, we will endeavour to respond as quickly

as possible

How Much Does The Heat Pump Maintenance Package Cost?

The maintenance package costs £360/€434 inc VAT per year and is payable in ad-vance before

we visit your premises. If any parts or remedial actions are required, we will provide an additional

quotation for this work.

All service oers are subject to payment in advance by cleared cheque or by debit/credit card. The

comprehensive service is available on a monthly direct debit plan.All service prices are inclusive of VAT.

Commissioning, Service & Maintenance

Package

Autres manuels Samsung Pompe à chaleur

Samsung

Samsung RC090MHXEA Manuel utilisateur

Samsung

Samsung AM160FNBFEB/EU Guide d'installation

Samsung

Samsung HHSM-G500005-1 Manuel utilisateur

Samsung

Samsung AM CNB C AA Series Manuel d'instructions

Samsung

Samsung AE090JNYDEH Manuel utilisateur

Samsung

Samsung AJ040TXJ2KG/EU Manuel d'instructions

Samsung

Samsung AEX060EDEHA Manuel utilisateur

Samsung

Samsung AE090JXEDEH Manuel utilisateur

Samsung

Samsung RC090MHXEA Manuel

Samsung

Samsung RC160MHXEA Manuel

Samsung

Samsung RC090MHXEA Manuel

Samsung

Samsung AEN160YDEHA Manuel utilisateur

Samsung

Samsung DV8 T 2 Series Manuel utilisateur

Samsung

Samsung AE CXYD Series Manuel utilisateur

Samsung

Samsung CNH NDB Series Manuel d'instructions

Samsung

Samsung AE160ANYD H Series Manuel utilisateur

Samsung

Samsung MIM-E03EN Manuel utilisateur

Samsung

Samsung AE050RXYDEG Manuel utilisateur

Samsung

Samsung AE040RXED Series Manuel utilisateur

Samsung

Samsung VRF DVM S2 Manuel d'instructions

Samsung

Samsung AE090JXYDEH Manuel utilisateur

Samsung

Samsung RD060PHXEA Manuel utilisateur

Samsung

Samsung RD060PHXEA Manuel utilisateur

Samsung

Samsung 050JXYDEH Manuel

Manuels Pompe à chaleur populaires d'autres marques

MICROWELL

MICROWELL HP 1000 GREEN Manuel utilisateur

Sanyo

Sanyo SAP120FCH Manuel utilisateur

Daikin

Daikin EHYHBH05AA Manuel utilisateur

Panasonic

Panasonic WH-SDF03E3E5 Mode d’emploi

Bryant

Bryant 544B Manuel utilisateur

Airxcel

Airxcel 45000 Series Manuel

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Manuel utilisateur

Dimplex

Dimplex LI 16I-TUR Guide de l'utilisateur

Carrier

Carrier WSHP Open v3 Guide de configuration rapide

TGM

TGM CTV14CN018A Manuel utilisateur

Carrier

Carrier 38MGQ Series Manuel utilisateur

Kokido

Kokido K2O K880BX/EU Guide de dépannage

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Guide rapide

Carrier

Carrier 48EZN Manuel utilisateur

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Mode d'emploi

Ariston

Ariston NIMBUS Manuel utilisateur

Weishaupt

Weishaupt WWP L 7 Guide de l'utilisateur

GE Zoneline AZ85H09EAC Manuel utilisateur