Samsung AW07P1HBA Manuel utilisateur

AW07P1HBA

AW07P1HEA AW09P1HAA

AW09P1HBA

AW09P1HDA

AW09P1HEA

AW12P1HAA

AW12P1HBA

AW12P1HDA

AW12P1HEA

AWT12P1HBA

AWT12P1HEA

SERVICE Manual

CONTENTSAIR CONDITIONER

1. Precautions

2. Product Specifications

3. Installation and Operating

Instructions

4. Disassembly and Reassembly

5. Refrigerating Cycle Diagram

6. Troubleshooting

7. Exploded Views and Parts List

8. Wiring Diagram

ROOM AIR CONDITIONER

DB98_04512A(3)_co 2/23/04 9:51 AM Page 3

1Samsung Electronics

1. Precautions

1. Warning: Prior to repair, disconnect the power cord

from the circuit breaker.

2. Use proper parts: Use only exact replacement parts.

(Also, we recommend replacing parts rather than

repairing them.)

3. Use the proper tools: Use the proper tools and

test equipment, and know how to use equipment

may cause problems later-intermittent contact,

for example.

4. Power Cord: Prior to repair, check the power cord

and replace it if necessary.

5. Avoid using an extension cord, and avoid tapping

into a power cord. This practice may result in mal-

function or fire.

6. After completing repairs and reassembly, check the

insulation resistance.

Procedure: Prior to applying power, measure the

resistance between the power cord and the ground

terminal. The resistance must be greater than

30 megaohms.

7. Make sure that the grounds are adequate.

8. Make sure that the installation conditions are

satisfactory.

Relocate the unit if necessary.

9. Keep children away from the unit while it is being

repaired.

10. Be sure to clean the unit and its surrounding area.

Fig. 1-1 Avoid Dangerous Contact

Fig. 1-2 No Tapping and No Extension Cords

Fig. 1-3 No Kids Nearby!

Fig. 1-4 Clean the Unit

DB98_04512A(3)_1 2/23/04 9:51 AM Page 1

Samsung Electronics2

Precautions

Type Model Name

: The symbol of model name

Notice

AW07P1HBA

AW07P1HEA AW09P1HAA

AW09P1HBA

AW09P1HDA

AW09P1HEA

AW12P1HAA

AW12P1HBA

AW12P1HDA

AW12P1HEA

AWT12P1HBA

AWT12P1HEA

DB98_04512A(3)_1 2/23/04 9:51 AM Page 2

3Samsung Electronics

2. Product Specifications

2-1 Table

Item Unit of

Measure

Type

Dimensions:

(Width x Height x Depth)

Voltage

Phase

Frequency

Operating Current

Power Consumption

Refrigerant Type

Refrigerant Charge

Capacity

EER

Net Weight

Condenser

Condenser Fan

Evaporator

Evaporator Fan

Fan Motor

Compressor(Rotary)

Overload Protect

Compressor Capacitor

Fan Motor Capacitor

Fan Speed

Thermo Control

Air Swing

Volt

FREON

BTU/h

BTU/h.W

Row

Type

Row

Type

MODEL

µF / VAC

RPM

MODEL

220V ~

44A072IUAEA

KA-122-LYGN64B

20 / 370

220 - 240V~

44A070JUAEB

KA-122-LYGN52B

25 / 370

115V~

44B092HXAEF

KA-122-LRGN00K

45 / 370

44B092IXAEF

MRA12153-12008

20 / 450

44B092MXAEF

KA-122-LPDN00B

35 / 450

44B092JXAEF

KA-122-LYCN00B

30 / 450

AW07P1HBA AW07P1HEA AW09P1HAA AW09P1HBA AW09P1HDA AW09P1HEA

WINDOW

SINGLE

60Hz

R22

Propeller Fan

Blower

THERMISTOR

500 x 355 x 458

220V~

50Hz 60Hz 60Hz 50Hz 50Hz

220 - 240V~

200 - 220V~

4.3/4.2

920/990

410

8400/8500

9.1/8.5

29.5

2 X16

2 X14

YGN53-4D

3.0/450

920/880/840

(900/860/820)

50SM16

2. Product Specifications

2-2 Table

Item Unit of

Measure

Type

Dimensions:

(Width x Height x Depth)

Voltage

Phase

Frequency

Operating Current

Power Consumption

Refrigerant Type

Refrigerant Charge

Capacity

EER

Net Weight

Condenser

Condenser Fan

Evaporator

Evaporator Fan

Fan Motor

Compressor(Rotary)

Overload Protect

Compressor Capacitor

Fan Motor Capacitor

Fan Speed

Thermo Control

Air Swing

Volt

FREON

BTU/h

BTU/h.W

Row

Type

Row

Type

MODEL

µF / VAC

RPM

MODEL

115V ~

44B117HXAEF

MRA13424-12007

50 / 370

220V~

44B117IXAEF

MRA12070-12007

25 / 370

200 - 220V~

48D124MUAEL

MRA12081-12008

40/ 450

48D124JUAEL

MRA12123-12007

30 / 450

48D135ITAEL

MRA12107-12007

35 / 450

48D124JTAEL

MRA12050-12007

30 / 450

AW12P1HAA AW12P1HBA AW12P1HDA AW12P1HEA AWT12P1HBA AWT12P1HEA

WINDOW

SINGLE

60Hz

R22

Propeller Fan

Blower

THERMISTOR

560 x 397 x 550

220 - 240V~

60Hz 50Hz 50Hz 60Hz 50Hz

220 - 240V~

220V~

Samsung Electronics

5.8/5.5

1260/1290

550

11500/11800

9.2/9.1

40.5

2 X 17

2 X 14

YGN56-6A

3.5/450

900/860/800

50SM16

5Samsung Electronics

2-2 Dimensions

(Unit : mm)

2-2-1 Main Unit

Type W H D

A500 355 458

B560 397550

Front view Side view

Samsung Electronics6

3. Installation and Operating Instructions

3-1 Installation

1. Make sure that you install the unit in an area providing

good ventilation. The air conditioner must not be blocked

by any obstacle affecting the air flow near the air inlet and

air outlet.

2. Make sure that you install the unit in an area that allow

good air handling. The installation area must be able to

endure vibration from the unit.

3. Make sure that you install the unit away from heat or

vapor.

4. Make sure that you install the unit in an area which is cool

and has adequate space.

5. Make sure that you install the unit in an area away from

TVs, audio units, cordless phones, fluorescent lighting

fixtures and other electrical appliances (obtain a clearance

of at least one meter).

6. Make sure that you install the unit in an area which

provides easy drainage for condensed water.

7. Make sure that you install the unit in an area not exposed

to rain or direct sunlight.

(Install a separate sunblind if exposed to direct

sunlight.)

8. Make sure that you install the unit in an area allowing good

air movement. Do not install it in a space that would cause

noise amplification of noise.

9. Fix the unit firmly if mounted in a high place.

3-1-1 Selecting Area for Installation

• Do not use the air conditioner in the following environments : greasy areas (including areas near machines),

or marine areas. Contact your local dealer for advice.

DB98_04512A(3)_1 2/23/04 9:51 AM Page 6

7Samsung Electronics

3-2 Controls and Components

3-2-1 Thermostat

 OFF

When the room temperature is lowered by the air condition-

er, the gas within the thermostat will contract and cause a

break in the electric contact. The compressor will then stop.

After the compressor stops, the room temperature will rise

 ON

As the room temperature increases to a selected level,

the gas within the thermostat expands, causing electric

contact, which provides the source of electric power to the

compressor. The room temperature will fall and the cycle will

repeat.

3-2-1 Thermostat

 Control Operation

By turning the control knob clockwise(toward higher

numbers), the temperatures will be cooler.

By turning the control knob counterclockwise (toward lower

numbers), the temperature will be warmer.

Level 01 : Cool air will be supplied above 30~35˚

Level 10 : Cool air will be ceased below 28~32.5˚

Level 10 : Cool air will be supplied above 17.4~20.4˚

Level 10 : Cool air will be ceased below 14.4~17.4˚

Operating mode

selection dial

Temperature

control dial

Air flow blade swing switch

Samsung Electronics8 Samsung Electronics

Installation and Operating Instructions

3-2-2 Operation

The fan selector switch offers high and low fan cooling control levels to assure maximum comfort.

The two fan speeds allow you to economically circulate room air flow on days when intense cooling is not required When

combined with the thermostat(set to call for conditioned air), these controls cool, dehumidify, filter, and circulate room air,

with the fan continuing to circulate air even when the compressor is turned off.

3-2-3 Air swing switch

• On : Automatic oscillation distributes the air flow throughout the room. (controls left the right and left blade-V.)

• Off : Maintains a fixed direction of air flow, Set the Air switch to OFF at the instant the wave fins come to the desired

position.

3-2-4 Fan speed switch

The fan speed switch offers high and low fan cooling control levels to assure maximum comfort.

The two fan speeds allow you to economically circulate room air flow on days when intense cooling is not required.

When combined with the thermostat(set to activate the air conditioner)hese controls cool, dehumidify, filter, and circulate room air,

with the fan continuing to circulate air while the compressor is turned off.

3-2-5 Ventilation switch

Use the ventilation switch to exhaust stale air.

• Open position : The air inside the room circulates while the outdoor air is introduced inside.

• Closed position : The air inside the room circulates while the outdoor air is not introduced inside.

9Samsung Electronics

4. Disassembly and Reassembly

4-1 Compressor Replacement Flow Chart

Corrective action Check refrigerant oil level

Add oil as necessary

Low oil level? No

Yes

Leakage?

Locate cause of defect

Release refrigerant

Disconnect electrical wiring

from compressor

Cut refrigerant lines

from compressor

Plug disconnected lines

Replace compressor

Inspect electrical

wiring for defects, and

terminals for correct

and secure connections

Solder discharge line Solder suction line Use nitrogen gas

Problem?

Perform soldering function

Fill system with nitrogen gas

Check for leakage

Pinch and braze filling tube

Recharge system

Evacuate system

Release nitrogen gas?

DB98_04512A(3)_1 2/23/04 9:51 AM Page 9

Autres manuels pour AW07P1HBA

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Samsung Climatiseur

Samsung

Samsung AM JXVHGH EU Series Manuel d'instructions

Samsung

Samsung AMxxxNN1PEH Series Manuel utilisateur

Samsung

Samsung AQT24A1QE/B Manuel utilisateur

Samsung

Samsung MRK-A10N Mode d’emploi

Samsung

Samsung AW06FBNAA Manuel utilisateur

Samsung

Samsung AC777MNADCH Manuel utilisateur

Samsung

Samsung AC026KNADEH Manuel utilisateur

Samsung

Samsung SH07APGD Manuel utilisateur

Samsung

Samsung F-AR12FSSSCWK1 Manuel utilisateur

Samsung

Samsung AQT18P0GED/AND Manuel utilisateur

Samsung

Samsung RC060RTRGA Mode d’emploi

Samsung

Samsung AM128FNMDEH Manuel utilisateur

Samsung

Samsung AW0503B Manuel utilisateur

Samsung

Samsung AC071JN4CEH Manuel utilisateur

Samsung

Samsung EH035CAV Manuel utilisateur

Samsung

Samsung AC***JXADCH Series Manuel utilisateur

Samsung

Samsung AW07PHHBA/BB Manuel utilisateur

Samsung

Samsung AF55JV1MAEE Manuel utilisateur

Samsung

Samsung AW07F2NBA Manuel utilisateur

Samsung

Samsung AQV18FA Manuel utilisateur

Samsung

Samsung AC024BXUPCH Manuel utilisateur

Samsung

Samsung AC NN4DEH Series Manuel utilisateur

Samsung

Samsung AC MNMSEH Series Manuel utilisateur

Samsung

Samsung ADC4400TB Manuel utilisateur

Manuels Climatiseur populaires d'autres marques

Spheros

Spheros CC 355 Manuel utilisateur

Bosch

Bosch Climate 5000 SCI 24 CAS/ OU- OUE Manuel utilisateur

Panasonic

Panasonic CS-E12HKEW Manuel utilisateur

nedis

nedis ACMB1WT7 Manuel utilisateur

Daikin

Daikin FCFV50A Manuel utilisateur

Fujitsu

Fujitsu Inverter ASBA30JFC Manuel utilisateur

Toshiba

Toshiba RAS-M10SMUV-E Manuel utilisateur

Daikin

Daikin FXLQ20MAVE Manuel utilisateur

Hitachi

Hitachi RAS-E24CAK Manuel utilisateur

CIAT

CIAT Magister 2 Series Mode d’emploi

Bestron

Bestron AAC6000 Manuel utilisateur

Hisense

Hisense 7K Manuel technique

Frigidaire

Frigidaire FFRE0533S1E0 Manuel utilisateur

Frigidaire

Frigidaire CRA073PU11 Manuel du propriétaire

Soleus Air

Soleus Air GB-PAC-08E4 Manuel utilisateur

McQuay

McQuay MCK020A Manuel utilisateur

Webasto

Webasto Frigo Top 25 DS Manuel utilisateur

Frigidaire

Frigidaire FAZ12ES2A Manuel utilisateur