Salda EKA Manuel utilisateur



EKA_P0093_AZ_0002

ELECTRIC DUCT HEATERS

EKA&9$0

EKA NI&9$03(

EKA NIS&9$039

EKA NV&9$03,

EKA NV PH&9$04,$

EKA NV PTC/PS&9$04,

USER MANUAL

EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt

Safety instructions and precautions 3

WARNING! SAFETY REQUIREMENTS 3

TRANSPORTING AND STORING 3

RECEIVING AND HANDLING 3

SERVICE 3

QUALITY 3

INGRESS PROTECTION (IP) RATING 3

CIRCULAR DUCT HEATER TYPES 4

SPECIFICATION 4

INSTALATION 4

Electrical connection 5

WIRING DIAGRAMS 6

HEATERS DESCRIPTION & STRUCTURE 11

Double overheat protection 11

Duct connection 11

CONTROL 11

External control of three-phase heaters 11

External control of one-phase & two-phase heaters 11

Heaters with built-in control 11

Air velocity 11

CIRCULAR DUCT HEATER TYPES 11

Appendix A. CIRCULAR DUCT HEATERS POWER &

DIMENSIONS 12

TROUBLESHOOTING 13

NOTES 15

WARRANTY 16

WARRANTY CLAIM FORM 16

EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt



The electrical heater’s model and serial number is located on the label of the product.

Parts of the heater become very hot when operating and immediately after operating.

Severe burns may occur if the heater is not allowed to cool down properly before servicing.



Do not perform any service with heater plugged in. Serious injury or death may occur if personnel come in contact with high voltage

lead.









year.

Inspect heater for any possible shipping damage. Inspect heater element wire for any deformation that could cause a short circuit or











IP44/IP55.

IP30.



read and understood its contents before using the heater.

EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt

To ensure long service time and quality heating we use heating elements from stainless steel.



Heater voltage 

Heater power        

Number of heating elements        

Heater voltage  

Heater power       

Number of heating elements     6x1.5  





EKA NV 400 15.00 3f PTC PS

Heater with installed pressure sensor





Number of phases.

Power of heater kW

Heater diameter

Heater type.







Circular duct heater



 through heater must be not less 1,5 m/s. Heaters can not be in

stalled in explosive and aggressive substances atmosphere. Heaters can be used only for clean air heating. Heaters intended for inside installation.

Heaters installation position:

Installation example EKA NV

EKA NIS

EKA NV

3xD



Duct sensor

Room

EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt

EKA NIS

EKA NI

3xD

EKA NIS

LED1

LED2

EKA NV...PTC/PS

TK-K10K

AHU*

3xD

RESET P1

Installation example EKA NI

Installation example EKA NV PTC/PS, EKA NV PH

Installation example EKA NIS

Temperature





Duct sensor

Room



Room



heater.

*AHU





3xD – we recommend install duct temperature sensor in minimum distance multiplied by the heater’s diameter. For example: heater



INDICATION of LED lamps on EKA NV PTC/PS casing

1. LED1



2. LED2



2. Power supply source must conform with data on heater label.

3. Power supply cable must be selected corresponding to heater electrical data.



EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt

technical data table.

5. Heater must be grounded.

6. For heaters install duct temperature sensor and connect as in wiring diagram.

EKA 1X230V



B – protection from over



C – protection from over







S – Automatic circuit







B – protection from over



C – protection from over







S – Automatic circuit







B – protection from over



C – protection from over







S – Automatic circuit





EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor

EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor

TR5K – external potentiom

eter





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor

TR5K – external potentiom

eter





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor

TR5K – external potentiom

eter



EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat







B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat







B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





EKA (NI, NIS, NV, NV PH, NV PTC/PS)

www.salda.lt





B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor











B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor











B – protection from over



C – protection from over







S – Automatic circuit



T – thermostat





sensor







Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Salda Chauffage

Salda

Salda SAV 2000 Manuel utilisateur

Salda

Salda EKS Manuel utilisateur

Salda

Salda VEKA 350 EC Mode d’emploi

Salda

Salda SAV Mode d’emploi

Salda

Salda AVS 125 Mode d’emploi

Salda

Salda Comfort Box Manuel utilisateur

Salda

Salda SMARTY XV Mode d’emploi

Salda

Salda EKA 1 Manuel utilisateur

Salda

Salda SAV Series Manuel utilisateur

Manuels Chauffage populaires d'autres marques

oventrop

oventrop Regucor Series Manuel utilisateur

Blaze King

Blaze King CLARITY CL2118.IPI.1 Manuel utilisateur

ELMEKO

ELMEKO ML 150 Manuel utilisateur

BN Thermic

BN Thermic 830T Manuel utilisateur

KING

KING K Series Mode d’emploi

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Guide de démarrage rapide

Well Straler

Well Straler RC-16B Manuel utilisateur

EUROM

EUROM 333299 Manuel utilisateur

Heylo

Heylo K 170 Manuel utilisateur

Eterna

Eterna TR70W Manuel utilisateur

Clarke

Clarke GRH15 Mode d’emploi

IRSAP

IRSAP The Radiator Company Ovali Manuel utilisateur

Empire Heating Systems

Empire Heating Systems WCC65 Manuel utilisateur

Wetekom

Wetekom 92 86 43 Manuel utilisateur

Desa

Desa SPC170-F Manuel utilisateur

Watlow

Watlow Watrod Electric Tubular Heaters Manuel utilisateur

Haverland

Haverland ECO-DRY GPS Series Manuel de la liste des pièces

Stelpro

Stelpro ASILVC2060 Series Manuel utilisateur