Robern CC2440D4ND34TU Manuel utilisateur
1Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
Safety - 2
Tools needed - 3
Parts - 3
Accessories - 4
Dimensions - 5
Recess Mounting - 6
Final Assembly - 7
Use and Maintenance - 9
Warranty - 10
CONTENTS
This instruction manual contains information on how to recess mount the Craft Series cabinet. This series comes in dierent sizes and
door styles. Refer to the specic model numbers for dimensions.
Read the specic instruction for how your cabinet(s) will be mounted. The cabinets can be surface mounted* or recess mounted.
Save these instructions for future use and reference. An improper installation voids the warranty. Installed cabinets cannot be returned.
If you experience any problems with your cabinet, contact your dealer or Robern directly.
Limited Warranty — One Year Term
* For surface mounting and other installation instructions, see page 4.
GENERAL INFORMATION
CRAFT SERIES CABINET
INSTALLATION INSTRUCTIONS
Important safety instructions - Save these instructions
TM
Scan the QR code
to see the entire
Craft series of
cabinets.
Use the camera app on your
mobile device to look at this and
other QR codes. This will allow
you to quickly access web pages
and other relevant documents.
2Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
SAFETY
IMPORTANT SAFETY INSTRUCTIONS
DANGER: Read all instructions before using this cabinet.
CAUTION: Maximum shelf load 34lbs/15.4kg
When using an electrical furnishing, basic precautions should always be followed, including the following:
WARNING: To reduce the risk of burns, re, electric shock, or injury to persons:
• Use this furnishing only for its intended use as described in these instructions.
• Do not use attachments not recommended by the manufacturer.
• Never drop or insert any object into any opening.
• Do not use outdoors.
WARNING: Risk of electric shock. Connect this furnishing to a properly grounded circuit only. See Grounding instructions.
GROUNDING INSTRUCTIONS
Electrical option cabinet must be connected to a grounded metal, permanent wiring system, or an equipment-grounding conductor must
be run with the circuit conductors and connected to the equipment-grounding terminal or lead on the product.
WARNING: Electrical option cabinet must be wired to a Class A 20 Amp GFCI (Ground Fault Circuit Interrupter) protected circuit when
used in bathrooms and all other locations required by the National Electric Code.
SAVE THESE INSTRUCTIONS
3Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
TOOLS NEEDED
PARTS
(3-4) Glass Shelves
[211-1329]
(2) Robern Logo Coverplates
[216-1201] Hardware Bag
[216-1208] Hardware Bag
(1) Craft Series Cabinet
Depending on installation, not all parts will be used.
[211-1376]
(3) Shelf Clips
[211-1377]
(3) Shelf Clips
[SS134]
(10) Hole Plugs
[SS672]
(6) Screw Caps
[SS674]
(6) #10 x 2" Screws
Depending on installation, not all parts will be used.
[211-1376]
(4) Shelf Clips
[211-1377]
(4) Shelf Clips
[SS134]
(10) Hole Plugs
[SS672]
(6) Screw Caps
[SS674]
(6) #10 x 2" Screws
4Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
Scan the available QR codes to learn more about these accessories at Robern.com
ACCESSORIES
[P2SMKITXXD4P]
Surface Mount Kit
XX (Heights available): 30, 40
[P2ELECTRIC*]
Portray Electric Upgrade
TM
For Electric
Upgrade
Instructions:
TM
For Digital
Lock Box
Instructions:
*Craft series cabinet models ending in "TU" include the Portray Electric Upgrade.
[DLB-XX]
IQ Digital Lock Box
XX (Widths available): 20, 24
5Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
DIMENSIONS
Rough Opening (RO) for recessed installation in chart below.
Number in the column headings below reference the cabinet dimensions from the model number, width and height (WWHH).
3-3/4"
(95 mm)
B
A
Determine overall cabinet dimensions. If recessing cabinet, see chart to determine rough-in dimensions.
1” (25.4 mm)
Minimum RO to
finished ceiling
1” (25.4 mm)
Minimum door
to faucet
Rough Opening:
(A)
Rough Opening:
(B)
Industrial / Thin Frame Round Corner
2030 2440 2034 2444
A19-1/4"
(489 mm)
23-1/4"
(591 mm)
19-1/4"
(489 mm)
23-1/4"
(591 mm)
B30"
(762 mm)
39-3/8"
(1000 mm)
34-1/4"
(870 mm)
43-5/8"
(1108 mm)
RO (A) 18-1/2"
(470 mm)
22-1/2"
(572 mm)
18-1/2"
(470 mm)
22-1/2"
(572 mm)
RO (B) 29-1/4"
(743 mm)
38-5/8"
(982 mm)
29-1/4"
(743 mm)
38-5/8"
(982 mm)
6Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
These instructions are for recess mounting your cabinet. For a surface mount installation, refer to the instructions included with the
surface mount kit (sold separately, see page 4). Before beginning installation, remove and set the door aside in a safe place.
1. Remove door from cabinet by taking the hinges o of the mounting plates.
2. Place the cabinet box into the rough opening with the hinges on the desired side. Check for square, plumb, and level.
Electrical Option Cabinets: Provide separate electrical connections for electrical options. Pull electric wire through the cabinet hole.
Be sure to provide enough wire to make proper and safe connections to Portray Electric Upgrade.
WARNING: An Electrical option cabinet must be wired to a Class A 20 Amp GFCI (Ground Fault Circuit Interrupter) protected circuit
when used in bathrooms and all other locations required by the National Electric Code.
3. Install a #10 X 2” screw [SS674] through top mounting hole in cabinet side and screw into wall stud.
4. Once cabinet is installed square, plumb, and level, install #10 X 2” screws into wall studs through the three remaining mounting
holes.
NOTE: Do not over-tighten screws or cabinet box may deform.
RECESS MOUNTING
13
2 4
[SS674]
#10 x 2" Screw
7Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
FINAL ASSEMBLY
21
3A
3C3B
Hinge Extended Hinge Partially
Extended
NOTE: The door hinges have a three-way adjustment feature. These adjustments can be made using a #2 Phillips-head screwdriver.
3A. Side adjustment – Rotate front screw to increase or decrease door overlay.
3B. Height adjustment – Rotate cam screw on mounting plate to adjust door.
3C. Depth adjustment – Rotate rear spiral tech cam screw to adjust door gap.
1. Align the door and reattach hinges to mounting plates until audible click is heard. Ensure all hinges are fully seated before
attempting to adjust door.
2. If desired, the slow close feature can be deactivated on one of the hinges. Swing the door closed once for the deactivation to be
complete. To reactivate, move switch back to original position.
8Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
FINAL ASSEMBLY
4. Press the shelf hole plugs [SS134] into the unused holes inside the cabinet. Place the screw head caps [SS672] over any exposed
screw heads.
5. Install a Robern logo coverplate [211-1329] into each unused electrical access hole.
6. Insert clear shelf clips [211-1376 and 211-1377] into the holes in the back channel on the sides of the cabinet.
7. Push the back of the shelf into both the left and right clips (A). Snap the shelf down into the clips (B).
6
4 5
7
A
B
9Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
USE AND MAINTENANCE
No Ammonia
Sans Ammoniac
Sin Amoniaco
No Vinegar
Sans Vinaigre
Sin Vinagre
No Ammonia
No Vinegar
CAUTION: Maximum shelf load 34 LBS
The cabinet door and interior are constructed of mirrored glass and aluminum. Use only a damp cloth to clean. Ammonia or vinegar-
based cleaners can damage mirrors.
A 50/50 solution of water and isopropyl alcohol is recommended for cleaning the mirrors. A mild detergent may be used on the surfaces.
When cleaning, spray the cloth, not the cabinet, mirror, or surround surfaces. Do not use abrasive cleansers on any part of the product.
NOTE: Do not store items in the cabinet area directly behind the hinge as damage may occur to cabinet or items.
10 Part no. CB-209-1439 07/13/2022
Craft Series Cabinet
© 2022 Robern, Inc. 701 N. Wilson Ave. Bristol, PA 19007 U.S.A.
800.877.2376 www.robern.com
Limited Warranty One Year Term
ROBERN warrants to the original purchaser that, it will, at its election repair, replace, or make appropriate adjustment to products
made by this company shown to have signicant defects in material or workmanship which are reported to ROBERN in writing
within one (1) year from the date of delivery. ROBERN is not responsible for installation costs. The warranty is void in the event the
product is damaged in transit, or if damage or failure is caused by abuse, misuse, abnormal usage, faulty installation, damage in an
accident, improper maintenance, or any repairs other than those authorized by ROBERN. At the expiration of the one year warranty
period, ROBERN shall be under no further obligation under any warranty, expressed or implied, including the implied warranty of
merchantability. ROBERN shall not be liable for any consequential damages arising out of or in connection with the use or performance
of its products. Some states do not allow limitations on how long an implied warranty lasts or do not allow the exclusion or limitation of
incidental or consequential damages, so the above limitation or exclusion may not apply to you. Any liability against ROBERN under
any implied warranty, including the warranty of merchantability, is expressly limited to the terms of this warranty. Permission to return
any merchandise under this warranty must be authorized by ROBERN and returned prepaid by the purchaser. Claims under this
warranty should be sent directly to your dealer.
© 2022 ROBERN, INC.
ALL RIGHTS RESERVED
WARRANTY
Ce manuel convient aux modèles suivants
10
Table des matières
Autres manuels Robern Mobilier d'intérieur
Robern
Robern RC 20 Manuel utilisateur
Robern
Robern UPLIFT CABINET UC3027FPE Guide de démarrage rapide
Robern
Robern CARTESIAN Series Manuel utilisateur
Robern
Robern UPLIFT TECH CABINET Manuel utilisateur
Robern
Robern 209-1375 06 Manuel utilisateur
Robern
Robern V14 Series Manuel utilisateur
Robern
Robern PC1230D4T Series Manuel utilisateur
Robern
Robern CRAFT Series Manuel utilisateur
Robern
Robern CRAFT Series Manuel utilisateur
Robern
Robern CRAFT CM0030C86 Manuel utilisateur
Robern
Robern PL Series Manuel utilisateur
Robern
Robern M Series Manuel utilisateur
Robern
Robern MURRAY HILL Series Manuel utilisateur
Robern
Robern SS476 MP Manuel utilisateur
Robern
Robern Entice M Series Manuel utilisateur
Robern
Robern PL PORTRAY Series Manuel utilisateur
Robern
Robern R3 CB-RSMK20D4P Manuel utilisateur
Robern
Robern PUSH-TO-OPEN KIT Manuel utilisateur
Robern
Robern FAIRHAVEN Manuel utilisateur
Robern
Robern balletto Manuel utilisateur
