Rheem 31202519V Document technique

This water heater must be installed and serviced by a qualified person.

Please leave this guide with the householder.

Owner’s Guide

and

Installation Instructions

Electric Domestic

Water Heater

Model 31202519V

An electronic copy of these Owner’s Guide and Installation Instructions

can be downloaded from rheem.co.nz.

PATENTS

This water heater may be protected by one or more patents or registered designs

in the name of Rheem Australia Pty Ltd or Rheem New Zealand Limited.

TRADEMARKS

® Registered trademark of Rheem Australia Pty Ltd or Rheem New Zealand Limited.

TM Trademark of Rheem Australia Pty Ltd or Rheem New Zealand Limited.

Note: Every care has been taken to ensure the accuracy in preparation of this

publication. No liability can be accepted for any consequences,

which may arise as a result of its application.

RHEEM NEW ZEALAND LIMITED

www.rheem.co.nz

For Service Telephone 0800 657 335 NEW ZEALAND

CONTENTS

HOUSEHOLDER

This booklet contains important information about your

new water heater, including terms of the Rheem warranty.

We recommend you read pages 8 to 23,

and the terms of the Rheem warranty on pages 4 to 7.

The other pages are intended for the installer but may be of interest.

Warranty .......................................................................................4

Safety, Warnings, Installation Notes .........................................8

About Your Water Heater..........................................................12

Maintenance Requirements ......................................................15

Water Supplies...........................................................................17

Save A Service Call ...................................................................21

Installation..................................................................................24

Connections –Plumbing ..........................................................32

Connections –Electrical...........................................................36

Commissioning..........................................................................38

Draining The Water Heater .......................................................39

RHEEM ELECTRIC DOMESTIC MAINS PRESSURE

WATER HEATER WARRANTY –NEW ZEALAND ONLY

ELECTRIC WATER HEATERS 312025 MODEL

In addition to your legal right, in New Zealand Rheem New Zealand Limited

makes the following promise to the owner. We will repair or, if necessary, replace

a defective unit or part of it, which has failed due to faulty manufacture on the

following terms and conditions:

1. THE RHEEM WARRANTY –GENERAL

1.1 This warranty is given in respect of sales in New Zealand by Rheem New

Zealand Limited of 475 Rosebank Road Avondale Auckland 1026.

1.2 Rheem offer a trained and qualified national service network who will repair or

replace components at the address of the unit subject to the terms of the

Rheem warranty in New Zealand –contact your Rheem Service Centre on

0800 657 335.

1.3 For details about this warranty, you can contact us at [email protected] (not

for service bookings) or phone your Rheem Service Centre on 0800 657 335.

1.4 The terms of this warranty and what is covered by it are set out in sections 2

and 3 and apply to water heaters manufactured from 1st November 2019.

1.5 If a subsequent version of thiswarranty is published, the terms of that warranty

and what is covered by it will apply to water heaters manufactured after the

date specified in the subsequent version.

2. TERMS OF THE RHEEM WARRANTY AND EXCLUSIONS TO IT

2.1 Rheem may reject a claim under this warranty in its sole discretion if:

a) You do not arrange for a major service to be conducted on your water

heater in the fifth year after installation, in accordance with Rheem’s

recommendation in the Owner’s Guide and Installation Instructions; and

b) The fault giving rise to the warranty claim would have been detected and

rectified during that major service.

2.2 The decision of whether to repair or replace a faulty component is at Rheem

New Zealand Limited’s sole discretion.

2.3 Where a failed component or cylinder is replaced under this warranty, the

balance of the original warranty period will remain effective. The replacement

does not carry a new Rheem warranty.

2.4 Where the unit is installed outside the boundaries of a metropolitan area,

defined by Rheem as further than 25 km from a Rheem Service Centre, the

cost of transport, insurance and travelling between the Rheem Service Centre

and the installed site shall be the owner’s responsibility.

RHEEM ELECTRIC DOMESTIC MAINS PRESSURE

WATER HEATER WARRANTY –NEW ZEALAND ONLY

ELECTRIC WATER HEATERS 312025 MODEL

2.5 Where the unit is installed in a position that does not allow safe or ready

access, the cost of that access, including the cost of additional materials

handling and/or safety equipment, shall be the owner’s responsibility. In other

words, the cost of dismantling or removing cupboards, doors, walls, roofs or

trap doors and the cost of any special equipment to bring the unit to floor or

ground level or to a serviceable position is not covered by this warranty.

2.6 This warranty only applies to the original and genuine Rheem unit in its original

installed location and anygenuine Rheem replacement parts. It does not cover

any plumbing, gas fitting or electrical parts supplied by the installer, that are

not an integral part of the unit, e.g. pipe-work, pressure limiting valve, stop

valves, non-return valves, electrical switches, pumps and fuses.

2.7 The Rheem warranty does not cover faults that are a result of:

a) Accidental damage to the unit or any component, for example Acts of God

such as floods, storms, fires, lightning strikes and the like and Third party

acts or omissions.

b) Misuse or abnormal use of the unit.

c) Installation or use not in accordance with the Owner’s Guide and

Installation Instructions, New Zealand Building Code requirements or with

relevant statutory and local requirements including failure to install a

properly drained safe tray where required by the owners guide and

installations.

d) Connection at any time to a water supply that does not comply with the

water supply guidelines as outlined in the Owner’s Guide and Installation

Instructions, or poor water quality outside the limits specified in the owners

guide and installation instructions.

e) Repairs, attempts to repair or modifications to the unit by a person other

than Rheem Service or a Rheem Accredited Service Technician.

f) Faulty plumbing or faulty power supply.

g) Failure to maintain the unit in accordance with the Owner's Guide and

Installation Instructions.

h) Transport damage.

i) Fair wear and tear from adverse conditions (for example, corrosion).

j) Cosmetic defects.

2.8 If you require a call out and we find that the fault is not covered by the Rheem

warranty, you are responsible for Rheem Service Centre call out costs. If you

wish to have the relevant component repaired or replaced by Rheem that

service will be at your cost.

2.9 Rheem may reject a claim under this warranty in its sole discretion if a third

party solar diverter is connected to the water heater.

RHEEM ELECTRIC DOMESTIC MAINS PRESSURE

WATER HEATER WARRANTY –NEW ZEALAND ONLY

ELECTRIC WATER HEATERS 312025 MODEL

2.10 Subject to any statutory provisions to the contrary, this warranty excludes any

and all claims however arising including under contract or tort for damage to

furniture, carpet, walls, foundations or any other consequential loss or

incidental expenses either directly or indirectly due to leakage from Rheem

unit, or due to leakage from fittings and/ or pipe work of metal, plastic or other

materials caused by water temperature, workmanship or other modes of

failure.

2.11 This warranty excludes to the extent permissible all implied warranties set out

in the Sale of Goods Act 1908 (New Zealand) and all guarantees set out in the

Consumers Guarantees Act 1993 (New Zealand) to the extent that the goods

are acquired for the purpose of resupply in trade consumption in the course of

a process of production or manufacture or repairing or treating in trade other

goods or fixtures on land.

3. WHAT IS COVERED BY THE RHEEM WARRANTY

FOR THE WATER HEATERS DETAILED IN THIS DOCUMENT

3.1 Rheem will repair or replace a faulty component of your unit if it fails to operate

in accordance with its specifications as follows:

What components

are covered

The period from the

date of installation

in which the fault

must appear in

order to be covered

What coverage

you receive

312025 model

All components

Year 1

Repair and/or replacement of

the faulty component, free of

charge, including labour.

The cylinder

(if the water heater is

installed in a single-family

domestic dwelling)

Years 2 to 5

Repair and / or replacement

of the cylinder, free of charge,

including labour.

Years 6 to 10

Replacement cylinder, free of

charge. Installation and repair

labour costs are the

responsibility of the owner.

The cylinder

(if the water heater is not

installed in a single-family

domestic dwelling)

Years 2 & 3

Replacement cylinder, free of

charge. Installation and repair

labour costs are the

responsibility of the owner.

RHEEM ELECTRIC DOMESTIC MAINS PRESSURE

WATER HEATER WARRANTY –NEW ZEALAND ONLY

ELECTRIC WATER HEATERS 312025 MODEL

4. ENTITLEMENT TO MAKE A CLAIM UNDER THIS WARRANTY

4.1 To be entitled to make a claim under this warranty you need to:

a) Be the owner of the unit or have consent of the owner to act on their behalf.

b) Contact Rheem New Zealand Limited Service Department without undue

delay after detection of the defect and, in any event, within the applicable

warranty period.

c) Return the faulty component or unit as directed by the Rheem New

Zealand Limited Service Department.

4.2 You are not entitled to make a claim under this warranty if your unit:

a) Does not have its original serial numbers or rating labels.

b) Is not installed in New Zealand.

5. HOW TO MAKE A CLAIM UNDER THIS WARRANTY

5.1 If you wish to make a claim under this warranty, you need to:

a) Contact Rheem New Zealand on 0800 657 335 and provide the owner’s

details, address of the unit, a contact number and date of installation of the

unit or if that’s unavailable, the date of manufacture and serial number

(from the rating label on the unit).

b) A Rheem Service Centre will arrange for the unit to be tested and

assessed on-site.

c) If Rheem determines that you have a valid warranty claim, Rheem will

repair or replace the unit in accordance with this warranty.

5.2 Any expenses incurred in the making of a claim under this warranty will be

borne by you.

6. THE CONSUMER GUARANTEES ACT 1993 (NEW ZEALAND)

6.1 Our goods come with guarantees that cannot be excluded under the Consumer

Guarantees Act 1993 (New Zealand). If the goods fail to comply with the

applicable guarantees set out under the Consumer Guarantees Act 1993 (New

Zealand) being the guarantee as to acceptable quality, the guarantee as to

correspondence with description or the guarantee as to repair and parts, or if

the goods fail to comply with any express guarantee given by Rheem, then you

are entitled to a replacement or refund and for compensation for any other

reasonably foreseeable loss or damage.

6.2 The Rheem warranty (set out above) is in addition to any rights and remedies

that you may have under the Consumer Guarantees Act 1993 (New Zealand).

 
8 
SAFETY, WARNINGS, INSTALLATION NOTES 
 
It is important you read the following safety and warnings information. 
 
 SAFETY AND WARNINGS 
•This water heater is only intended to be operated by persons who have the 
experience or the knowledge and the capabilities to do so. 
•This water heater is not intended to be operated by persons with reduced 
physical, sensory or mental capabilities i.e. the infirm, or by children. Children 
should be supervised to ensure they do not interfere with the water heater. 
•If the electrical conduit to the water heater is damaged, it must be replaced 
by a qualified person in order to avoid a hazard. Phone your Rheem Service 
Centre to arrange for an inspection. 
•This water heater uses 230 V a.c. power for the electrically operated 
components. The removal of the front cover will expose 230 V a.c. wiring. It 
must only be removed by a qualified person. 
•This water heater is supplied with a thermostat, an over-temperature cut-out 
and a combination temperature pressure relief valve. These devices must not 
be tampered with or removed. The water heater must not be operated unless 
each of these devices is fitted and is in working order. 
The Rheem warranty may not cover faults if relief valves or other safety 
devices are tampered with or if the installation is not in accordance with 
these instructions. 
•DANGER: The operation of the over-temperature cut-out on a thermostat 
indicates a possibly dangerous situation. If the over-temperature cut-out 
operates, it must not be reset and the water heater must be serviced by a 
qualified person. 
•The water heater will operate until a water temperature of 60°C to 70°C is 
reached, depending upon the thermostat setting. 
Refer to “How  Hot  Should  The  Water  Be?” on page 12 and “Temperature 
Adjustment” on page 13. 
•The lever on the temperature pressure relief valve and expansion control 
valve (if fitted) requires to be operated every six (6) months to clear any 
deposits and to ensure the valve and its drain line are not blocked. 
Refer to “Relief  Valves” on page 9 and “Minor  Maintenance  Every  Six 
Months” on page 16. 
•For continued safety of this water heater it must be installed, operated and 
maintained  in  accordance  with  the  Owner’s  Guide  and  Installation 
Instructions. 

SAFETY, WARNINGS, INSTALLATION NOTES

•Servicing of a water heater must only be carried out by qualified personnel.

Phone your Rheem Service Centre.

•Only a person qualified to install or service a water heater can drain the water

heater, if this is required.

•Do not modify this water heater.

RELIEF VALVES

Temperature Pressure Relief Valve

This water heater incorporates a

temperature pressure relief valve located

near the top of the water heater. This valve

is essential for the water heater’s safe

operation.

It is possible for the valve to discharge a

quantity of water through the drain line

during each heating period. This quantity

should be equal to approximately 1/50 of the

hot water used, as water expands by this

volume when heated.

Expansion Control Valve

It is mandatory an expansion control valve is fitted to the cold water line to the

water heater to comply with Clause G12 of the New Zealand Building Code,

unless the water heater is installed as a push through installation.

The expansion control valve will discharge the quantity of water from its drain

line during the heating period instead of the temperature pressure relief valve as

it has a lower pressure rating.

Valve Operation

Continuous leakage of water from either valve and its drain line may indicate a

problem with the water heater. Refer to “Temperature Pressure Relief Valve or

Expansion Control Valve Running” on page 22.

Warning: Never block the outlet of either valve or their drain lines for any

reason. A relief valve drain must be left open to atmosphere, and be installed in

a continuously downward direction.

In locations where water pipes are prone to freezing, the relief valve drain line

must be insulated and not exceed 300 mm in length before discharging into a

tundish through an air gap.

SAFETY, WARNINGS, INSTALLATION NOTES

Operate the easing lever on the temperature

pressure relief valve and expansion control

valve once every six (6) months to clear any

deposits and ensure the valve and its drain

line are not blocked. It is very important the

lever is raised and lowered gently. Refer to

“Minor Maintenance Every Six Months” on

page 16.

Warning: Water discharged from the

temperature pressure relief valve drain line

will be hot. Exercise care to avoid any

splashing of water by standing clear of the

drain line’s point of discharge when operating

either valve’s easing lever.

DANGER: Failure to operate the easing lever on the relief valve once every

six (6) months may result in the water heater cylinder failing, or under certain

circumstances, exploding.

If water does not flow freely from the drain line when the lever is lifted, then the

water heater must be checked. Phone your Rheem Service Centre to arrange

for an inspection.

The temperature pressure relief valve should be replaced at intervals not

exceeding five (5) years and the expansion control valve should be checked for

performance or replaced at intervals not exceeding five (5) years. The checking

of the valves performance or replacement should occur more frequently in areas

where there is a high incidence of water deposits. Refer to “Water Supplies” on

page 17.

INSTALLATION NOTES

This water heater must be installed:

•by a qualified person,

•in accordance with the installation instructions,

•to conform to Clauses G12 and H1 of the New Zealand Building Code,

•in compliance with the Plumbing Standard AS/NZS 3500.4,

▪This water heater is suitable for either indoor or outdoor installation.

▪This water heater is intended to be permanently connected to the water

mains and not connected by a hose-set. A braided flexible hose or semi-

flexible connector may be used for connection to the water heater, where

permitted by AS/NZS 3500.4.

lift until water

flows from the

drain line –

lower gently

drain

line

Table des matières

Autres manuels Rheem Chauffe-eau

Rheem

Rheem Ecosense ECO-180DV Manuel utilisateur

Rheem

Rheem Lazer Classic Series Mode d’emploi

Rheem

Rheem Fury 40 Manuel utilisateur

Rheem

Rheem 199,000 Btu/hr Manuel utilisateur

Rheem

Rheem EV-30 Manuel utilisateur

Rheem

Rheem Induced Draft Manuel utilisateur

Rheem

Rheem GHE119-500 Manuel utilisateur

Rheem

Rheem RT1000C6 Document technique

Rheem

Rheem 40 Gallon Manuel utilisateur

Rheem

Rheem RUUD High-Power Commercial Water Heater Manuel utilisateur

Rheem

Rheem Stellar Document technique

Rheem

Rheem RTGH-95DVELN-3 Manuel utilisateur

Rheem

Rheem Residential Electric Models Manuel utilisateur

Rheem

Rheem 862 27 Series Mode d'emploi

Rheem

Rheem RTG2-42PV Manuel utilisateur

Rheem

Rheem 871018 Mode d'emploi

Rheem

Rheem Marathon MR105/473185 Manuel utilisateur

Rheem

Rheem PRO415TM Manuel utilisateur

Rheem

Rheem 81VR120-1 Manuel utilisateur

Rheem

Rheem 311 Series Document technique

Rheem

Rheem HPHD-135HNU-483 Document technique

Rheem

Rheem 874 Series Document technique

Rheem

Rheem RTG-3 Series Manuel utilisateur

Rheem

Rheem Direct Vent Gas Tankless Water Heater Manuel utilisateur

Manuels Chauffe-eau populaires d'autres marques

Kenmore

Kenmore 153.582400 Manuel utilisateur

Applimo

Applimo Edel AIR Manuel utilisateur

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manuel utilisateur

clage

clage E-Mini Series Manuel utilisateur

Toyotomi

Toyotomi Oil Miser OM-180 Manuel utilisateur

Bradford White

Bradford White EF Series Manuel utilisateur

Eccotemp

Eccotemp 40-H Manuel utilisateur

Dimplex

Dimplex ECSd125-580 Mode d’emploi

Dux

Dux 32FCR6N Manuel utilisateur

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guide de dépannage

Noritz

Noritz N-132M Manuel d'instructions

TESY

TESY GCV7/4S 10047 Fiche technique

A.O. Smith

A.O. Smith Gphe 50 Manuel utilisateur

Koryo

Koryo KWHZF15Y Manuel utilisateur

Pentair

Pentair PSC-14-4-02 Manuel utilisateur

GE 40M06AAG Instructions de montage

Thermor

Thermor AEROMAX SPLIT 2 Manuel utilisateur

American Hometec

American Hometec AHQ-B03X Manuel utilisateur