Raypak P Manuel utilisateur

CATALOG NO.: 6200.40D

Effective: 5-15-00

Replaces: 10-15-99

Raypak, Inc., 31111 Agoura Road, Westlake Village, CA 91361-4699 • (818)889-1500 • Fax (818) 889-4522 • www.raypak.com

Litho in U.S.A.

COMMERCIAL SWIMMING POOL HEATERS

MODEL P – SIZES 514-1223

SUGGESTED SPECIFICATIONS

1. The heater shall be Raypak Model with BTU input, output. The heater shall be

design certified, ASME inspected and stamped for 160 PSI working pressure, complete with manufacturer’s

data report. The heater shall be equipped with 125 PSI, ASME pressure relief valve. The water tube heat

exchanger shall be of single level horizontal grid design constructed with nine tubes, 1”x.065” wall integral

cupro nickel fin tubes with fins spaced at seven per inch, and extra heavy galvanized steel gull baffles

secured tightly to the tubes above the point of tangency of the fins. Each end of the tubes shall be rolled into

an ASME fire box steel tube sheet and sealed to bronze headers with silicone “O” rings with a temperature

rating over 500°F. The headers shall be precision machined for easy removal and the “O” rings seals shall

positively prevent boiler water from reaching the steel tube sheets. They shall be of high pressure bronze with

integral bronze baffling to direct water through the heat exchanger in two passes.

2. The heat exchanger shall be capable of withstanding a 1000 PSI hydrostatic pressure. The heaters shall be

secured to the tube sheets by properly spaced stud bolts and flange nuts. The heat exchanger shall be readily

cleanable from either the right side or the left side of the heater, and cleanable on the right side without

removing external piping.

3. The heat exchanger shall be explosion proof on the waterside. It shall have 100% copper and bronze

waterways to positively protect the heater from galvanic action (electrolysis).

4. The heater shall be equipped with a 24V main electric gas valve, a factory calibrated pressure switch, a pool

thermostat, and a high limit switch. Electronic Intermittent Pilot Ignition is standard.

5. The heater shall be equipped with stainless or aluminized steel burners mounted in an easily removable

burner drawer. The burners shall be capable of quiet ignition and extinction, and equipped with fixed primary

air ports for atmospheric gas firing and capable of complete combustion.

6. The heater shall be equipped with a Unitherm Governor Bypass Valve to automatically control the internal

water temperature between 105° and 115°F.

7. The heater shall be rated at least 82% thermal efficiency by a recognized independent gas appliance test laboratory,

independent of the manufacturer.

Table des matières

Autres manuels Raypak Chauffe-piscine

Raypak

Raypak 207 Manuel utilisateur

Raypak

Raypak ECONOPAK 203A Manuel utilisateur

Raypak

Raypak X94 Manuel

Raypak

Raypak XTherm Series Manuel

Raypak

Raypak 130A Manuel

Raypak

Raypak MVB 1104 Guide de configuration

Raypak

Raypak Raytherm P-1826 Manuel

Raypak

Raypak 155A VERSA Manuel utilisateur

Raypak

Raypak VERSA 155C Manuel utilisateur

Raypak

Raypak 259B Manuel

Raypak

Raypak RP-045 Manuel utilisateur

Raypak

Raypak CROSSWIND Series Manuel utilisateur

Raypak

Raypak 185A Mode d’emploi

Raypak

Raypak P-R185B To P-R405B, C-R185B To Manuel utilisateur

Raypak

Raypak 053A Manuel utilisateur

Raypak

Raypak HI-DELTA 302 Manuel d'utilisation et d'entretien

Raypak

Raypak D-2 Power Vent Manuel utilisateur

Raypak

Raypak 334 Manuel utilisateur

Raypak

Raypak RP2100 ASME R185B Manuel utilisateur

Raypak

Raypak 183A Manuel utilisateur

Raypak

Raypak HI DELTA 1802B Manuel utilisateur

Raypak

Raypak SpaPak 552 & 1102 Manuel d'instructions

Raypak

Raypak Xtherm 1505 Manuel utilisateur

Raypak

Raypak RP-045 Manuel utilisateur

Manuels Chauffe-piscine populaires d'autres marques

Nibe

Nibe S Series Guide de l'utilisateur

Zodiac

Zodiac JXi 200 Manuel utilisateur

Texsun

Texsun El Niño Manuel utilisateur

Aqua Comfort

Aqua Comfort AC110 Manuel utilisateur

HeatPRO

HeatPRO pool heat pump Manuel utilisateur

Dickinson

Dickinson NEWPORT Manuel utilisateur

Pentair Pool Products

Pentair Pool Products MiniMax CH 150 Manuel utilisateur

Jandy

Jandy LJ Manuel utilisateur

Pentair Pool Products

Pentair Pool Products MiniMax NT Series Manuel utilisateur

Hayward Pool Products

Hayward Pool Products HP40A Manuel de service

Laars

Laars Lite 2 LC Manuel utilisateur

SUPREME

SUPREME Heatseeker Solar Pool Heating Manuel utilisateur

UTC

UTC ICP HMP-03 Instructions de montage

Pentair

Pentair ETi 400 Manuel utilisateur

Hayward

Hayward ENP2M-9A Manuel de service

BriskHeat

BriskHeat TOT Series Manuel utilisateur

Hayward

Hayward C-SPA-XI 5.5 Manuel utilisateur

Aquacal

Aquacal AEROTEMP Manuel utilisateur