Puretec PRO270 Manuel utilisateur

User Guide

Portable Reverse Osmosis Water Treatment System

PRO270

For correct operation & installation it is essential to observe these instructions.MAY2019

What's Inside

Introduction................................................................................................................................. 2

Operation...................................................................................................................................... 2

Cartridge Replacement ......................................................................................................... 2

Installation................................................................................................................................... 3

Installation Requirements................................................................................................... 3

Installation Procedure ........................................................................................................... 3

Cartridge Changeout.............................................................................................................. 5

Use Guidelines........................................................................................................................... 5

Substance Reduction.............................................................................................................. 6

Warranty .............................................................................................................................................7

Puretec Customer Service

Thank you for purchasing a Puretec PRO270 Water Treatment System. Your system is a

proven performer manufactured from only quality materials and components and will give

years of ‘spring fresh’ water, if maintained properly.

The Puretec PRO270 Water Treatment System cartridges needs replacing regularly to

maintain optimum performance. This is a simple procedure when following instructions. For

cartridge replacements contact your nearest Puretec stockist.

Customer Service Helpline 1300 140 140 (Australia) 0800 130 140 (New Zealand).

Operation

The Puretec PRO270 Water Treatment System is designed to run economically for many

years and this is dependent on the initial installation and periodical maintenance.

Flush systems for 10 minutes aer any period of non-use more than 2 days.

The Puretec PRO270 Water Treatment System is designed to operate with mains water.

Cartridge Replacement

To maintain the high quality of the puried water the cartridges need changing every 6

months, dependent on water quality and usage.

You can obtain replacement cartridges from your local Puretec dealer. To maintain

performance standards and warranty, use only genuine Puretec replacements.

What's Inside

Portable Reverse Osmosis Water Treatment Systems

Order the PX051 (sediment cartridge) & CB951 (carbon cartridge) for a replacement

cartridges and RET1812-75 replacement membrane to suit your PRO270 system.

Installation

This system comes complete with an installation kit enabling it to be connected to 15 mm

(½”) male thread to an existing tap or mixer tap (cold supply only - hot water should be

ltered prior to heating). Also includes extending kit, where extra length is required.

Installation Requirements

1. Water supply pressure: 300 - 875 kPa.

2. Water supply temperature: 0° - 30°C (protect from freezing).

Alternative ttings may be required if being connected to anything other than a standard

15 mm tap.

Installation Procedure

Important Note: Do not cut the BLACK tube when installing this system.

1. The unit comes with a tap adapter on the inlet side, identied by a GREEN tube, which

will screw onto a standard tap without the need of thread seal tape. Make sure it is rmly

screwed to provide a seal on the rubber gasket (hand tighten only).

2. To gain access to the mounting screw holes on the mounting bracket, simply unclip the

R.O. housing from the clip attached to the main mounting bracket. This will reveal the wall

mounting screw holes to enable the mounting of the system to the wall, cupboard etc.

3. Puried water (BLUE tube) and waster water (BLACK tube) lines do not come with any

attachments. Pure water should be directed to a suitable container without any back pressure

or valving occurring in the line. The drain line, or waste water may be directed to the outside

garden, or if installed inside, to a washing machine, to conserve water. If inconvenient it may

be directed to any drainage system.

4. When the unit is in place and the water lines are installed, the unit should be run for 4 hours

before the puried water is used, on initial start up. The unit cannot be stored for more than

2 weeks without use, or damaged to the membrane may occur. Please enquire if this is the

case.

For a period of non-use greater than 2 days, ush for 10 minuntes before use. For non-use

greater than 2 weeks, the cartridges may need replacing.

5. The sediment and chemical removal lters should be replaced every 6 months. The

membrane should be replaced when water quality deteriorates or every 18 - 24 months,

Installation Guide

depending on incomming water quality. A Puretec TDS meter (PTE10) can determine quality

for you at the push of a button.

For best performance use only genuine Puretec replacement cartridges and cartridges that

are suitable for this appliance.

Figure 1

No. DESCRIPTION

1 Tap Adaptor

2, 2A Tube Adaptor

3Inlet Water - Green Flexible Tubing

4Waste Water Outlet - Black Flexible Tubing

5Pure Water Outlet - Blue Flexible Tubing

6 Membrane Housing

7Mounting Bracket

8Chemical Filter Housing

9 Sediment Filter Housing

SEDIMENT REMOVAL CHEMICAL REMOVAL

END VIEW OF

MEMBRANE HOUSING

Portable Reverse Osmosis Water Treatment Systems

Cartridge Changeout

To change the ﬁlter cartridges adhere to the following procedure.

1. Close tap to prevent water ow.

2. Unscrew lter housing using the spanner wrench and discard cartridges. When removing

housings place a container underneath to catch any spillage. Membrane housing cap can be

unscrewed by hand.

3. Cleanse the inside of the housing using Puretec S500 Sanitiser. Check O-ring and lubricate

with food grade silicone lubricant or similar. Replace O-ring if kinked or damaged.

4. Install new cartridges and replace housing screwing them up HAND TIGHT ONLY. PX051 lter

is on the inlet side and CB951 on the outlet side.

5. Restore water supply & check for leaks, rectifying any before leaving the unit.

Aer installing cartridges ush unit for 5 - 10 minutes.

Use Guidelines

• Use for mains, rain, harsh and rural water supply.

• Minimum operating pressure 300 kPa.

• Maximum operating pressure 875 kPa.

• Do not allow exposure to temperatures below 0b°C (protect from freezing).

• Maximum operating temperature 30 °C.

• Nominal ow rate 11 Lpm.

• This system must be installed according to local plumbing codes on the cold water line

only.

• Replacement Cartridge: PX051 & CB951

• Replacement Membrane: RET1812-75

• This system requires regular replacement of the lter cartridges to maintain proper

operation. Varying chlorine, sediment, or organic substance levels may aect

replacement frequency.

• Be sure to change the lter cartridges at least every 8,000 litres or 6 months which

ever occurs rst; or whenever you detect a change in taste, odour, or decrease in ow.

8,000 litres is approximately equal to using 20 litres daily for one year.

Substance Reduction

• For use with thread seal tape only.

• Any use of liquid sealants will void warranty.

Caution: Do not use with water that is microbiologically unsafe or of unknown quality

without adequate disinfection before or after the system.

Substance Reduction

The Water Filter models listed above have been tested and certied under AS/NZS

3497 and AS/NZS 4348 for reduction of chlorine, odour, particles, taste and turbidity.

The performance of this product has been veried and substantiated as the test data

summarised below indicates. These substances may not be in your water.

Notes

Puretec water care products are designed, manufactured and supported by Puretec Pty

Ltd the name you can trust for viable and proven water solutions. The complete range of

Puretec products are developed, rened, made to meet and exceed stringent specications

for the worldwide market.

Important: Sales of products are subject to our Terms and Conditions which are available

upon request. All specications, information and photos are a guide only and are subject to

change without notice. Please ring to conrm details. Warning: For correct operation of this

appliance it is essential to observe manufacturer’s instructions.

Class Pass Comment

Particular Reduction III YES 75% or more

Taste, Odour, Chlorine Reduction IV YES 75% or more

Cryptosporidium & Giardia Cyst Removal IIc YES 99.9% or more

Portable Reverse Osmosis Water Treatment Systems

Warranty

Any claim under this warranty must be made within 3 years of the date of purchase of the

product. This product is warranted to be free of defect of material and workmanship for 3 years

from date of purchase. 3 year warranty is 1 year parts and labour plus 2 years parts only.

Excludes cartridges.

To make a claim under the warranty, take the product and proof of purchase to place where you

purchased the product, and they will lodge a Warranty Request with Puretec.

Puretec will pay your reasonable, direct expenses of claiming under this warranty. You may

submit details and proof of your expense claim to place of purchase for consideration.

The warranty only applies if the product was used and/or installed in accordance with the user

guide and/or installation instructions. This warranty is given in lieu of all other express or implied

warranties and manufacturer shall in no circumstance be held liable for damages consequential

or otherwise or delays caused or faulty manufacturing except as excluded by law.

Applicable to all above, is that the warranties need to be approved by Puretec to ensure product

was not incorrectly used, installed or claimed. False and incorrect claims will be pursued at

Puretec’s discretion, including chargeable inspection and labour costs incurred.

Warranty/Australia

This warranty is given by Puretec Pty Ltd, ABN 44 164 806 688, 37-43 Brodie Road, Lonsdale SA

5160, telephone no. 1300 140 140 and email at [email protected].

This warranty is provided in addition to other rights and remedies you have under law: Our goods

come with guarantees which cannot be excluded under the Australian Consumer Law. You are

entitled to replacement or refund for a major failure and to compensation for other reasonably

foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the

goods fail to be of acceptable quality and the failure does not amount to a major failure.

Warranty/New Zealand

This warranty is given by Puretec Ltd, Reg. No 4464398, PO Box 875 Cambridge 3450 NZ,

telephone no. 0800 130 140 and email at [email protected].

This warranty is provided in addition to other rights and remedies you have under law: Our goods

come with guarantees which cannot be excluded under the Consumer Guarantees Act. You are

entitled to replacement or refund for a major failure and to compensation for other reasonably

foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the

goods fail to be of acceptable quality and the failure does not amount to a major failure.

Table des matières

Autres manuels Puretec Système de filtration d'eau

Puretec

Puretec Z1 Tripla Black Series Manuel utilisateur

Puretec

Puretec CD Series Manuel utilisateur

Puretec

Puretec Sparq S4 Manuel utilisateur

Puretec

Puretec WH1 Manuel utilisateur

Puretec

Puretec WU-UV Series Manuel utilisateur

Puretec

Puretec QT12 Manuel utilisateur

Puretec

Puretec ROS2700 Manuel utilisateur

Puretec

Puretec FilterWall IM2 Series Manuel utilisateur

Puretec

Puretec NTR-E3 Series Manuel utilisateur

Puretec

Puretec HYBRID H6 Manuel utilisateur

Puretec

Puretec Hybrid-P9 Manuel utilisateur

Puretec

Puretec RO270 Manuel utilisateur

Puretec

Puretec Hybrid-R Triple Series Manuel utilisateur

Puretec

Puretec ES2 Series Manuel utilisateur

Puretec

Puretec UFC Series Manuel utilisateur

Puretec

Puretec CO-RO270 Series Manuel utilisateur

Puretec

Puretec Basic HD Series Manuel utilisateur

Puretec

Puretec SF240 Manuel utilisateur

Puretec

Puretec MPB202 Manuel utilisateur

Puretec

Puretec MUL-E1 Series Manuel utilisateur

Puretec

Puretec RO SERIES Manuel utilisateur

Puretec

Puretec UFC Series Manuel utilisateur

Puretec

Puretec MaxiPlus MPB202B Manuel utilisateur

Puretec

Puretec HYBRID Series Manuel utilisateur

Manuels Système de filtration d'eau populaires d'autres marques

Wisy

Wisy LineAir 100 Manuel utilisateur

Schaffner

Schaffner Ecosine FN3446 Series Manuel d'utilisation

Pentair

Pentair FLECK 4600 SXT Guide de l'utilisateur

H2O International

H2O International H20-500 Manuel utilisateur

Renkforce

Renkforce 2306241 Manuel utilisateur

Neo-Pure

Neo-Pure TL3-A502 Manuel utilisateur

FLTR

FLTR OBF Manuel utilisateur

STA-RITE

STA-RITE VERTICAL GRID DE FILTERS S7D75 Manuel utilisateur

Applied Membranes

Applied Membranes W-G844EM Manuel utilisateur

BEGA

BEGA 116 Manuel utilisateur

WATA

WATA Standard Manuel utilisateur

Price

Price FFU series Manuel

Gaggenau

Gaggenau BRITA INTENZA 467873 Manuel utilisateur

Brita

Brita SAFF-100 Manuel utilisateur

HEISSNER

HEISSNER FPU24000-00 Manuel utilisateur

BGS technic

BGS technic 1518 Manuel utilisateur

Reverse Osmosis

Reverse Osmosis RF Series Manuel utilisateur

ubbink

ubbink Filtramax Series Manuel utilisateur