Prorack K855 Manuel utilisateur
K855
Fitting Kit
EN Fitting Instructions for Basic Carrier
x 1 x 1 x 1 x 1
x 1 x 1 x 1 x 1
x 1 x 1 x 1 x 1
Revision No: 1A 1
Fitting Kit K855
MAX kgs (lbs)
W/P WHD
Volvo
S40, 4dr Sedan 04-10 NZ 75 kgs (165 lbs) 75 kgs (165 lbs)
S40, 4dr Sedan 04-10 AU 75 kgs (165 lbs) 75 kgs (165 lbs)
S40, 4dr Sedan 04-10 ZA 75 kgs (165 lbs) 75 kgs (165 lbs)
S40, 4dr Sedan 04-10 CN 75 kgs (165 lbs) 75 kgs (165 lbs)
S40, 4dr Sedan 04-11 US 75 kgs (165 lbs) 75 kgs (165 lbs)
S40, 4dr Sedan 04-12 EU 75 kgs (165 lbs) 75 kgs (165 lbs)
2
Fitting Kit K855
X
A B C 1 2 3
S40, 4dr Sedan 04-10 (NZ) -340mm 320mm - 902mm 910mm -
-13 -3/8ths" 12 5/8ths" - 35 1/2ths" 35 13/16ths" -
S40, 4dr Sedan 04-10 (AU) -340mm 320mm - 902mm 910mm -
-13 -3/8ths" 12 5/8ths" - 35 1/2ths" 35 13/16ths" -
S40, 4dr Sedan 04-10 (ZA) -340mm 320mm - 902mm 910mm -
-13 -3/8ths" 12 5/8ths" - 35 1/2ths" 35 13/16ths" -
S40, 4dr Sedan 04-10 (CN) -340mm 320mm - 902mm 910mm -
-13 -3/8ths" 12 5/8ths" - 35 1/2ths" 35 13/16ths" -
S40, 4dr Sedan 04-11 (US) -340mm 320mm - 902mm 910mm -
-13 -3/8ths" 12 5/8ths" - 35 1/2ths" 35 13/16ths" -
S40, 4dr Sedan 04-12 (EU) -340mm 320mm - 902mm 910mm -
-13 -3/8ths" 12 5/8ths" - 35 1/2ths" 35 13/16ths" -
3
Fitting Kit EN
K855
First Time Installation
●Remove parts from inside the package and
check. Contact your dealer if any parts are
missing or damaged.
●This kit fits type A, B, C and D.
●These instructions show type A crossbar
fitted. They also apply to type B, C and D.
NOTE: Clamp images in these instructions may
not be representative of the clamps in this kit
4
Fitting Kit EN
K855
●Use keys to remove covers.
●Use hex screwdriver to reverse adjusting
screw 10 turns.
●Press adjusting screw and pull crossbar
legs out. Refer to the crossbar instructions
for crossbar adjustment method.
●Ensure each end of the crossbar is
adjusted equally.
5
Fitting Kit EN
K855
●Remove locking screw.
●Apply protective strip as shown.
Trim if required.
●It is important to put the clamps in the
correct position on the vehicle.
●Letters refer to the part numbers stamped
on clamps.
●Clamp Part Number:
A = A453
B = A454
C = A455
D = A456
6
Fitting Kit EN
K855
●Attach clamp to each leg. NOTE; clamps
may have labels showing their positions on
the vehicle (For example; "Front Right").
●Refit locking screw so that it goes through
the hole in the clamp. Do not begin to
tighten the locking screw.
●Refer to the underside of the pad for the
part number.
7
Fitting Kit EN
K855
●It is important to put the pads in the correct
position on the vehicle.
●Letters refer to the pad part numbers and
position.
●Pad Part Number:
A = 265A
B = 266A
C = 293A
D = 294A
●Place rubber pads (supplied with fitting kit)
on the vehicle roof. Pad may vary in shape
to that shown.
●Make sure the pad fits into the holes
underneath the foot.
8
Fitting Kit EN
K855
Fitment
●Please check the front of this manual for
information relating specifically to your
vehicle.
●Place crossbar on vehicle. Minimum
recommended spacing between the bars is
700mm (27 1/2") (unless otherwise stated).
●Clamps directly to edge of roof under the
doors, pin locates in hole on vehicle on
front clamps
●Adjust the legs on the crossbar so that they
are positioned equally from the ends of the
crossbar, and the clamps engage firmly on
the body work of the vehicle.
●Tighten adjusting screw to 3 Nm (2.2 ft lb)
hand tight.
9
Fitting Kit EN
K855
●Tighten locking screw on both legs evenly,
3 Nm (2.2 ft lb).
●Check crossbar is securely attached to the
vehicle.
●Use keys to fit and lock covers
10
Table des matières
Autres manuels Prorack Accessoires automobiles
Prorack
Prorack K199 Manuel utilisateur
Prorack
Prorack K623 Manuel utilisateur
Prorack
Prorack K624 Manuel d'utilisation et d'installation
Prorack
Prorack K629 Manuel utilisateur
Prorack
Prorack K458 Manuel utilisateur
Prorack
Prorack K611 Manuel utilisateur
Prorack
Prorack K671 Manuel utilisateur
Prorack
Prorack K765 Manuel d'utilisation et d'installation
Prorack
Prorack K1125 Manuel utilisateur
Prorack
Prorack K131 Manuel utilisateur
Prorack
Prorack K373 Manuel utilisateur
Prorack
Prorack K566 Manuel utilisateur
Prorack
Prorack K122 Manuel utilisateur
Prorack
Prorack K345 Manuel utilisateur
Prorack
Prorack K120 Manuel utilisateur
Prorack
Prorack K552 Manuel utilisateur
Prorack
Prorack K038 Manuel utilisateur
Prorack
Prorack K082 Manuel utilisateur
Prorack
Prorack K1163 Manuel utilisateur
Prorack
Prorack K868 Manuel utilisateur
