Nominal capacity per day
50 kg (110 lb) of waste food
Construction
All stainless steel (chassis, side panels,
drum, shaft, arms, paddles, and load
cells). Chassis is mirror finish (EN10088-
2 specification 2P)
Operating environment
Indoors or covered patio
Must not be exposed to rain, snow, or
sunshine
Ingress protection
IP54 – splash proof and dust proof
Ambient operating temperature
4°C~38°C (39°F~100°F)
Operating altitude
1000 m (3300 ft)
Floor surface flatness required
±15 mm (0.6")
Weight when empty
167 kg (368 lb)
Moving and positioning
Machine is rolled into place with casters
Machine is raised once in position and
supported by feet and rubber pads
Weight when full
240 kg (530 lb) maximum
Load per pad
81 kg (178 lb) maximum
Pressure per pad
79 kPa (11 psi), maximum
Space required around machine
Left side: 20 cm (8") minimum, 28cm
(11") preferred. 100 cm (39") is required
for servicing
Right side: 15 cm (6") minimum, 60cm
(24") preferred. 125 cm (50") is required
for servicing
Back: 2 cm (1")
Front: 60 cm (24") minimum
Water inlets
Filters: use external filters to remove
particles and hardness
Fitting: DN15 (½") female
Typically use flexible hose pipes to allow
machine to move freely. Install valves
to disconnect water for servicing and
backflow prevention devices if required
Pressure: 275 to 550 kPa
(40 to 80 psi, 2.8 to 5.6 kg/cm²)
Flow rate: 20 litre per minute (5 gpm)
max. @ 450 kPa (65 psi, 4.5 kg/cm²)
Drum water: 35°C~50°C (95°F~120°F)
Washout water: 15°C~75°C
(60°F~165°F)
Use external mixing valves, heaters,
pressure reducers, and bladder tanks to
meet the above requirements as needed
Water input per day
150 litre (40 gallon) typical
Water outlet
Typically use flexible coupling on output
to permit machine to move freely
Install stop valve on outlet pipe (used for
commissioning)
Slope pipe down by about 1 in 45 (1.3°)
Drain
Type: Must exit to sewer (not storm
drain); grease trap is required in most
jurisdictions
Size: 50 mm (2") minimum
Total water output per day
200 litre (53 gallon), typical
Flow rate of waste water out
20 l/min (5.3 gpm), maximum
0.1 l/min (0.04 gpm), typical average
AC supply
120 V, 60 Hz (100 V to 130 V)
Single phase + PE
Circuit breaker: 15 A
Fitted with NEMA 5-15 plug
or
230 V, 50 Hz (220 V to 240 V)
Single phase + PE
Circuit breaker: 15 A
Plug installed by local distributor
AC power cord
Length of cable on machine: 180 cm (6')
Can wire directly (without a plug and
socket). Outlet must be accessible by
operator and have a safety disconnect
Maximum power
690 W
Energy per day
3.6 kWh typical
User interface
22mm 3-color LED
5" touchscreen with 65k colors
Ethernet
RJ45, 100 baseT
DHCP or fixed IP address
Connect to Internet with direct cable, Wi-Fi
client, or GSM modem
Automatically connects to LFC Cloud for
remote support, reporting, and monitoring
(included in purchase price)
Powerzyme
(Microorganisms and enzymes)
0.5 litre, included with initial purchase
Powerchips
(Medium for microorganisms)
50 litre, included with initial purchase
Operating lifetime
Expected to be 15 to 25 years
Warranty
3 years on all parts and components
Safety
Certified to UL430
(waste disposal machines)
CAN/CSA-C22.2 No. 60335-1:11
EN 60335-1:2010+AMD1:2013
(general safety)
CAN/CSA-C22.2 No. 60335-2-16:16
EN 60335-2-16:2002+A1:2008+A2:2011
(waste food disposers)
EMC
EN 61000-6-3:2007+A1:2011
EN 61000-6-1:2007
EN 61000-3-2:2006+A1:2008+A2:2009
EN 61000-3-3:2013
RoHS
Compliant for EU and China
LFC-50
For complete details see User’s Manual
Installation Requirements
