Overhead door RSX Manuel utilisateur

Equipment Differences from normal Side

Mount Unit.

1) Door Shaft will be split in 2 pieces to allow

installing the drive sprocket on a Chain Coupled

Door. In addition, the shaft pieces will be shortened

on a Direct Couple Door to allow space for the

Operator Output Shaft.

2) The Emergency Hand Hoist is mounted on an

extension shaft that places the Hand Wheel and

Hoist Chain at the edge of the door.

3) Included is a kit for mounting the Hoist with the

extended shaft (Installation Instructions on reverse

side of this instruction).

Installation Differences-Direct Couple.

1) If not closed — fully close the door.

2) Slide a coupling half onto each door shaft and

operator shaft each with a square key .

3) Slide the operator between the door shafts so that

the output shaft is aligned with the two door

shaft halves.

4) Butt the coupling halves together and tighten their

set screws.

5) Roll both halves of the door shaft to remove slack

from the cables and equalize tension on both ends.

They can be held in position using clamps or locking

pliers while the shafts are being coupled together.

Bolt the coupling halves together with flat washers

next to the coupling and lock washers next to

the nuts.

6) Install Hoist Kit. (See Reverse)

Installation Differences-Chain Couple.

1) Slide the door shaft sprocket onto the half of the

door shaft that allows it to be aligned with the

sprocket on the operator output shaft.

2) Slide a coupling half onto each door shaft each with

a square key.

3) Butt the coupling halves together and tighten their

set screws.

4) Roll both halves of the door shaft to remove slack

from the cables and equalize tension on both ends.

Bolt the coupling halves together with flat washers

next to the coupling and lock washers next to

the nuts.

5) Align the door shaft sprocket with the operator

output sprocket and tighten the set screws in both

the sprocket and coupling.

6) Install Hoist Kit. (See Reverse)

CENTER MOUNT INSTALLATION

ADJUSTABLE

SHAFT

SUPPORT

BRACKET

ADJUSTABLE

SHAFT

SUPPORT

BRACKET

HAND

WHEEL

HAND

HOIST

SHAFT

HAND

HOIST

COUPLING

CHAIN

GUARD

HAND

CHAIN

SET

COLLAR

SET

COLLAR

DIRECT COUPLE

CHAIN COUPLE

800.275.6187 or www.overheaddoor.com 10-08

10-08 111431.0001

EN 36423

NOT FOR RESIDENTIAL USE

This document is a supplement to the RSX

SIDEMOUNT Manual.

CENTERMOUNT

RELEASE

111066.0001

WASHER

110819.0001.S

DOWEL PIN

110881.0001.S

E-RING

080415.0022.S

SPRING

110545.0001.S

DENTIL, HOIST

111110.0001.S

SLEEVE, DENTIL

070040.0000.S

HANDWHEEL

EXTENSION

SHAFT

HOIST SHAFT INSTALLATION

1) Drive spring pin out of the intermediate shaft

(handwheel) and remove all items up to the

handwheel release, retaining the washer. FIGURE 1.

2) Place the washer back onto the shaft and insert the

new dowel pin. FIGURE 2.

3) Next slide the short half of the dentil coupling, the

spring and finally snap the e-ring type retainer

into place.

4) Insert the handwheel extension shaft into the dentil

sleeve coupler and secure with the set screws.

5) Slide shaft support bracket(s) onto the extension

shaft. Check that the bearing bracket are free to slide

back and forth. FIGURE 3.

6) Mount the support bracket(s) to the wall or

support pad. Use a level.

7) Adjust the bearing brackets to

make the extension shaft

parallel with the wall and tighten

down the brackets.

8) Slide the handwheel, chain guard

and set collar up against the

support bracket and tighten the

set screws on the collar

and handwheel.

9) Install hand chain.

(See Owner’s Manual)

FIGURE 1

FIGURE 2

FIGURE 3

TYPICAL HORIZONTAL

MOUNTING SETUP

Access Systems Division

a Division of Overhead Door Corporation

22790 Lake Park Blvd.

Alliance, Ohio 44601

SUPPORT BRACKET/

BEARING BRACKET

P/N 108227.0002

SUPPORT BRACKET/

BEARING BRACKET

P/N 108227.0001

HORIZONTAL MOUNT

VERTICAL MOUNT

RE-USE

Autres manuels Overhead door ouvre-porte de garage

Overhead door

Overhead door 981 Guide de planification

Overhead door

Overhead door Universal Wireless Console Manuel utilisateur

Overhead door

Overhead door Wireless Wall Console Manuel utilisateur

Overhead door

Overhead door 450A Guide de démarrage rapide

Overhead door

Overhead door OverDrive Manuel utilisateur

Overhead door

Overhead door Wayne Dalton 8000 Manuel utilisateur

Overhead door

Overhead door 780 CD Series Manuel utilisateur

Overhead door

Overhead door RapidSlat 611 Guide de démarrage rapide

Overhead door

Overhead door 55 Instructions de montage

Overhead door

Overhead door 55A Instructions de montage

Overhead door

Overhead door Odyssey 1000 7030H Manuel utilisateur

Overhead door

Overhead door Legacy 920 Manuel utilisateur

Overhead door

Overhead door 1026 Manuel utilisateur

Overhead door

Overhead door SilentMax 4040 Manuel utilisateur

Overhead door

Overhead door ohd anywhere Manuel utilisateur

Overhead door

Overhead door 65A Manuel utilisateur

Overhead door

Overhead door 170 Series Guide de planification

Overhead door

Overhead door Stormtite 625 Manuel utilisateur

Overhead door

Overhead door 03T Manuel utilisateur

Overhead door

Overhead door 610F Manuel utilisateur

Overhead door

Overhead door Signature Screw Drive Manuel utilisateur

Overhead door

Overhead door Standard Drive 650 Manuel

Overhead door

Overhead door CD Series Manuel utilisateur

Overhead door

Overhead door Legacy 800 2026 Manuel utilisateur

Manuels ouvre-porte de garage populaires d'autres marques

Dorma

Dorma ES 90 Manuel utilisateur

Garaga

Garaga SECURITY+ 3265GCM 1HP Manuel utilisateur

Chamberlain

Chamberlain Whisper Drive SECURITY+ WD822K Series Manuel utilisateur

Chase Doors

Chase Doors DuraShield Manuel utilisateur

CSI

CSI Classic Manuel utilisateur

HATO

HATO 120 Manuel utilisateur

Chamberlain

Chamberlain Elite 3575S Manuel utilisateur

Richmond

Richmond GTR156 Manuel utilisateur

Raynor

Raynor 1280RGD Manuel utilisateur

CAME

CAME F4000 Series Manuel utilisateur

B&D

B&D Controll-A-Door 5 Manuel utilisateur

BFT

BFT PRV AA SL Manuel utilisateur

Craftsman

Craftsman 139.53924 Manuel utilisateur

Chamberlain

Chamberlain MyQ 940ESTD Manuel utilisateur

Automatic Technology

Automatic Technology GDO-9V1 SecuraLift Manuel utilisateur

Westfalia

Westfalia 19 36 07 Manuel utilisateur

Chamberlain

Chamberlain HD520EVP Manuel utilisateur

Cardin

Cardin BL Series Manuel utilisateur