Outdoor Plus OPT-TTM Series Manuel utilisateur
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 1
TOP TORCHES
STAINLESS STEEL / CORTEN
OPT-TT(X)M
INSTALLER: Leave this manual with the appliance
CONSUMER: Retain this manual for future reference.
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 2
SAFETY WARNINGS
AVERTISSEMENT
AVERTISSEMENT
AVERTISSEMENT
WARNING
WARNING
WARNING
Do not store or use gasoline, or other
ammable vapors and liquids, in the vicinity of
this or any other appliance.
An LP-cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
Improper installation, adjustment, alteration,
service, or lack of maintenance can cause injury
or property damage.
Read the installation, operating, and
maintenance instructions thoroughly before
installing or servicing this equipment.
FOR OUTDOOR USE ONLY.
Ne pas entreposer ne utilizer de l’essence ni
d’autres vapuers ou liquids inammables dans
le voisinage de l’appareil, ne de tout autre
appareil. Une bouteille de propane qui n’est
pas raccordee en vue de son utilisation, ne doit
pas etre entreposee dans le voisiange de cet
appariel ou de tout autre appreil.
Une installation, un ajustement, une
modication, une réparation ou un entretien
inapproprié peuvent être la cause de blessures
ou de dommages.
Veuillez lire attentivement les instructions
d’installation, d’utilisation et d’entretien avant
d’installer ou de réparer ce matériel.
POUR USAGE A L’EXTERIEUR SEULEMENT.
AVERTISSEMENTWARNING
For use with natural gas or liquid propane only.
Do not use charcoal or other solid fuel in gas
burning appliances.
Do not use your re feature for cooking.
Always adhere to the specied clearances listed in
this manual.
Never allow clothing or other ammable materials
come in contact with any hot surface until it has
fully cooled.
Never wear loose tting or hanging garments
while using your re pit. Fabric may ignite and
result in personal injury.
Pour utilisation avec du gaz naturel ou du propane
liquide seulement.
N’utilisez pas de charbon de bois ou d’autres
combustibles solides dans les appareils à gaz.
N’utilisez pas votre caractéristique de feu pour
cuisiner.
Respectez toujours les dégagements spéciés
dans ce manuel.
Ne laissez jamais des vêtements ou d’autres
matériaux inammables entrer en contact avec
une surface chaude avant d’avoir complètement
refroidi
Ne portez jamais de vêtements amples ou
suspendus lorsque vous utilisez votre foyer. Le
tissu peut s’enammer et entraîner des blessures.
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 3
SAFETY WARNINGS
TOP TORCHES
AVERTISSEMENT
AVERTISSEMENT
WARNING
WARNING
If you smell gas:
õShut o gas to the appliance
õExtinguish any open ame
õIf odor continues, keep away from the
appliance and immediately call your gas
supplier or re department.
Si’l y une odeur de gaz:
õCoupez l’admission de gaz de l’appareil.
õÉteindre toute amme nue.
õSi l’odeur persiste, éloignez-vous de
l’appareil et appelez immédiatement le
fournisseur de gaz ou le service d’incendie.
For use with natural gas or liquid propane only.
Do not use charcoal or other solid fuel in gas
burning appliances.
Do not use your re feature for cooking.
Always adhere to the specied clearances listed in
this manual.
Never allow clothing or other ammable materials
come in contact with any hot surface until it has
fully cooled.
Never wear loose tting or hanging garments
while using your torch. Fabric may ignite and
result in personal injury.
Pour utilisation avec du gaz naturel ou du propane
liquide seulement.
N’utilisez pas de charbon de bois ou d’autres
combustibles solides dans les appareils à gaz.
N’utilisez pas votre caractéristique de feu pour
cuisiner.
Respectez toujours les dégagements spéciés
dans ce manuel.
Ne laissez jamais des vêtements ou d’autres
matériaux inammables entrer en contact avec
une surface chaude avant d’avoir complètement
refroidi
Ne portez jamais de vêtements amples ou
suspendus lorsque vous utilisez votre foyer. Le
tissu peut s’enammer et entraîner des blessures.
Carbon Monoxide Hazard
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in enclosed
space such as a camper, tent, car or
home.
MONOXYDE DE CARBONE
Cette appareil peut produire du monoxyde de
carbone, un gaz inodore.
L’utilisation de cet appareil dan des espaces
clos peut entrainer la mort.
Ne jamais utiliser cet appareil dans
un espace clos comme un véhicule de
camping, une tente, une automobile ou
une maison.
AVERTISSEMENTWARNING
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 4
SAFETY WARNINGS
WARNING
California Proposition 65 Warning: This product can expose you to chemicals including Lead and Lead
Compounds, which are known to the state of California to cause cancer, and Carbon Monoxide, Lead and
Lead Compounds which are known to the state of California to cause birth defects or other reproductive
harm. For more information go to www.P65Warnings.ca.gov.
WARNING
Installation must conform with local codes or, in the absence of local codes, with the
National Fuel Gas Code, ANSI Z223.1 / NFPA 54, or International Fuel Gas Code.
The appliance, when installed, must be electrically grounded in accordance with local codes or, in
the absence of local codes, with the National Electric Code, ANSI/NFPA 70, if applicable.
BURN HAZARD
SAFETY
While the torch unit is operating, the outside surface may reach high temperatures which may cause burns.
Never leave children unattended in the area where the torch unit is being used. Close supervision of children is
necessary when any appliance is used near children. Never leave the torch unattended when in use.
Do not reach over your torch unit when hot or in use.
Keep all electrical supply cords away from the heated areas of the torch.
Clothing or other ammable materials should not be hung from the appliance, or placed on or near the
appliance.
DANGER
Propane gas source to the torch must be regulated.
Do not operate if regulator has been removed. Fire or explosion can occur.
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 5
GENERAL INFORMATIONS
Fuel Type - Before making gas connections ensure appliance being installed is compatible with the available gas
type. Check the label on the appliance to conrm appliance gas type requirement.
Gas Pressure - Proper input gas pressures are required for optimum appliance performance.
GAS PRESSURE REQUIREMENTS
Natural Gas
Minimum 3.5” W.C. - Nominal: 7.0” W.C. - Maximum 1/2” PSI (14.0” W.C.)
Liquid Propane:
Minimum 8.0” W.C. - Nominal: 11.0” W.C. - Maximum 1/2” PSI (14.0” W.C.)
CLEARANCE FROM COMBUSTIBLES
Warning - Provide adequate clearance
from combustibles as shown below.
INSTALLATION & MAINTENANCE
We suggest that our products be
serviced by a professional certied
in the U.S. By the National Fireplace
Institute as a NFI Specialists
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 6
INSTALLATION
INSTALLATION OF BASE POLE
12”
8’
Note: Installation should be done by a qualied service technician that is locally licensed.
Manual Gas
Shuto Valve
Base Pole
Base Pole
Manual Gas
Shuto Valve
Electrical
Conduit
Gas Line Gas Line
Landscape
Box
OPTION 1
Manual gas shut o located at torch.
OPTION 2
Manual gas shut o located on torch
pole (Requires you to drill a hole.)
TIKI TORCH COMPONENTS MANUAL SHUT OFF OPTIONS
Torch Head
Black Pole
Base Pole
Diagram 1 shows ½” gas stub stubbed up inside a hole.
The hole is 12” deep.
STEP 1
DIAGRAM 1 DIAGRAM 2
Diagram 2 shows the Base Pole. Slide it over the Gas stub
Adjust the height of the Base Pole so that the tapered
top end of the Base Pole ended up above grade.
Do this to make the connection between the Base Pole
and the Tiki Pole easier later on.
STEP 2
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 7
INSTALLATION
STEP 3
If you are installing the Manual Gas Shuto on the Tiki Pole
(Option 2 from page 7) rst remove the handle from the Ball
Valve and then install the ball valve on the ½” gas riser as shown
in diagram 3.
The use of pipe dope or Gas Teon tape is highly recommended
to prevent a possible gas leak.
STEP 4
Once the Manual Gas Shuto is installed, measure from the
center of the Gas Shuto to the top of the Black Base Pole.
This dimension we shall refer to as measurement “A”.
See diagram 4
STEP 5
Temporarily install the longer pole and measure from the
seam between the Base Pole and the top of the long tiki
pole. This dimension we will refer to as measurement “B”.
DIAGRAM 3
DIAGRAM 4
DIAGRAM 5
A
Base Pole
Inner Sleeve
B
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 8
INSTALLATION
STEP 6
Install ½” gas hose to your gas riser (or manual gas
shuto valve) so that the end of the ½” gas line is 1”
SHORTER than the pole (measurement “B” from the
previous page)
In addition, bring the wires previously installed
up along the gas line and tape it to the gas line in
anticipation of installing the longer tiki pole.
STEP 7
As shown in diagram 6, Measure from
the bottom of the long tiki pole up to
measurement “A” and mark the pole. Then
drill a 1” diameter hole in the side of the pole
for the Manual Gas Shuto Valve.
STEP 9
Next install the Manual Gas Shuto Valve as shown in diagram 7.
A A
DIAGRAM 6
DIAGRAM 7
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 9
INSTALLATION THE TORCH HEAD
STEP 10
STEP 9
Insert the pole into the torch head.
Secure by tightening the 3 set screws
in the base of the torch head.
See diagram 10.
Connect the gas line to the head of the tiki torch.
Do NOT use pipe dope or plumbers tape on ared
connections. Ensure connections are tight to
prevent any gas leaks.
DIAGRAM 10
DIAGRAM 9
GAS LINE
GAS LINE
COUPLING
COUPLING
HEX BOLT
ALLEN WRENCH
HEX BOLT
TOP TORCHES
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 10
MAINTENANCE
õKeep any debris out of the burning area, clean as needed.
WARNING: Installation and repair should be done by a qualied service person. Fire feature should be inspected
prior to use and at least annually by a qualied service person.
WARNING: Ensure gas and power (if applicable) are shut o and re pit is cool before servicing.
FIRE PIT OPERATION
WARNING: before use, be sure to test all gas connections for leaks. Do not use torches if there is any evidence of
leaking gas. If leaking gas suspected, turn o the main gas supply and repair immediately.
WARNING: Wind and gusty conditions will aect the ame in an unpredictable manner. If conditions exist that are
not safe for patrons, turn the torches o.
WARNING: solid fuels shall not be burned in the re pit. Leaves, sticks, wood, paper, clothing, food material, should
be kept away from the re pit. Fire pit is not for cooking. Make sure that there is no vegetation or other objects over
the top or sides of the re pit that could interfere with safe operation. See clearances at the end of this document
WARNING: when torch is not in operation turn o gas valve.
IMPORTANT: Initial Start Up: It may be necessary to purge air in gas lines after system installation.
START UP
SHUT DOWN
õSTOP! Read the safety information on “What to do if you smell gas. (Pg. 4)
õEnsure torch is clear of people, debris, that all covers are removed and the feature is safe to start.
õPlace long handled lighter or match while burning on top or in the torch.
õSlowly turn “ON” gas valve
õAfter torch ignites, remove lighter or match.
õAdjust ame to desired height
õIf the torch does not ignite, turn valve o and allow gas to clear the repeat steps 3-7.
õNever alter the design of the torch
õEnsure torch, children and patrons are supervised by a responsible adult that is familiar with emergency shut down.
õFlammable materials should not be placed on or near the re pit.
õTurn “OFF” gas valve.
Will Not Light
Air in gas line If new install, may take several attempts to purge air
Debris n gas line Conrm gas line is clear (insulation, dirt, plastic, excessive pipe sealer etc..)
Improper gas pressure Conrm proper gas pressure found
Will Not Stay Lit
Improper gas pressure Conrm proper gas pressure found (Section 1)
Improperly applied media Review media
Noise
Whistling Sound Change ex line routing. Conrm whistle free lines are being used.
TROUBLE SHOOTING
Below are some potential causes and countermeasures to the symptoms indicated in bold. If still unable to resolve
issue, please contact your retailer or certied technician.
TOP TORCHES
Table des matières
