Neomouv CARLINA Manuel utilisateur

CARLINA LINARIA

FACELIA

USER MANUAL

THIS MANUAL CONTAINS IMPORTANT

SAFETY AND OPERATING INSTRUCTIONS

« Model conforms to safety standards »

Product may differ from photos

11-2019

 
Manuel CARLINA –FACELIA –LINARIA 

CONTENTS 
 
 INTRODUCTION.................................................................................................................................... 3 
 ADJUSTEMENTS / ASSEMBLY........................................................................................................... 4 
1 Adjusting the saddle:.............................................................................................................................. 4 
1.1 Angle:................................................................................................................................................. 4 
1.2 Height :............................................................................................................................................... 4 
2 Adjusting the handlebars and the stem:.................................................................................................. 5 
2.1 Height:................................................................................................................................................ 5 
2.2 Adjusting the handlebars and the stem:.............................................................................................. 6 
3 Adjusting the brakes:.............................................................................................................................. 7 
3.1 V-type front brake:............................................................................................................................. 7 
3.2 Rear V-type brake: ............................................................................................................................. 8 
3.3 Hydraulic brakes (Only for CARLINA): ........................................................................................... 9 
4 Rack:..................................................................................................................................................... 10 
5 Mounting and dismounting the wheels (rear wheels to be handled by a specialist):........................... 10 
5.1 Front wheel:...................................................................................................................................... 10 
5.2 Rear wheel :...................................................................................................................................... 11 
6 Lights:................................................................................................................................................... 12 
 USING THE E-BIKE :........................................................................................................................... 13 
1 Indexed gearshift:................................................................................................................................. 13 
2 Electronic gear shifting: ....................................................................................................................... 13 
3 Display.................................................................................................................................................. 14 
3.1 Operation of the display (LINARIA):.............................................................................................. 14 
3.2 Operation of the display (CARLINA et FACELIA):....................................................................... 15 
4 Electric assistance:................................................................................................................................ 17 
4.1 Operation:......................................................................................................................................... 17 
4.2 Performance :.................................................................................................................................... 17 
4.3 Technical specifications of the power-assistance system :............................................................... 18 
5 The electric motor : .............................................................................................................................. 18 
 CHARGING THE BATTERY :............................................................................................................ 19 
1 NEOMOUV Lithium Ion 36-volt charger............................................................................................ 19 
1.1 Precautions (safety instructions): ..................................................................................................... 20 
1.2 Protecting the charger:...................................................................................................................... 20 
2 Battery:................................................................................................................................................. 21 
2.1 Battery performance for electric bikes:............................................................................................ 22 
2.2 Recommendations / precautions to take with your battery: ............................................................. 23 
 TIPS FOR INCREASING THE BATTERY LIFE PER CHARGE:................................................. 24 
 UPKEEP AND MAINTENANCE:........................................................................................................ 25 
1 Upkeep :................................................................................................................................................ 25 
2 Lubrication : ......................................................................................................................................... 25 
3 Maintenance : ....................................................................................................................................... 25 
 SAFETY –RECOMMENDATIONS :.................................................................................................. 26 
 TECHNICAL DATA.............................................................................................................................. 27 
 DECLARATION OF CE CONFORMITY.......................................................................................... 27 
 CERTIFICATE OF CONFORMITY................................................................................................... 27 
 TERMS OF WARRANTY..................................................................................................................... 27 
 

Manuel CARLINA –FACELIA –LINARIA

INTRODUCTION

Thank you for choosing a NEOMOUV Electric-Assisted Bicycle (E-Bike)

Your E-Bike:

Notes :

•The symbol indicates important advice or essential safety measures. Follow the various instructions.

•Some adjustment and assembly/disassembly operations require special tools and expertise; perform

these only if you have the skills to do so, otherwise consult your authorised dealer or a specialist.

•The symbol indicates the tools you will need to carry out adjustments.

•Your e-bike has a serial number engraved on the frame by the fork.

MAXIMUM LOAD:120 KG.FOR YOUR SAFETY,YOU SHOULD NOT EXCEED THE MAXIMUM LOAD WHEN

USING YOUR BICYCLE.

Rack (25kg

max)

Display

Battery

Electric

motor

Controller

Pedal

sensor

Serial number

Manuel CARLINA –FACELIA –LINARIA

ADJUSTEMENTS / ASSEMBLY

Adjust the bike to your height

2.1 Adjusting the saddle:

6mm mm Allen key

2.1.1 Angle:

Loosen the nut under the saddle (having first removed the battery).

Adjust the angle of the saddle in order to find your most comfortable position. Tighten the nut, with a

maximum tightening torque of 13 Nm.

2.1.2 Height :

5mm mm Allen key

The power-assisted bicycle enables you to opt for a lower saddle position than on a classic bike. With power

assistance, you expend less effort and can be seated in a lower position for improved safety. The required user

(cyclist) height for optimal utilisation of the bike ranges from 1.55m to 1.85 m. Adjust your saddle height to the

optimal sitting position as follows:

Wearing suitable cycling shoes, sit on the saddle, place one of the pedals in the lowest position, rest one heel

on the pedal, and your leg should rest normally on the pedal without being stretched. Raise or lower the

saddle to get the correct height. While pedalling backwards, you should not have to move your hips from side

to side.

Loosen the quick-release seat clamp.

Tighten the quick-release clamp: 8Nm.

Nut

Quick-release

Clamp

Manuel CARLINA –FACELIA –LINARIA

THE SEAT POST SHOULD NOT BE EXTENDED BEYOND THE ENGRAVED SAFETY MARK (VERTICAL BARS).

The minimum height between the highest point of the saddle and the ground is 80 cm.

2.2 Adjusting the handlebars and the stem:

2.2.1 Height:

Height (Only for LINARIA) :

5 mm Allen Key

To be comfortable, the position of your handlebars must be at least at the same height as your saddle, or higher

depending on your comfort. Unscrew the Allen screw and adjust the desired height of your stem, then tighten

it firmly. Maximum tightening torque : 14 - 15 Nm.

Do the same with the second screw to set the angle of tour handlebars, after making your adjustments, tighten

the screws vigorously, with a max. tightening torque of 6 Nm.

THE STEM MUST NOT COME OUT OF THE HEAD TUBE BEYOND THE ENGRAVED MARKINGS (VERTICAL BARS AND THE

INSCRIPTION “MINIMUM INSERTION”).

Safety

mark

Handlebar

angle

adjustment

screw

Manuel CARLINA –FACELIA –LINARIA

Incline:

5 mm Allen Key

To adjust the inclination of your stem, loosen the nut with a 5mm Allen key.

ONCE YOUR SETTING HAS BEEN MADE,TIGHTEN VIGOROUSLY,MAXIMUM TIGHTENING TORQUE:14 -15 NM.

2.2.2 Adjusting the handlebars and the stem:

To adjust the inclination of your handlebar, loosen one of the 2 nuts using a 5mm Allen key.

Once you have adjusted the angle, tighten the bolts vigorously, maximum tightening torque: 11 - 12 Nm.

Height

adjustment

screw

Handlebar angle

adjustment screw

Manuel CARLINA –FACELIA –LINARIA

2.3 Adjusting the brakes:

Screwdriver

5 mm Allen Key

2.3.1 V-type front brake:

The front brake is operated by the left handle on the handlebar.

Tighten the nut on the brake handle fully. This adjustment will enable you to compensate later for the natural

slackening of the brake cable.

Then check :

-The pressure that the brake pads exert on the rim by tightening or loosening the nut with a screwdriver.

-The brake pads attached to the caliper are tightened with the 5mm Allen key.

The pads are in the right position when they are an equal distance from the wheel rim. The final adjustment is

made by tightening the screws on the brake shoes with a screw driver (a distance of about 0.1 to 0.5 mm

from the wheel rim).

Allen Key

Screwdriver

Manuel CARLINA –FACELIA –LINARIA

2.3.2 Rear V-type brake:

The rear brake is operated by the right handle on the handlebar.

As with the brake before fully tightening the nut on the brake lever, this adjustment will allow you to compensate

later for the natural slackening of the brake cable.

Then check (Cf : 2.3.1) :

-The pressure that the brake pads exert on the rim by tightening or loosening the nut with a screwdriver.

-The brake pads attached to the caliper are tightened with the 5mm Allen key.

The pads are properly adjusted when they are at equal distance from the rim.

The control of your adjustment is correct, when the wheel, turning freely, stops smoothly.

WARNING!IN WET WEATHER OR ON DAMP GROUND,THE BRAKING DISTANCE INCREASES.

Manuel CARLINA –FACELIA –LINARIA

2.3.3 Hydraulic brakes (Only for CARLINA):

Your e-bike is equipped with front and rear hydraulic disc brakes. The maintenance of this system must be

carried out by a specialist. Nevertheless, here are a few recommendations:

-Periodically check the condition of the lining on the brake pads. It is important to avoid leaving this until

the last minute, because if the lining is damaged, the disc rubs against the metal of the pads which

damages them.

-Here are 2 ways to monitor the wear and tear on your pads:

oBy sound: the braking sound will be more metallic when the lining is worn.

oBy sight: you can see the thickness of the lining when looking from the front of the calliper.

-Periodically check the cleanliness and wear of the discs. Use alcohol or water to clean the discs.

-Completely avoid any contact with greasy substances on the disc and the pads. The pads will absolutely

have to be changed. (They are porous and will absorb the greasy substance).

AS A GENERAL RULE,THE HYDRAULIC DISC BRAKING SYSTEM SHOULD NOT BE ADJUSTED BY NON-EXPERTS.

WE RECOMMEND THAT YOU CALL A SPECIALIST SHOULD YOU HAVE ANY DOUBTS ABOUT WHAT TO DO.

Disc

Pads

Manuel CARLINA –FACELIA –LINARIA

2.4 Rack:

DO NOT LOAD RACK BEYOND THE STIPULATED WEIGHT:25 KG.

Any carrying device or other equipment installed by you on your rack (e.g., child seats, other equipment, etc.)

must be compatible with the robustness and build of the bike.

YOU SHOULD PERIODICALLY CHECK THE TIGHTNESS OF THE RACK’S FASTENINGS.THIS TYPE OF RACK

IS NOT DESIGNED TO TOW A TRAILER.

Any alterations made to the rack by the user will at their own risk.

When the rack is loaded, changes in the behaviour of the bicycle must be taken into account (wind stability,

braking distances, changes in direction, etc.). For their safety, the user must be aware of these changes in

operation.

When installing a child seat or panniers, the user must perform a safety check (e.g., hanging straps that are in

danger of catching in the spokes and raise the risk of a fall; check the secureness of the fastenings on the child

seat, the potential trapping of the child's fingers under the saddle, etc.)

The reflector and the rear light must not be covered by the equipment or seat that has been fitted to the rack.

The load on the rack must be evenly distributed on both sides to ensure the stability of the equipment while

riding on public roads.

2.5 Mounting and dismounting the wheels (rear wheels to be handled by a specialist):

2.5.1 Front wheel:

15 mm open-ended spanner

Dismounting the front wheel:

First, loosen the V-Brake’s cable clamp to release the pads and enable the removal of the wheel. Undo the cap

nuts on each side and remove the washers.

Raise the bike and tap lightly on the top of the tyre to remove the wheel.

Mounting the front wheel:

Reposition the washers on the wheel axle. Raise the bike and insert the wheel axle into the base of the opening

of the fork ends.

Check the position of the washers as well as the centring of the wheel. Screw in the wheel nuts. Alternately and

progressively tighten the wheel nuts on each side (max. tightening torque 25 Nm).

If the wheel is not centred, loosen the nuts and perform the operation again.

DO NOT ADJUST THE LOCKNUTS,YOU MAY DAMAGE THE BEARINGS.

Adjust your brake again (see Chapter 2.3.1).

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels neomouv Vélo

neomouv

neomouv ENARA Manuel utilisateur

neomouv

neomouv FURTIVOO Manuel utilisateur

neomouv

neomouv DRIVE Manuel utilisateur

neomouv

neomouv FACELIA N3 Manuel utilisateur

neomouv

neomouv PLIMOA Manuel utilisateur

neomouv

neomouv Bricks Manuel utilisateur

neomouv

neomouv CROONY Manuel utilisateur

neomouv

neomouv PLIMOA Manuel utilisateur

neomouv

neomouv PLIMOA Manuel utilisateur

neomouv

neomouv Montana Brose Manuel utilisateur

neomouv

neomouv CRONOS Manuel utilisateur

Manuels Vélo populaires d'autres marques

RAMBO

RAMBO R1000X2M-FF-BFD Manuel utilisateur

Vermeiren

Vermeiren SAFARI Manuel utilisateur

Velec

Velec A2/36V Manuel utilisateur

Coswheel

Coswheel A-ONE Manuel utilisateur

Betzold

Betzold 97869 Manuel utilisateur

Cervélo

Cervélo S3 2019 Manuel utilisateur

Tenways

Tenways AGO X Manuel utilisateur

Festo

Festo EGSC-BS-KF Manuel de la liste des pièces

Gio Electric

Gio Electric H1 Volt Manuel utilisateur

GOGOBEST

GOGOBEST GM30 Manuel utilisateur

DAHON

DAHON CIAO - 2009 Manuel utilisateur

Aprimatic

Aprimatic ONDA 500 Guide de démarrage rapide

MV Agusta

MV Agusta Lucky Explorer GRAVEL Manuel d'instructions

Greyp

Greyp G6 Series Manuel utilisateur

Babboe

Babboe Carve-E Manuel utilisateur

Huka

Huka orthros Manuel utilisateur

Xtracycle

Xtracycle Stoker 2021 Manuel utilisateur

APRILIA

APRILIA DORSODURO 750 ABS 2015 Manuel utilisateur

neomouv CARLINA Manuel utilisateur

Manuels Vélo populaires d'autres marques