Lanner electronics EM-561 Series Manuel utilisateur

EM-561 SERIES

5.25” EMBEDDED SBC

WITH VGA &THREE 10/100MBPS LAN

FOR SOCKET370 PENTIUM III PROCESSOR

USER'S MANUAL

This document is a copyright of the original manufacturer, 2001. The original manufacturer

reserves the rightsto make improvement and/or modification to the product described in this

manual at any time without further notice. This manual may not, in whole or in part, be

photocopied, reproduced, transcribed, translated, or transmitted in whatever form without the

written consent of the manufacturer, except for copies retained by the purchaser for backup

purposes. All rights are reserved.

TRADEMARKS

The following are trademarks or registered trademarks of their respective companies: IBM, Intel,

AMD, Cyrix, NS, Award, AMI, Microsoft, Windows, Windows NT, Novell, SCO, PC/104, PICMG, ALI,

UMC, SMC and Winbond. Products mentioned in this manual are mentioned for identification

purposes only. All names of products or services appearing in this manual are the trademarks or

registered trademarks of their respective organizations and companies.

Date: October 1st , 2001

TABLE OF CONTENTS

CHAPTER 1General Information …………………………………………..…… 1

1.1Introduction ………………………………………………………………….……….. 1

1.2Features ………………………………………………………………………..……….. 1

1.3 Specification ………………………………………………………………….……….. 2

1.4 Unpack Your EM-561 ………………………………………………………..…… 2

1.5 Board Layout …………………………………………………………………..……….. 3

CHAPTER 2Installation …………………………………………………………….4

2.1 Hardware Setup and Installation ………………………..…………………… 4

2.1.1 CPU Installation and Upgrading ……………….…………………… 4

2.1.2 System Memory Installation ………………………………………… 5

2.1.3 DiskOnChip Installation ………………………..…………………….. 6

2.2 Jumper Settings And Connectors ……………………………………………….6

2.2.1 Board Outline …………………………………………………….……… 6

2.2.2 Jumper Settings Summary ………………………………..………….7

2.2.3 I/O Connectors Summary ……………………………..……………… 10

CHAPTER 3BIOS Setup ………………………………………………………… 26

3.1 Running Award BIOS……………………………………………………………….26

3.2 CMOS Setup Utility ………………………………………………………………….27

3.3 Standard CMOS Setup ……………………………………………………………… 28

3.4 BIOS Features Setup ……………………………………………………………….. 30

3.5 Chipset Features Setup …………………………………………………………….32

3.6 Integrated Peripherals …………………………………………………………….. 34

3.7 Power Management Setup ……………………………………………………….36

3.8 PnP/PCI Configuration ……………………………………………………………… 39

3.9 PC Health Status ……………………………………………………………………….40

3.10 Frequency / Voltage Control ……………………………………………………. 41

3.11 Load Fail-Safe Defaults …………………………………………………………….. 42

3.12 Load Optimized Defaults …………………………………………………………… 42

3.13 Supervisor / User Password …………………………………………………….. 43

3.14 Save & Exit Setup …………………………………………………………………….. 43

3.15 Exit Without Saving ………………………………………………………………….. 44

CHAPTER 4Drivers Support ……………………………………………………… 45

4.1 Driver Support …………………………………………………………………………… 45

4.1.1 Core Chip ………………………………………………………………..…….45

4.1.2 Network ……………………………………………………………………… 45

4.1.3 VGA ………………………………………………………………………….. 45

4.1.4 Hardware Monitor ……………………………………………………….46

4.2 Driver List ……………………………………………………………………………….46

4.3 Driver Setup and Installation …………………………………………………….47

4.3.1 Intel 815 Chipset ………………….…………………………….……….47

4.3.2 Intel Ultra ATA Storage Driver ………………..…………………….49

4.3.3 VGA Driver …………………..……………………………………………… 51

4.3.4 LAN Driver …………………….…………………………………………….53

APPENDIX A How To Use Watch-Dog Timer

Terms and Condition

RMA Service Request Form

Page: 1

CHAPTER 1General Information

1.1 Introduction

The new EM-561 Series embedded SBC is highly configurable with multiple features to suit

different types of commercial and industrial needs. Three Ethernet capability of the EM-561 Series

gives network administrators another tool to deal with today's changing application needs. The

board comes with the top-of-the-line Intel 82559 LAN chips could act as a firewall that sits

between the Internet and a company's internal network. This applies to Web (HTTP) servers, FTP

servers, SMTP (E-mail) servers or DNS servers. The EM-561 can also be used as an inter-network

gateway that connects a number of local networks. Once again, the three Ethernet capability and

processing power of the EM-561 Series gives it the ability to perform these functions.

The new EM-561 Series is enhanced with IntelÒ815E chipset; one 168-DIMM socket support up

to 100/133 MHz SDRAM and one DiskOnChip from M-System socket support up to 288MB flash

memory disk which provide full functionality and performance to be used "exactly" where you

need it as well. EM-561 also features high performance VGA display that support resolutions and

color depths up to 1600x1200 x256 color at 85Hz.

EM-561 has many expansion function such as one PCI expansion connector with one PCI riser

card; one FDD interface support up to two floppy devices ; two IDE ports that support up to four

IDE devices and Ultra ATA/100/66/33 interface helps designers and integrators improve system

performance by retrieving and sending data faster. Everything you could need is on-board.

In addition, it is equipped with two RS-232 serial ports; four USB ports; one multi-mode parallel

port which supports SPP, ECP and EPP modes. It provides more flexible functions to satisfy all

users' different application requirements.

The EM-561 also offers several industrial features such as a 16 -level watchdog time-out intervals

and contains the health monitoring hardware. The health monitoring IC keeps an eye on the

CPU and releases an audio alarm when detecting abnormal operating voltage & temperature or

malfunction of the cooling fans. And with its industrial grade reliability, the EM-561 can operate

continuously at temperatures up to 60° C (140° F). All these numerous features provide an ideal

price/performance solution for commercial and industrial applications where stability and reliability

are essential.

1.2 Features

nSupportsSocket 370 Celeron/Intel®Pentium III Processor, 133MHz FSB

nIntel®815E chipset

nBuilt–in three 10/100BASE-TX Ports with RJ-45 connectors

nSocket for DiskOnChip

nWith one PCI expansion slot

n4 USB ports and supports 4 Ultra ATA 100 devices

n5.25” Form Factor, special design for firewall and network applications

Page: 2

1.3 Specification

EM-561 Series

Processor IntelÒPentium III Coppermine / CeleronÔProcessor in Socket

370(66/100/133 MHz) and up to 1GB

Chipset IntelÒ815E chipset

System Memory / RAM One 168-pin DIMM sockets, support 100/133 MHz SDRAM and up to

512 SDRAM

BIOS AwardÒlicensed BIOS

Flash Memory Disk Reserved socket for DiskOnChip from M-System, support up to 288 MB

flash memory disk

Graphics Controller Internal graphic controller with Intel’s Dynamic Video Memory

Technology, resolution up to 1600 x 1200 x 256 colors @ 85 Hz, with

VGA 2x6x2.54 mm pin header with housing

Network Interface Three Intel 82559 chip, support three-10/100 Base-TX Ethernet, three

RJ-45 external connectors with ACT LED, LNK LED

IDE Drive Interface Two PCI IDE ports that support up to four IDE devices and Ultra

ATA/100/66/33

Floppy Drive Interface One FDD port, support up to two floppy devices

Serial Port Two COM ports, one RS-232 DB-9 connector and one RS-232

2x5x2.54 mm pin header with housing

Parallel Port One multi-mode parallel port ( SPP / EPP / ECP )

Bus Interface PCI bus slot

RTC Internal RTC with Li battery

Keyboard/Mouse 6-pin keyboard/mouse pin header

Watchdog Timer 16-level time-out intervals

Universal Serial Bus Support 4 USB ports (4x5 pin headers)

Health Monitoring Enhanced hardware monitor functions with optical sensor

Operating Temperature 0 °C~60 °C

Storage Temperature -20 °C~70 °C

Humidity 5 %~95%RH, non-condensing

Dimensions 203 x 146 x 25 mm ±0.5 mm

EMI/EMS EN 50081-1/1994>EN 55022/1997>EN 61000-3-2/1995

>EN 61000-3-3/1995, EN 50082-1/1994>IEC 1000-4-2/1995,

IEC 1000-4-3/1995, IEC 1000-4-4/1995, EN55024

Remark PCI Rev. 2.2 compliant

ORDERING INFORMATION EM-561B

EM-561C (Customer model No.)

1.4 Unpack your EM-561

Before you begin to install your card, please make sure that you received the following materials as

listed below:

nEM-561 x 1 pc 5.25" Embedded Single Board Computer

nFDD Cable x 1 pc 34 to 34-pin Standard Header Flat Ribbon Cable

nIDE Cable x 1 pc 40-pin IDE Cable

nVGA Cable x 1 pc 12-pin Standard Header to 15-pin/3-Row D-Sub Cable

nKeyboard and Mouse Cable x 1 set 8-pin connector to PS/2 Keyboard and Mouse Cable

nDriver Utility CD-ROM x 1 pc Drivers & Utilities

nUser's Manual x 1 pc This User's Manual

Page: 3

1.5 Board Layout

Page: 4

CHAPTER 2 Installation

2.1 Hardware Setup and Installation

2.1.1 CPU Installation and Upgrading

Step 1: Locate the ZIF socket and open it by first pulling the lever of socket upward.

Step 2: Insert the CPU into the socket. Please keep the lever right angle when

inserting CPU.

Step 3: When inserting the CPU please note the correct orientation as shown. The

notched corner should point toward the end of the lever.

Step 4: Push the lever down to close the socket.

PGA370

Page: 5

Step 5: Attach the heatsink onto the CPU.

Step 6: Push the clip of heatsink downward to hock the ear of socket firmly.

Step 7: Finally, attach the fan cable to the CPU fan header.

2.1.2 System Memory Installation

Step 1: Open latches of DIMM socket.

Step 2: Insert the RAM module into the DIMM socket.

Step 3: Press the latches into the notches of the RAM module.

Page: 6

2.1.3 DiskOnChip Installation

Please make sure the central polarization key on the socket, and place the DiskOnChip

as the same direction.

2.2 JUMPER SETTINGS AND CONNECTORS

2.2.1 Board Outline

CON2

PWR1

IDE1

IDE2

FDC1

Cyrix

COM1

JP5

LAN1

LAN2

LAN3

CON1

JP3 JP2 JP1

JP12

JP15

ATXC1

JP13

JP14

JP6

SDOC1

PCI1

KM1

JP8

DIMI

JP10

JP11

SR1

ATXPS1

Cyrix

CPU

USB1

USB2

USB3

USB4

JP7

ATXPB1

JP9

LPT1

COM2

VGA1

FAN1

AT Power Connector 90

。

forEM-561C

PS1

Table des matières

Autres manuels Lanner electronics Ordinateur monocarte

Lanner electronics

Lanner electronics IAC-F847 Series Manuel utilisateur

Lanner electronics

Lanner electronics IAC-F694 Series Manuel utilisateur

Lanner electronics

Lanner electronics EM-535 Series Manuel utilisateur

Lanner electronics

Lanner electronics EM-551Series Manuel utilisateur

Lanner electronics

Lanner electronics IAC-H668 Series Manuel utilisateur

Lanner electronics

Lanner electronics AP-370VF Manuel utilisateur

Lanner electronics

Lanner electronics EM-9560 Series Manuel utilisateur

Lanner electronics

Lanner electronics PC/104 Single Board Computer with STPC Atlas CPU, and VGA, LCD, LAN, SSD, on-board RAM, 4xCOM,... Manuel utilisateur

Lanner electronics

Lanner electronics MB-X66 Series Manuel utilisateur

Lanner electronics

Lanner electronics EM-568 Series Manuel utilisateur

Lanner electronics

Lanner electronics AP-545L Manuel utilisateur

Lanner electronics

Lanner electronics EM-660 Series Manuel utilisateur

Lanner electronics

Lanner electronics IAC-H670 Series Manuel utilisateur

Lanner electronics

Lanner electronics IAC-F845 Series Manuel utilisateur

Manuels Ordinateur monocarte populaires d'autres marques

WIN Enterprises

WIN Enterprises PL-80910 Manuel utilisateur

AXIOMTEK

AXIOMTEK SBC81206 Series Manuel utilisateur

Embest

Embest SOM-PH8800 Manuel utilisateur

SeaLevel

SeaLevel SBC-R9 Manuel utilisateur

SMART Embedded Computing

SMART Embedded Computing ATCA-8310 Manuel utilisateur

WinSystems

WinSystems PPM-LX800-G Manuel utilisateur

GIGAIPC

GIGAIPC QBiX-PPC Series Manuel utilisateur

OLIMEX

OLIMEX A10S-OLinuXino-MICRO Manuel utilisateur

Commell

Commell FS-978 Manuel utilisateur

GIGAIPC

GIGAIPC QBiP-8665A/ Manuel utilisateur

VersaLogic

VersaLogic Python EBX-11 Manuel utilisateur

Micro Computer Specialists

Micro Computer Specialists IRV-3702 Manuel utilisateur

CompuLab

CompuLab SB-A510 Manuel utilisateur

Boser

Boser HS-7321 Manuel utilisateur

Premier Farnell

Premier Farnell Embest SBC8530 Manuel utilisateur

MicroSys Electronics

MicroSys Electronics miriac SBC-LS1043A2 Manuel utilisateur

Aaeon

Aaeon UP Manuel utilisateur

Portwell

Portwell WUX Series Manuel utilisateur