KYE Systems Corp. Genius SP-E120 Manuel utilisateur

ServiceGuide SP-E120

Version : 1.0 Page 1 of 15

SERVICE GUIDE

KYESYSTEMS CORP.

SP-E120

ServiceGuide SP-E120

Version : 1.0 Page 2 of 15

Version : 1.0

RevisionHistory

Version Date Change

1.0 15/05/2008

ServiceGuide SP-E120

Version : 1.0 Page 3 of 15

Table of Contents

Revision History …………………………………………………………………….2

Table of Contents ……………………………………………………………………3

Getting Started ………………………………………………………………………4

Conventions Used in this Guide ……………………………………….4

Safety Precautions ……………………………………………………..4

Chapter 1. How to Handle Defective Returns……………………………………..5

1.1 Overview …………………………………………………………..5

1.2 Problems …………………………………………………………...6

1.2.1 One or more channels no sound ………………..…7

1.2.2 Power LED (indicator) no light………………....…8

1.2.3 Volume no function...…………………….………..8

Chapter 2. Specifications …………………………………………………………9

Chapter 3. Block Diagram ……………………………………………………….10

Chapter 4. Exploded View ………………………………………………….11 ~ 12

Chapter 5. Part List ………………………………………………………………13

Chapter 6. Schematic Diagram …………………………………………………..14

Chapter 7. Important Notes ………………………………………………………15

7.1 Packing Requirement for Sending the PCB Assembly by Post …..15

7.2 Short of Spare Parts while Repairing a Speaker System …………15

ServiceGuide SP-E120

Version : 1.0 Page 4 of 15

Getting Started

Conventions Used in this Guide

Pay Special Attention : Instructions that are important to remember and

may prevent mistakes .

Caution : Information that, if not followed, may result in damage to the

product .

Safety Precautions

The following precautions should be observed in handling the speaker

Described in this guide :

Place the speakers on a flat, level and stable surface.

Do not place the speakers in environments subject to mist, smoke,

vibration, excessive dust, salty or greasy air, or other corrosive gases

and fumes.

Do not drop or jolt the speakers.

Do not allow anything to drop into the subwoofer case through its

ventilator, as it could result in fatal electric shock or fire .

Place the unit far enough from other equipments for good heat

dissipation .

Disconnect the AC power cord from the AC outlet before performing

any maintenance on the speakers .

Do not perform any maintenance with wet hand .

Prevent foreign substances, such as water, other liquids or chemicals ,

From entering the speakers while performing maintenance procedures

on the speakers .

ServiceGuide SP-E120

Version : 1.0 Page 5 of 15

Chapter 1. How to Handle Defective Returns

1.1 Overview

Verifying problems

Proceeding necessary tests

Receiving Defective speakers from

Customers

Analyzing possible malfunction

causes

Deciding & proceeding the

rectification methods

Replace necessary defective parts

Proceeding tests to

Verif

if the s

eaker is

functionin

normall

Return the speakers with p

roper

repackaging to customers

Function NG

Function OK

Function NG

ServiceGuide SP-E120

Version : 1.0 Page 6 of 15

1.2 Problems

Item Problem Description

1.2.1 Oneormorechannelsnosound

1.2.2 PowerLED(indicator)nolight

1.2.3 Volumenofunction

ServiceGuide SP-E120

Version : 1.0 Page 7 of 15

Attention

1.2.1 One or more channels no sound

Problem

Solutions

Please follow the numbered sequence marked within parenthesis given in individual

Flow chat, in that this is the best-recommended sequence to rectify the problems.

One or more channels no sound

Broken or short circuit Defective U1 Speaker cable

dis-connect or speaker

damaged

Check solder points on

PCB

Check and Replace

defective IC

Re-connect speaker

cable or replace

defective speaker(s)

Analyzer and

Identify the Causes

ServiceGuide SP-E120

Version : 1.0 Page 8 of 15

1.2.2 Power LED (indicator) no light

Problem

Solutions

1.2.3 Volume no function

Problem

Solutions

Power LED (indicator) no light

Power switch or LED

defective

Defective

D1~D4,R11,C16,C17

Ac cord of transformer

disconnected or defective

Re-solder or replace

defective component(s)

Analyzer and

Identify the Causes

Volume no function

Broken or short circuit DefectiveU1,VR1

Check solder points on PCB

Analyzer and

Identify the Causes

Check and Replace defective

components

ServiceGuide SP-E120

Version : 1.0 Page 9 of 15

Chapter 2. Specifications

NO. Description Unit Specifications

1 Out Power at THD 10% W ≧1

2 Sensitivity V 310 ±50

3 Freq. Response (Top -3dB) Hz 38~20K

4 Separation dB ≧50

5 S/N ratio dB ≧70

6 Hum & Noise (Vol.: max) mV ≦ 2

ServiceGuide SP-E120

Version : 1.0 Page 10 of 15

Chapter 3. Block Diagram

AUDIO IN

Volume

Increase

Power

Amplifier

R.CH Speaker

AC IN

L.CH Speaker

Volume

Decrease

Power

Conditioner

Table des matières

Autres manuels KYE Systems Corp. Intervenants

KYE Systems Corp.

KYE Systems Corp. Genius SP-S110 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-U115 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SW-Flat2.1 700 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1250K Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF2000X Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF850X Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-i150 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF1200A Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-S200 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-N200 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-E06S Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-N120 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF 2.1 800 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP700 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF360A Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-i175 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-J330 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-U110 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-F200 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF800 PRO Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF2.0 1250 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-S115 Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-HF355X Manuel utilisateur

KYE Systems Corp.

KYE Systems Corp. Genius SP-S110 Manuel utilisateur

Manuels Intervenants populaires d'autres marques

argon audio

argon audio IE20 Manuel utilisateur

Denon

Denon SC-N7 Manuel utilisateur

Gemline

Gemline Ace 3952 Manuel utilisateur

Focal

Focal ON WALL 300 Mode d’emploi

HEADRUSH

HEADRUSH Maximus HRSP 5024 Manuel utilisateur

SoundLogic

SoundLogic BCCS-6/6395 Manuel utilisateur

Peavey

Peavey DTH 218 Manuel utilisateur

Avantree

Avantree Pluto Air Manuel utilisateur

Morel

Morel Integra Series INTEGRA OVATION 4 Manuel utilisateur

Oppo

Oppo SONICA Manuel utilisateur

Bose

Bose SoundLink Wireless Music System Manuel utilisateur

Rocksteady

Rocksteady Stadium Manuel utilisateur

Bowers & Wilkins

Bowers & Wilkins 4 Manuel utilisateur

Sonance

Sonance SONOS OUTDOOR Series Manuel utilisateur

Electro-Voice

Electro-Voice EVID FM4.2 Manuel utilisateur

Pioneer

Pioneer XW-HTD630 Manuel utilisateur

Onn

Onn BWA16AA002 Manuel utilisateur

HP GL313AA - USB Speakers PC Multimedia Manuel utilisateur