Kipor IG3000 Manuel d'installation

Preface

Thank you for purchasing KIPOR diesel generator set.

This instruction includes the operations and maintenance of IG3000 and IG4000.

This instruction is written according to the newly developed products.

KIPOR has the right to modify this instruction without further notice.

No duplicating without written approval.

As a part of the generator, this instruction should be transferred accompanying the

generator.

Please pay particular attention to the following signs:

Failure to properly follow these precautions may result in

property damage, serious injury or DEATH!

Read all labels and the owner's manual before operating

this generator.

Operate only in well ventilated areas. Exhaust gas contains

poisonous carbon monoxide, and can be deadly. Always

stop engine before refueling. Wait 5 minutes before

restarting.

Check for spilled fuel or leaks. Clean and/or repair before

use.

Keep any sources of ignition away from fuel tank, at all

times.

Indicates a strong possibility of severe personal injury or

death if instructions are not followed

Indicates a possibility of personal injury or equipment

damage if instructions are not followed

NOTE: Gives helpful information.

If a problem should arise, or if you have any questions

about the generator, consult an authorized dealer.

Our generators are designed to give safe and dependable

service if operated according to instructions. Read and

understand the Owner's Manual before operating the

generator. Failure to do so could result in personal injury or

equipment damage.

Content

1. Safe use instruction ···························································································1

2. Parts identification ····························································································3

3. PRE-OPERATION CHECK················································································8

4. Starting engine·································································································12

5. Generator use··································································································15

6. Stop the Engine ·······························································································19

7. Maintenance ····································································································20

8. Transportation/Storage·····················································································25

9. Troubleshooting ·······························································································26

10. Basic parameters···························································································28

11. Electric schematic diagram ············································································30

12. Castor Assembly ····························································································33

13. Appendix ········································································································35

1. Safe use instruction

Operate carefully and make sure users and others safety.

WARNING

■Our generators are designed to give safe and

dependable service if operated according to instructions.

Read and understand the Owner's Manual before operating

the generator. Failure to do so could result in personal injury

or equipment damage.

WARNING

■Never run the generator in an enclosed area for exhaust

gas contains poisonous carbon monoxide. Be sure to

provide adequate ventilation.

WARNING

■ The muffler becomes very hot during operation and

remains hot for a while after stopping the engine.

Be careful not to touch the muffler while it is hot.

■ To prevent scalding, please pay attention to the warning

marks attached to the generator.

WARNING

■Gasoline is extremely flammable and explosive under certain conditions. Refuel

in a well ventilated area with the engine stopped.

■Keep away from cigarette, smoke and sparks when refueling the generator.

Always refuel in a well-ventilated location.

■Wipe up spilled gasoline at once.

■Restrict application of generator in high-hazard risk to causing fire area.

WARNING

■Connections of communication base station standby power and its electrical

system must be made by a qualified electrician and must comply with all applicable

laws and electrical codes.

WARNING

■ Always make a pre-operation inspection before you start the engine. You may

prevent an accident or equipment damage.

■ Please operate the generator at outdoor or under good ventilation condition.

■ Operate the generator on a level surface. If the generator is tiled, fuel spillage

may result.

■ Know how to stop the generator quickly and understand operation of all the

controls. Never permit anyone to operate the generator without proper

instructions.

■Keep children and pets away from the generator when it is in operation.

■Keep away from the exhaust outlet while the generator is running.

■The generator is a potential source of electrical shocks when misused; do not

operate with wet hands.

■ Do not operate the generator in rain or snow and do not let it get wet.

2. Parts identification

2.1 Outside overview

See Fig.1.

Fig.1 Outside view

Oil level switch

2.2 Control panel

2.2.1 IG3000 Control panel

See Fig. 2

Fig.2 IG3000 Control panel

油开关

空滤盖

IG4000 oil level

switch

ir filter cove

Autres manuels pour IG3000

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Kipor Générateur portable

Manuels Générateur portable populaires d'autres marques

Kohler

Kohler 20EORZ Mode d’emploi

Powerhorse

Powerhorse 83171 Manuel utilisateur

HURST

HURST ML-630-SI Manuel utilisateur

ETQ

ETQ TG4000 Manuel utilisateur

Briggs & Stratton

Briggs & Stratton 40265 Guide de configuration

ConMed

ConMed 7550 Manuel utilisateur

Owon

Owon Waveform Generator Manuel utilisateur

evertz

evertz 7700 Series Manuel utilisateur

Power Stroke

Power Stroke PS906025 Manuel utilisateur

Firefly

Firefly Cygnus CYG2400/460/24 Manuel utilisateur

Draper

Draper PG950S Mise à jour du firmware

PowerBoss

PowerBoss PowerBoss Manuel utilisateur

SDMO

SDMO SH 4000 Manuel utilisateur

EINHELL

EINHELL STE 5500 Manuel utilisateur

Wanco

Wanco WI3000P Manuel utilisateur

Full Boar

Full Boar FBT-3300 Manuel utilisateur

Dwyer Instruments

Dwyer Instruments ASG Manuel utilisateur

Westinghouse

Westinghouse WH1000i Series Manuel utilisateur