Johnson Controls TPLC060A12MP12C Manuel utilisateur

NOTES:

1. If the furnace is equipped with NOx screens and is to be

used with LP (propane) gas, the screens must be removed

prior to start-up.

2. Drip leg in the gas line must be installed.

3. The furnace controls require correct polarity on the power

supply and a proper ground.

4. Y & G must be connected to the control board for cooling

operation.

5. External filters required on all configurations.

6. Electrical or gas entry is available on both casing sides.

7. To measure total static pressure add supply duct pressure to

the return duct pressure, add pressure drop across the ‘A’

coil, and add pressure drop across the filter. Ignore negative

signs on the readings.

8. Inlet gas pressure for natural gas should be 7” and for pro-

pane should be 11” w.c. Nominal manifold gas pressure is

3.5” for natural gas and 10” w.c. for propane at max. input.

9. For downflow application the vent blower must be rotated 90

left or right as shown.

* Other airflows are available. see Tech guide for all CFM options.

LED INDICATOR

Slow Green Flash - Normal operation in standby mode

Slow Amber Flash - Normal operation with call for cooling

Two Amber Flashes - Normal operation with call for heat

Three Amber Flashes - Normal operation, burner is on at end of

thermostat cycle.

Six Amber Flashes - Normal operation with call for heat pump

heating.

Any Red Flash - Fault condition

Models

Airflow CFM (Bottom Return without Filters) Minimum Wire

Size awg @ 75'

One-Way

Maximum

Over Current

Protection

0.5" ESP (Nominal)*

D-A C-A B-A A-B

(T,Y,C,L)PLC060A12MP12C 600 815 1050 1340 14 15

(T,Y,C,L)PLC080B12MP12C 580 775 960 1290 14 15

(T,Y,C,L)PLC080C16MP12C 1000 1200 1395 1715 14 15

(T,Y,C,L)PLC100C16MP12C 980 1165 1345 1600 14 15

(T,Y,C,L)PLC100C20MP12C 1140 1330 1515 2110 12 20

(T,Y,C,L)PLC120C20MP12C 1200 1400 1510 1990 12 20

Models Input

Rate Total Unit

Amps Air Temp. Rise

Max Input °F Air Temp. Rise

Min Input °F

Time For 1 ft3Natural Gas

(1030 Btu/Ft3) Seconds

(On Max. Rate)

Max Min

(T,Y,C,L)PLC060A12MP12C 60,000 30,000 7.0 30-60 20-50 62

(T,Y,C,L)PLC080B12MP12C 80,000 40,000 7.5 40-70 20-50 46

(T,Y,C,L)PLC080C16MP12C 80,000 40,000 10.0 35-65 20-50 46

(T,Y,C,L)PLC100C16MP12C 100,000 50,000 10.0 35-65 20-50 37

(T,Y,C,L)PLC100C20MP12C 100,000 50,000 12.0 35-65 20-50 37

(T,Y,C,L)PLC120C20MP12C 120,000 60,000 12.0 45-75 25-55 30

This document does not replace the installation instructions, which must be referred to for

detailed information.

CLEARANCES

* 24" clearance in front and 18" on side recommended for

service access.

All furnaces approved for alcove and attic installation.

DIMENSIONS

FRONT

SUPPLY END RETURN END

LEFT SIDE

RIGHT SIDE

33”

Clips can be flipped

into the up position

for coil cabinet or

plenum attachment

A-COIL

Follow all national, local codes and standards in addition to this document. The installation

must comply with regulations of the serving gas supplier, local building, heating, plumbing,

and other codes. In absence of local codes, the installation must comply with the national

codes and all authorities having jurisdiction.

28.5”

Gas Pipe

Entry

Thermostat

Wiring

14”

1”

1.5”

23”

Electrical

Entry

.5”

24.25”

4” Diameter

Vent Connection

Outlet

24.38”

20”

.5”

Electrical

Entry

Vent

Connection

Outlet

29.5”

(For Cladded door add

appoximately an additional .75”)

Application Upflow Downflow Horizontal

Top 1" 0" 0"

B-Vent 1" 1" 1"

Rear 0" 0" 0"

Side 0" 0" 1"

Front* 0" 0" 0"

Floor Combustible Combustible1

1. For combustible floors only when used with special

sub-base.

Combustible

Closet Yes Yes Yes

Line Contact No No Yes

Cabinet Size A (in) B (in)

All 'A' Cabinet Furnaces 14-1/2" 13-3/8"

All 'B' Cabinet Furnaces 17-1/2" 16-3/8"

All 'C' Cabinet Furnaces 21" 19-7/8"

QUICK REFERENCE GUIDE

80% MODULATING ECM MULTI-POSITION

RESIDENTAL GAS FURNACES (33” TALL)

Subject to change without notice. Published in U.S.A. 535679-URG-A-0909

Johnson Controls Unitary Products

5005 York Drive

Norman, OK 73069

*535679*

Furnace is multi-position and may be installed in any of the configurations shown.

MOST COMMON INSTALLATION CONFIGURATIONS (MORE OPTIONS AVAILABLE WHICH IS COVERED IN THE INSTALLATION MANUAL)WITH INDUCER ROTATION,

AIRFLOW

HORIZONTAL LEFT

UPFLOW

DOWNFLOW

HORIZONTAL RIGHT

Must be installed on combustible floor base or

coil cabinet to prevent blockage of combustible air openings

Vent blower may also

be rotated 90° left or

right to vent through

casing top.

Vent blower may also

be rotated 90° left or

right to vent through

casing top.

Inducer blower may be rotated 90° either way to vent through casing side, as shown below.

These are Category I units and the vent system must be installed in accordance with latest

edition of the National Fuel Gas Code, Z223.1/NFPA 54, or in Canada, CSA B149.1.

These furnaces should be vented with type B vent pipe. No single - wall vent pipe or

vent connectors are allowed. This furnace be vented into a masonry chimney.

only

should not

These are modulating furnaces which vary the gas input between 50% and 100% of full rate.

To make it easier to check that the furnace is not overfired or underfired, put the furnace in

TEST MODE and clock the gas meter. See Installation Booklet for details of TEST MODE.

AIRFLOW

Optional - Vent blower may also

be rotated 90° left or right to

vent through casing side.

Combustion

Air Entry

Bottom blockoff

plate - Remove

for bottom

return applications

Junction Box

(May be

moved to

other side)

Vent blower must be

rotated 90° left or

right to vent through

casing side.

For downflow

applications, the gas

valve must be rotated

upwards as shown

Ce manuel convient aux modèles suivants

Autres manuels Johnson Controls Four

Johnson Controls

Johnson Controls TM8M/TMLM*MP Manuel utilisateur

Johnson Controls

Johnson Controls MM9E Series Mode d’emploi

Johnson Controls

Johnson Controls TG9S*MP Manuel utilisateur

Johnson Controls

Johnson Controls TM8T*MP Manuel utilisateur

Johnson Controls

Johnson Controls EB Series Manuel

Johnson Controls

Johnson Controls GG9S*MP Manuel utilisateur

Johnson Controls

Johnson Controls TM9V*MP Manuel utilisateur

Johnson Controls

Johnson Controls TM9X Manuel utilisateur

Johnson Controls

Johnson Controls TM8E Manuel utilisateur

Johnson Controls

Johnson Controls TP9C C Manuel utilisateur

Johnson Controls

Johnson Controls GG9S040A08MP11 Guide de démarrage rapide

Johnson Controls

Johnson Controls TM8X MP Series Manuel utilisateur

Johnson Controls

Johnson Controls York EBE Series Manuel

Johnson Controls

Johnson Controls TM8X*MP Series Manuel utilisateur

Johnson Controls

Johnson Controls TM9V C Series Manuel utilisateur

Johnson Controls

Johnson Controls 33” Multi-position Gas Furnaces Mode d’emploi

Johnson Controls

Johnson Controls DGAA Manuel utilisateur

Johnson Controls

Johnson Controls 33" Mode d’emploi

Johnson Controls

Johnson Controls TM9T Mode d’emploi

Johnson Controls

Johnson Controls RL18 Manuel utilisateur

Johnson Controls

Johnson Controls TM9M MP Series Manuel utilisateur

Johnson Controls

Johnson Controls TG9S*MP Manuel utilisateur

Johnson Controls

Johnson Controls TM9X*MP Manuel utilisateur

Johnson Controls

Johnson Controls EB Manuel utilisateur

Manuels Four populaires d'autres marques

Armstrong

Armstrong EG7H SERIES Manuel utilisateur

Payne

Payne PG92ESA Mode d’emploi

SUPREME

SUPREME FEM10-M2301CM-A Instructions de montage

Ingersoll-Rand

Ingersoll-Rand S9V2B080D4VSAC/D Instructions de montage

Fluke

Fluke 9118A Manuel utilisateur

Lennox

Lennox EL195UHE Elite Series Manuel d'installation et d'exploitation

Intertherm

Intertherm M7RL Series Manuel utilisateur

HDG

HDG Pelletmaster 15 Manuel utilisateur

Pinnacle

Pinnacle Aero Bella AB-716C-QH Manuel

Nortek

Nortek MG2S Series Manuel utilisateur

VERDER

VERDER CARBOLITE GERO ABF 8/28 Manuel

Goodman

Goodman GMV9 Manuel

SUPREME

SUPREME SUP10-M2301C Instructions de montage

Dettson

Dettson AMT400B34-SM1PMA Instructions de montage

Evcon

Evcon DGD 60 MBH Manuel utilisateur

Trane

Trane S8B1A026M2PSAB Instructions de montage

Hart Sceintific

Hart Sceintific 9113 Manuel utilisateur

Whirlpool

Whirlpool Gold WGGE45 Manuel utilisateur