Icom FP-561 Manuel utilisateur

SERVICE

MANUAL

MARINE PLOTTER/SOUNDER

DGPS BEACON RECEIVER

fineline6

INTRODUCTION

DANGER

ORDERING PARTS

REPAIR NOTES

This service manual describes the latest service information

for the FP-561 MARINE PLOTTER/SOUNDER and RD-200

DGPS BEACON RECEIVER at the time of publication.

To upgrade quality, all electrical or mechanical parts and

internal circuits are subject to change without notice or

obligation.

VERSION

MODEL

FP-561 General

Europe

SYMBOL

GEN

EUR

NEVER connect the unit to an AC outlet or to a DC power

supply that uses more than 33 V (FP-561) or 16 V (RD-200).

Such a connection could cause a fire hazard and/or electric.

DO NOT expose the unit to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when

connecting the unit.

DO NOT apply an RF signal of more than 20 dBm (100mW)

to the antenna connector. This could damage the unit’s front

end.

Be sure to include the following four points when ordering

replacement parts:

1. 10-digit order numbers

2. Component part number and name

3. Equipment model name and unit name

4. Quantity required

0910051392 PCB B-5305 FP-561 MAIN UNIT 1 pieces

8810004540 Screw BiH 3x8 SUS FP-561 Chassis 10 pieces

Addresses are provided on the inside back cover for your

convenience.

1. Make sure a problem is internal before disassembling

the unit.

2. DO NOT open the unit until the unit is disconnected from

its power source.

3. DO NOT force any of the variable components. Turn

them slowly and smoothly.

4. DO NOT short any circuits or electronic parts. An insulat-

ed turning tool MUST be used for all adjustments.

5. DO NOT keep power ON for a long time when the unit is

defective.

6. READ the instructions of test equipment thoroughly

before connecting equipment to the unit.

FP-561 RD-200

fineline6

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

1-1 FP-561 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1

1-2 RD-200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2

SECTION 2 INSIDE VIEWS

2-1 FP-561 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1

2-2 RD-200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2

SECTION 3 CIRCUIT DESCRIPTION

3-1 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

3-2 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1

3-3 REGULATOR CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-2

3-4 INTERFACE CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3

3-5 LOGIC CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3

3-6 DGPS RECEIVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4

3-7 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5

SECTION 4 ADJUSTMENT PROCEDURES

4-1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

4-2 FP-561 TRANSMITTER ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2

4-3 FP-561 RECEIVER ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2

4-4 FP-561 WATER TEMPERTUREM ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2

4-5 RD-200 ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4

SECTION 5 PARTS LIST

SECTION 6 MECHANICAL PARTS AND DISASSEMBLY

SECTION 7 SEMI-CONDUCTOR INFORMATION

SECTION 8 BOARD LAYOUTS

8-1 FP-561

8-1-1 SW UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-1

8-1-2 LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-3

8-1-3 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-5

8-2 RD-200

8-2-1 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-7

8-2-2 ANT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-9

SECTION 9 BLOCK DIAGRAM

9-1 FP-561 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-1

9-2 RD-200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-2

SECTION 10 VOLTAGE DIAGRAM

10-1 FP-561 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1

10-2 RD-200 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-3

fineline6

1-1 FP-561

‘GENERAL

• Display : 5.6 inch TFT color LCD (320×234 pixels)

•Power supply requirement : 11–30 V DC

•LCD brightness : 16 levels

•Power consumption : Less than 22 W (Less than 1.8 A at 12 V DC)

•Dimensions (projections not included) : 186(W)×203(H)×102(D) mm; 75⁄16(W)×8(H)×4(D) in

•Weight (approx.) : 2.2 kg; 4 lb 14 oz

•Usable temperature range : 0˚C to +50˚C; +32˚F to +122˚F

•Unit of water depth : m (meter), FT (feet), FM (fathom)

•Unit of water temperature : ˚C, ˚F

•Unit of speed : KT (knots), km/h, MI/h (miles/h)

•Unit of distance : NM (nautical miles), km, MI (miles)

•Input data format : NMEA0183, Water temp./speed, DGPS

•Output data format : NMEA0183 (GGA, GLL, XTE, AAM, VTG, BOD, WPL, BWC),

Start-stop serial forward; 4800 bps

‘GPS

•Receive system : 12 parallel-channel, all-in-one view

•Receive frequency : 1575.42 MHz (±1 MHz)

•Measuring accuracy (2DRMS) : Position 100 m, 95% of the time, PDOP≤3 (Less than 100 m, S/A OFF)

Speed Less than 1 m/sec. (PDOP≤3, S/A ON)

NOTE: All GPS receivers are subject to degradation of position and velocity accuracy under the U.S. Department of

Defence.

•Data renewed interval : 1 sec.

‘PLOTTER

•Scale setting : 16 steps

•Plotting interval : 5 sec. to 60 min., 0.01–9.99 NM*

•No. of track memories : 5000 (selectable from 7 colors)

•No. of route memories : 20 (50 points/route)

•No. of event markers : 500

•Navigation computer : Vessel position (longitude/latitude), cursor position, distance, elapsed time,

course-out distance, direction, distance, time

•Data indication : Coastline, place name, contour line, route, lighthouse, longitude/latitude line

•Alarm : Area and Arrival alarms

1 - 1

SECTION 1 SPECIFICATIONS

fineline6

1 - 2

All stated specifications are subject to change without notice or obligation.

‘VIDEO SOUNDER

•Transmission freq. : 50 kHz, 200 kHz

•Output power : 500 W RMS

•Water depth range : 5–640 m* in 8-color indication

•Water temp. range : 0˚C to +40˚C; +32˚F to +104˚F

•Speed range : 0.0–99.9 KT*

•Bottom lock expansion range : 5 m*, 10 m*, 20 m*, 40 m*

•Phase shift variable range : 1–640 m*

•Type of display screen : Standard, A-scope, dual frequencies, bottom and marker zoom

•Picture sweep speed : 6 levels including pause

•Alarm : Shallow, depth and fish school

*selectable in each unit

1-2 RD-200

‘GENERAL

•Frequency coverage : 283.5 kHz to 325.0 kHz

•Type of emmision : 1K0F2B

•Antenna impedance : 50 Ωnominal

•Intermediate frequency : 455 kHz

•Usable temperature range : –20˚C to +70˚C; –4˚F to +158˚F

•Power supply requirement : 12 V DC nominal negative ground

•Current drain (at 12 V DC) : Less than 0.2 A

•Dimensions (projections not included) : 140(d)×157.2(H) mm; 51⁄2(d)×63⁄16(H) in

•Weight : 1.0 kg; 2 lb 3 oz

‘RECEIVER

•Intermediate frequency : 455 kHz

•Sensitivity : 0.2 µV at 12 dB SINAD

•Sprious response : 60 dB

•Intermodulation : 50 dB

fineline6

2 - 1

SECTION 2 INSIDE VIEWS

2-1 FP-561

• MAIN UNIT

• LOGIC UNIT

+5V regulator

(IC13: PQ05RF21)

GPS receiver

Switching control

(IC9: UPC494GS)

12V rectifier

(D13: SB30-09J)

8V rectifier

(D22: SB30-09J)

+6V regulator

Q27: 2SD1664 Q

D37: RD7.5M B1

40V rectifier

(D12: RG-2A)

Power amplifier

Q6, Q7: FS30KMJ-3

Q23, Q24: 2SC3326-B

Driver

IC2: TC4093BF

Q2, Q3: 2SC2712-GR

Q4, Q5: 2SA1162-GR

STC circuit

Q1: 2SC3326-B

Q26: 2SC2712-GR

200 kHz local oscillator circuit

IC3: TC3W03FU

X1: CR-497 (5.24MHz)

50 kHz local oscillator circuit

IC4: TC3W03FU

X2: CR-496 (4.04MHz)

Crystal oscillator

(X1: DSO-49SJ)

Main CPU

(IC1: CL-PS7500FE)

FIFO RAM

(IC20: CY7C433-40JC)

DRAM

(IC34, IC35: M5M44260CJ) SRAM

(IC30, IC31: M5M51008BVP-70LL)

Flash ROM

(IC32, IC33: MBM29F800BA-90PFTN)

Sub CPU

(IC22: TMP90PM36F)

Mail box RAM

(IC21: M66220FP)

DC-DC converter

Q4: 2SB120IS

Q5: XP6501AB

fineline6

8 - 2

• BOTTOM VIEW

GND

SW2

SW1

12V

INV

BEEP

SL0

SL1

SL2

RL0

RL1

RL2

RL3

RL4

RL5

GND

to LOGIC unit J3

J1 1

SP1

fineline6

6-9-16, Kamihigashi, Hirano-ku, Osaka, 547-0002, Japan S-13602II-CD

fineline6

Autres manuels pour FP-561

Table des matières

Autres manuels Icom Récepteur

Icom

Icom IC-R5 Manuel utilisateur

Icom

Icom IC-R71 Manuel utilisateur

Icom

Icom IC-R70 Manuel utilisateur

Icom

Icom IC-R8600 Manuel utilisateur

Icom

Icom IP501M Manuel utilisateur

Icom

Icom IC-R100 Manuel utilisateur

Icom

Icom R-71A Guide d'installation

Icom

Icom IC-R72 Manuel utilisateur

Icom

Icom IC-R7000 Manuel utilisateur

Icom

Icom IC-R2500 Manuel utilisateur

Icom

Icom IC-R7000 Manuel utilisateur

Icom

Icom IP503H Manuel utilisateur

Icom

Icom COMMUNICATIONS RECEIVER IC-R3 Manuel utilisateur

Icom

Icom IC-910H Manuel utilisateur

Icom

Icom COMMUNICATIONS RECEIVER IC-R3 Manuel utilisateur

Icom

Icom iC- r8500 Manuel utilisateur

Icom

Icom IC-R2 Manuel utilisateur

Icom

Icom IC-R20 Manuel utilisateur

Icom

Icom IC-R7100 Manuel utilisateur

Icom

Icom IP501M Manuel utilisateur

Icom

Icom iC- r8500 Manuel utilisateur

Icom

Icom MXA-5000 Manuel utilisateur

Icom

Icom IC-R1 Manuel utilisateur

Icom

Icom iC- r8500 Manuel utilisateur

Manuels Récepteur populaires d'autres marques

Garmin

Garmin GA 23 Manuel utilisateur

Aiphone

Aiphone PS-12F Manuel utilisateur

IMES

IMES TCS-01CA-PMI Manuel utilisateur

BWI Eagle

BWI Eagle AIR-EAGLE SR Manuel

AMIMON

AMIMON AMN12310 WHDI Manuel utilisateur

Dual

Dual DMCPA79BT Mode d'emploi

Sound Associates

Sound Associates SA652P Manuel utilisateur

Sherwood

Sherwood NewCastle R-772 Manuel utilisateur

Audio

Audio A10-RX Series Manuel utilisateur

AllSee

AllSee PushShare PSRV1.1 Manuel utilisateur

DEMAG

DEMAG DRC-DR D2 Manuel utilisateur

Teleco

Teleco TVRCL868A02 Manuel utilisateur

Bosch

Bosch RF3222E Manuel utilisateur

Kramer

Kramer 631R Manuel utilisateur

Xpress

Xpress xmc10 Manuel utilisateur

JVC

JVC KD-MR1BTS Manuel utilisateur

Omega Engineering

Omega Engineering UWTC-REC3 Manuel utilisateur

e-survey

e-survey E300 Pro Manuel utilisateur