HydroHoist Side-Tie B Series Manuel utilisateur

INSTALLATION

MANUAL

Side-Tie “B”

™

Pub. 8/24/04

MODEL

9/12/15/17B-MODEL

HydroHoist Boat Lifts

HydroHoist International, Inc.

P.O. Box 1286 Claremore, OK USA 74018

1-800-825-3379

HydroHoist International Inc.

HydroHoist International, Inc.

Product Installation and

Use Warning Disclaimer

ASSEMBLY, INSTALLATION OR REPAIRS OF A HYDROHOIST BOATLIFT SHOULD ONLY BE PERFORMED BY AN AUTHORIZED

HYDROHOIST TECHNICIAN. IF ASSEMBLY, INSTALLATION AND/OR REPAIR IS PERFORMED BY UNAUTHORIZED PERSONS,

SERIOUS PERSONAL INJURY AND/OR PROPERTY DAMAGE COULD OCCUR.

IF UNAUTHORIZED PERSONNEL ASSEMBLE, INSTALL OR REPAIR A HYDROHOIST BOATLIFT, HYDROHOIST INTERNATIONAL,

INC. HEREBY DISCLAIMS ANY AND ALL WARRANTIES, EXPRESSED OR IMPLIED. HYDROHOIST INTERNATIONAL, INC., LIMITS

ITS WARRANTY TO HYDROHOIST INTERNATIONAL INC.'S PUBLISHED BOATLIFT WARRANTY FURNISHED WITH EACH

PRODUCT. NO OTHER WARRANTY OF ANY KIND EITHER VERBAL OR IMPLIED INCLUDING WARRANTIES OF

MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE RECOGNIZED.

THE CONTENTS OF THIS MANUAL ARE SUBJECT TO CHANGE WITHOUT NOTICE AND SHOULD NOT BE CONSTRUED AS A

COMMITMENT, REPRESENTATION, WARRANTY OR GUARANTEE OF ANY METHOD, PRODUCT OR DEVICE BY HYDROHOIST

INTERNATIONAL, INC.

REPRODUCTION OR TRANSLATION OF ANY PART OF THIS MANUAL, WITHOUT THE WRITTEN PERMISSION OF HYDROHOIST

INTERNATIONAL, INC., IS PROHIBITED.

ANY INQUIRIES CONCERNING HYDROHOIST INTERNATIONAL, INC.’S, PUBLISHED WARRANTY OR THIS MANUAL AND ITS

CONTENTS SHOULD BE REFERRED TO:

CUSTOMER SERVICE

HYDROHOIST INTERNATIONAL, INC.

915 WEST BLUE STARR DRIVE

CLAREMORE, OK USA 74017

PHONE 918-341-6811

OFFICE HOURS M-F 8AM TO 5PM CT

HydroHoist International, Inc.

Safety Notice

TO ENSURE CONSUMER SAFETY, HYDROHOIST INTERNATIONAL, INC., HAS INSTALLED IN THE CONTROL UNIT’S ELECTRICAL

SYSTEM AN AC GROUND FAULT CIRCUIT INTERRUPTER (GFCI) DEVICE WHICH IS TO BE USED IN SERIES WITH THE USER’S PRIMARY

AC POWER SOURCE. THE GFCI IS AN INTEGRAL PART OF THE HYDROHOIST BOAT LIFT AND IS DESIGNED TO OFFER A LIMITED

MEASURE OF PROTECTION TO THE USER AGAINST HAZARDOUS ELECTRICAL CONDITIONS OR SHOCKS SHOULD THEY OCCUR.

THE USER SHOULD BE AWARE OF THE FOLLOWING WARNING:

WARNING!

IF USER DISABLES THE CONTROL UNIT’S GROUND FAULT CIRCUIT INTERRUPTER (GFCI) DEVICE,

HE IS IN DIRECT CONFLICT WITH THE RECOMMENDATIONS OF THE UNITED STATES GOVERNMENT

CONSUMER PRODUCTS SAFETY COMMISSION. DISABLING THE GFCI COULD RESULT IN SEVERE

ELECTRICAL SHOCK OR DEATH.

BEFORE CONNECTING AC POWER TO THE CONTROL UNIT, BE CERTAIN THAT THE PRIMARY AC

POWER SUPPLY MEETS ALL APPLICABLE ELECTRICAL CODES.

ANY INQUIRIES CONCERNING THE GROUND FAULT CIRCUIT INTERRUPTER (GFCI) DEVICE SHOULD BE REFERRED TO:

CUSTOMER SERVICE

HYDROHOIST INTERNATIONAL, INC.

915 WEST BLUE STARR DRIVE

CLAREMORE, OK USA 74017

PHONE 918-341-6811

OFFICE HOURS M-F 8AM TO 5PM CT

Publication 8/24/04

CONTENTS

Introduction to B-Model

Parts List - Section 1

Lift Dimensions - Section 2

Assembly Visuals/Exploded - Section 3

Getting Started - Section 4

Site Preparation & Lift Data Sheet - Section 5

Assembly - Section 6

Installation - Section 7

Final Adjustments - Section 8

Trouble Shooting - Section 9

HydroHoist International, Inc.

Model: 9/12/15/17B

Publication: 8/24/04

HydroHoist International Inc.

Introduction - I

Publication 8/24/04

Introduction to B-Model

The first objective when building a HydroHoist B-Model lift is to become acquainted with the different configurations and

sizes. An example of the nomenclature of the B-Model lifts would be BL-09-2AF-2T-STD. The descriptions for these abbreviations

are as follows.

•BL = Abbreviation for B-Model Lifts

•09 = Capacity of Lift in 1000’s of lbs. B-Models come in 9000,12000,15000,17000 lb capacities

•2AF = Signifies how many adjustable frames the lift has. B-Models can be 2 or 3 adjustable frames depending on size and hull

pad configuration

•2T = Signifies how many tanks the lift has. B-Models come in 2T and 4T configurations

•STD = Denotes frame width. There is STD = standard. WD = wide, and XWD = extra wide.

Other examples of commonly used abbreviations are:

•HP = Hull Pads

Nomenclature

Manual Walkthrough

This Installation Manual will guide you through the steps taken to successfully install a B-Model lift. The illustrations are

done in such a way to show how the component being discussed is installed and may not reflect exactly the lift you are installing.

For instance, all of the details in Fig C1-2AF-2T-WD Exploded apply to all lifts but the hull support shown is used in 9000 and

12000 B-Models. The illustration in Fig C2-3AF-4T-XWD Exploded show the hull support that is used on 15000 and 17000 B-

Models. This is one example of how you will have to be able distinguish which illustrations apply to the lift that you are installing

and which illustrations do not. Figures D1-D4 show the most common configurations for each lift to try and clear up any ambigui-

ties that there may be. Also, the optional Centering Guides and Counterweight are left out of the assembly illustrations and are

shown at the end of the Section 6-Assembly.

Important Notice

The Tank Band Settings given in this manual are generic. The distances between any frames with hull pads attached must

be maintained but freedom is given on 3 frame lifts for the front frame placement if another position better suits the boat. Flexibility

is also given for the positioning of the tanks relative to the frames. This dimension should be specific to the boat being lifted. In

general a boats center of gravity (Cg) is approximately 1/3 of the total length. So on a 36’ boat its Cg would be 12’ from the tran-

som. In some cases, such as multiple engine configurations, the Cg is shifted further towards the transom. In these cases the Cg is

usually 1/4 of the total length. So a 40’ multiple engine boat would have a Cg approximately 10’ from the transom. These equations

should be applied to the specific boat being lifted and the Tank Band Settings should be adjusted accordingly. On two tank lifts this

is easily done by verifying that the center of the tanks is aligned with where the approximate Cg of the boat will be when it is posi-

tioned on the lift. The 4T lifts are more difficult but the smaller tanks stay fixed relative to the frames so the outer tanks are the ones

that need to be adjusted to fit the boat. The settings given on a 15B are for a boat with a Cg of 8’ and the settings given for the 17B

are for a boat with a Cg of 9’. Using this information adjust the tank band dimensions “A” accordingly to fit the specific boat being

lifted. It is very difficult to adjust this dimension after the lift is installed so be sure to think these steps through before tightening the

tank bands.

Parts List

Sec. 1 Pg. 1

Parts List

HydroHoist International, Inc.

Model: 9/12/15/17B

Publication: 8/24/04

BL-09-2AF-2T-STD

BL-09-2AF-2T-WD

BL-12-2AF-2T-STD

BL-12-2AF-2T-WD

BL-12-2AF-2T-XWD

BL-12-3AF-2T-STD

BL-12-3AF-2T-WD

BL-12-3AF-2T-XWD

BL-15-3AF-2T-WD

BL-15-3AF-2T-XWD

BL-15-3AF-4T-WD

BL-15-3AF-4T-XWD

BL-17-3AF-4T-WD

BL-17-3AF-4T-XWD

5014800 TANK ASSY - 32"X23'B 2 2

1B 5014201 TANK ASSY - 32"X32'B 2 2 2 2 2 2 2 2 2 2

5012600 TANK ASSY - 32"X38'B 2 2

5010310 TANK ASSY - 24"X23'B 2 2

2B 5010200 TANK ASSY - 24"X16'

4260055 16' HULL PADS 2 2

3B 4260060 20' HULL PADS 2 2 2

42700609'HDHULLPADS 222222222

4260035 V BRACKET - TUBE SUPT 1 1 1 1 1

4B 4667200VBRACKET-20/30B 111111111

5 4260045 TUBE - UPPER 2" TUBE 6 6 6 6 6 6 6 6 6 6 6 6 6 6

6 4270160 PAD MOUNT - RECIEVE

44444444444444

7 4660160 PAD SUPPORT - LOWER ASS

66666666222222

4660150 PAD SUPPORT - UPPER ASSY (STD,WD) 6 6 6 6 6 6222

8B 4660130 PAD SUPPORT - UPPER ASSY (XWD) 6 6 2 2 2

4270071 WELDMENT - PAD MOUNT 4 4 4 4 4 4

8D 4270072 WELDMENT - PAD MOUNT - OPP 4 4 4 4 4 4

9 4270073 WELDMENT - BRACE 4 4 4 4 4 4

4660700 TANK BAND - BIG B LOWE

8 8 8 8 8 12 12 12 12 12 12 12 12 12

4666700 TANK BAND - BIG B UPPE

44444666666666

10B 3056200 TANK BAND - 24" LOWE

4466

11B 4050100 TANK BAND - 24" UPPE

4466

4665600 ADJUSTABLE FRAME CENTER STD 2 2 3

12B4665900ADJUSTABLEFRAMECENTERWD 22 3333

4668600 ADJUSTABLE FRAME CENTER XWD 2 3 3 3 3

13 2810000 WALKWAY 10' MODULE 4 4 4 4 4 4 4 4 4 4 4 4 4 4

14 2815000 WALKWAY 5' MODULE 2 2 4 4 4 4 4 4 4 4 4 4 4 4

15 4812095 HINGE BASE - UNIV BIG B 4 4 4 4 4 4 4 4 4 4 4 4 4 4

16 4812060 HINGE ASSY WALKWA

44444444444444

17 4812025 HINGE GRIP ASS

88888888888888

18 4812030HINGEGRIPBRACE 44444444444444

19 4812070HINGEPIN101/2" 88888888888888

20 4812085 WALKWAY SPACER - 3FRAME 2 2 2 2 2 2 2 2 2

21 4666100 EURO MOORING ASS

22222222222222

22 4666150EUROMOORINGCOVER-BIGB 22222222222222

23 4669165 EURO MOORING SLIDE

22222222222222

24 3550028CONTROLUNIT-4V-2M(PLASTICMAN.) 11111111111111

25 3072502HOSE75' 11111111111111

3072504 HOSE 10' 1111

3072507HOSE40' 11111111111111

6921652 PARTS BAG - 2FRAME LP 1 1

6921751 PARTS BAG - 12B 1 1 1 1 1 1

6921752 PARTS BAG - 15B 2T 1 1

6921753 PARTS BAG - 15B 4T 1 1

6921754 PARTS BAG - 17B 11

6921850 PARTS BAG - BIG B - XW

6937500 PARTS BAG - CABLE ASSY 9/12/15/20 1 1 1 1 1 1 1 1 1 1 1 1 1 1

6937100 PARTS BAG - WALKWAY 45/75/9

6937200 PARTS BAG - WALKWAY 12/15/17 1 1

6937225 PARTS BAG - WALKWAY 12B 2 FRAME 1 1 1

9/12/15/17 B-MODEL

PARTS

TANKS

HULL PAD

BRACKET

HULL SUPPORT

TANK BANDS

FRAME COMPONENTS

WALKWAY COMPONENTS

MOORING COMPONENTS

CONTROL UNIT

HOSE

PARTS BAGS

Parts List

Sec. 1 Pg. 2

Parts List

End of Section 1

HydroHoist International, Inc.

Model: 9/12/15/17B

Publication: 8/24/04

26 4668090CENTERINGGUIDE-LH 22222222222222

4668095CENTERINGGUIDE-RH 22222222222222

27 5027802COVER-9'CENTERINGGUIDE 44444444444444

OPTIONAL CENTERING GUIDE COMPONENTS

Lift Dimensions

Sec. 2 Pg. 1

Lift Dimensions

HydroHoist International, Inc.

Model: 9/12/15/17B

Publication: 8/24/04

Fig. A

Lift Dimensions

Sec. 2 Pg. 2

Lift Dimensions

End of Section 2

HydroHoist International, Inc.

Model: 9/12/15/17B

Publication: 8/24/04

Fig. B

Front of Hoist

Assembly Visuals

Sec. 3 Pg. 1

HydroHoist International, Inc.

Model: 9/12/15/17B

Publication: 8/24/04

Fig. C1-Exploded-2AF-2T-WD

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels HydroHoist Système de levage

HydroHoist

HydroHoist HarborHoist HH-20,000 V-HULL V-FRAME Manuel utilisateur

HydroHoist

HydroHoist HarborHoist G1.5 Manuel utilisateur

HydroHoist

HydroHoist HarborHoist Series Manuel utilisateur

HydroHoist

HydroHoist LevelLift L Series Guide de démarrage rapide

HydroHoist

HydroHoist UltraLift FRONT MOUNT Series Manuel utilisateur

HydroHoist

HydroHoist HraborHoist G1.5 Manuel utilisateur

HydroHoist

HydroHoist HarborHoist Triton Manuel utilisateur

HydroHoist

HydroHoist HarborHoist 4400 Manuel utilisateur

HydroHoist

HydroHoist HydroPort EPIC Manuel utilisateur

HydroHoist

HydroHoist 4400 FM Manuel utilisateur

HydroHoist

HydroHoist UltraLift Series Manuel utilisateur

HydroHoist

HydroHoist FM 6000 Manuel utilisateur

Manuels Système de levage populaires d'autres marques

morse

morse 82H-124 Manuel utilisateur

Braun

Braun NL955 Series Manuel utilisateur

haacon

haacon 1889.10 Manuel utilisateur

Protekt

Protekt AT 252 Manuel utilisateur

R. Beck Maschinenbau

R. Beck Maschinenbau HS 600 Manuel utilisateur

Nova Technology International, LLC

Nova Technology International, LLC NAS Series Manuel utilisateur

Genie

Genie Z-60/34 Manuel utilisateur

Screen Technics

Screen Technics INTERFIT Vertical Up Lift Manuel utilisateur

Mortuary Lift

Mortuary Lift ULTIMATE 1000 Manuel utilisateur

Custom Equipment

Custom Equipment Hy-Brid 3 Series Manuel de programmation

Custom Equipment

Custom Equipment Hy-Brid Lifts 2 Series Manuel de programmation

Hy-Brid Lifts

Hy-Brid Lifts HB-P3.6 Manuel de programmation

BERG

BERG BeNomic EasyLeaf Manuel utilisateur

Powermate

Powermate LiftGate LG-3 Manuel utilisateur

Snorkel

Snorkel TM12 Series Manuel utilisateur

Terberg

Terberg OMNIDEKA Manuel utilisateur

Harmar Mobility

Harmar Mobility AL625 Mode d'emploi

Rotary

Rotary SPO16 Manuel utilisateur