Hitachi L22DP03C Manuel utilisateur

CAUTION:

Before servicing this chassis, it is important that the service technician read the “Safety

Precautions” and “Product Safety Notices” in this service manual.

ATTENTION:

Avant d’effectuer l’entretien du châssis, le technicien doit lire les «Précautions de sécurité»

et les «Notices de sécurité du produit» présentés dans le présent manuel.

VORSICHT:

Vor Öffnen des Gehäuses hat der Service-Ingenieur die „Sicherheitshinweise“ und „Hinweise

zur Produktsicherheit“ in diesem Wartungshandbuch zu lesen.

SERVICE MANUAL

MANUEL D'ENTRETIEN

WARTUNGSHANDBUCH

DatacontainedwithinthisService

manual is subject to alteration for

improvement.

Les données fournies dans le présent

manuel d’entretien peuvent faire l’objet

de modifications en vue de perfectionner

le produit.

DieindiesemWartungshandbuch

enthaltenen Spezifikationen können sich

zwecks Verbesserungen ändern.

SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT

Colour Television

May 2009

No. 0253

L22DP03C

L22DP03U

FOR ALL PARTS PLEASE MAKE

CONTACT WITH ASWO.

FOR YOUR LOCAL OUTLET GO TO

www.aswo.com

TABLE OF CONTENTS

1 INTRODUCTION.........................................................................................................................................3

2 GENERAL DESCRIPTION ........................................................................................................................3

3 POWER STAGE................. ..........................................................................................................................4

4MICROCONTROLLERPORT CONFIGURATION...............................................................................4

5 SIDE BOARDS AND CONNECTORS .......................................................................................................5

5.1 Keypad ......................................................................................................................................... 5

5.2 Infrared& LED ........................................................................................................................... 6

5.3 DVB-T ......................................................................................................................................... 6

5.4 DVD .............................................................................................................................................8

5.5 LVDS .......................................................................................................................................... 9

5.6 IPS POWER CARD.....................................................................................................................9

6 IC SPECIFICATIONS ...............................................................................................................................10

6.1Microcontoller/Video&Audio Processor (VCT4953G) ............................................................10

6.2 Scaler/De-interlacer (MST-TSUMU38BF) ................................................................................13

6.3 Audio Stage (LM358D,MP7721)................................................................................................. 16

6.4 HeadPhone Amplifier (TDA1308T) ...........................................................................................16

6.5Audio Matrix Switch (TEA6422D)............................................................................................ 19

6.6HDMI Receiver (ANX9021) ....................................................................................................... 19

6.7 Video Switch (PI5V512) .............................................................................................................. 20

6.8Tuner (DTT71306) ...................................................................................................................... 21

6.9 SAW Filter (X6966M) ............................................................................................................... 22

6.10 I2C Switch (74HCT4053) ..........................................................................................................22

6.11 Audio DAC (CS4334) ............................................................................................................... 23

6.12 IC EEPROM 24LC02 2Kbx8.................................................................................................... 24

6.13 SPDIF Switch (NLAST4599) .....................................................................................................24

6.14 17MB29 Block Diagram.............................................................................................................26

1 INTRODUCTION

The purpose of this document is to define the operation of 17MB29 chassis, capable of driving 22”

TFT LCD panel. It is aimed to provide information to engineering staff to understand the operation and specs

of the TV. The other related technical documents are given in Table1:

Title

1 17MB29 schematics

2 IR receiver and LED display board schematics

3 Keypad board schematics

4 DVD module card schematics

5 DVB-T module card schematics

Table1.1: Related documents

2 GENERAL DESCRIPTION

The system is a low to mid end; 22” 1680 x 1050 TFT TV solution basically for EU market with

VCT4913G microcontroller / video audio processor chip on a 2-layer PCB. Since the target market is EU, the

first release of the TV will support PAL/SECAM B/G/D/K/I/L/L’. The target panel is 22” W 1680 x 1050

TFT-LCD panels. A DVD loader is used to read DVD content and a DVB-T module card is used to support

DVB-T.

Inputs

• 1xTuner (both analog and DVB-T)

• 1xDVD

• 1xScart

• 1xPC (VGA)

• 2xHDMI (optional)

• 1xBack AV (optional)

• 1xSIDE YPBPR (optional)

Outputs

• Speaker (stereo, 2x4 Ω, 2x4Watt)

• Headphone (stereo) (optional)

• Audio line out (stereo and mono) (optional)

• DVD/DVB-T coaxial SPDIF out(optional)

General default features

• Multi System Reception: PAL-SECAM BG-DK-I/I’-L/L’

• Menu system (multi language)

• 100 program storage locations

• OSD (on-screen display)

• Teletext

• IR Control (RC5 and other customer specific protocols)

• “No Ident” Timer

• Child Lock

• Sleep Timer

• WSS (16:9/4:3 Aspect Ratio Auto Switch)

Sound Features

• Equalizer

• FM Radio

• Linear Stereo

• German-NICAM Stereo

• 5-Band Equalizer Control

• SRS TRU Surround (OPT)

• SRS TRU Bass (OPT)

• BBE, WOW (OPT)

Picture Features

• WIDE PANEL---4:3,16:9, Auto(opt), Subtitle(opt), Zoom(opt), Panoramic(opt)

• Picture Modes ( Bright, Standard, Soft)

• Media Window Enhancement (MWE)

• Backlight brightness setting (movie/normal/bright)

• Multi System Reception : PAL-SECAM BG-DK-I/I’-L/L’

• NTSC Video Playback

• WSS (16:9 / 4:3 Aspect Ratio Auto Switch)

• Channel Type Sorting (Favorite/Sport/Music/News/Movie)

Tuning Options

• FST

• Frequency Search (Optional)

• APS (Auto Search/Name/Sort)

• Auto Search

• CATV/HYPERBAND

Keyboard

• Volume -/ +Button

• Program -/+ Button

• Menu Button

• TV / AV Button

Teletext/OSD

• Simple Text 10 Pages

• Fastext & Top Text (OPT)

• Teletext Languages (ALL)

• Character Based OSD

Electrical features

•IPS generates 12V and 5V DC supply.

•<1W standby power consumption

System Building Blocks

17MB29 chassis main blocks are as follows:

•Analog Front End : VCTI (Microcontroller+Video Proccessor+Audio Proccessor+IF

Demodulator+ Teletext Decoder+ OSD Generator)

•Back End : MST-TSUMU38BF(Scaler, Deinterlacer, OSD Generator)

Analog Front End

17MB29 main board consists of two major blocks. The first block is analog front-end and this

block is handled by VCTI chip that is highly multifunctional. VCTI performs Tuner IF demodulation,

CVBS, RGB, SVHS and audio input selection and processing. The audio processor (MSP) supports

equalizer, tone control, volume control, AVL, surround effect etc. The video processor (VSP) handles

video processing such as color standard detection and demodulation, picture alignment (brightness,

contrast, color etc.). The IC also has a teletext decoder with fastext memory. The processed video output

is sent to MST-TSUMU38BF, scaler/deinterlacer in RGB format together with a composite sync.

The TV tuner is PLL controlled symmetrical IF output type. The IF signal is filtered by a single

SAW filter. Inter-carrier sound demodulation is performed by the system. After the SAW filter block, IF

signal is processed by VCTI IF demodulator. Audio signal is digitally filtered in the IF demodulator

block. The same IF signal is buffered and sent to DVB-T module card, tdm1300.Since VCTI can handle

all the audio processing, there is no need for additional audio processor solution on the board.

MSP has two audio inputs which are assigned to the Scart in L/R and Audio Switch L/R output.

MSP has three audio outputs which are assigned to the headphone amplifier L/R input, audio amplifier

L/R input and Audio switch L/R input. The board employs MP7721 and TDA1308 to drive speaker and

headphone outputs, respectively. Switching control for other audio inputs and outputs (HDMI, Back AV,

PC, DVD, and DVB-T) is achieved by an I2C controlled audio switch (TEA6422).

Back End

MST-TSUMU38BF has two ADC inputs. First ADC input is assigned to the VCTI RGB output.

Other RGB/YPbPr inputs are multiplexed for the second ADC input. HDMI receiver ANX9021 analog

output, VGA RGB input and the synchronization signals are multiplexed by a primary RGB switch

(PI5V512). MST-TSUMU38BF has an embedded LVDS transmitter. There are three PWM output ports.

PWM0 is assigned to analog/digital dimming control for the backlight, PWM1 is used for backlight

on/off and panel logic power supply on/off control and PWM2 is used to control PC/HDMI switch IC

(PI5V512).

3 POWER STAGE

The DC voltages required at various parts of the chassis and inverters are provided by a main power

supply unit and power interface board. IPS generates 12V and 5V DC supply. Power stage which is

on-chasis generates +12V for audio amplifier and 5V stand by voltage and 33V, 12V, 5V, 3.3V and 1.8V

supplies for other different parts of the chassis.

4 MICROCONTROLLER PORT CONFIGURATION

PORT

NAME

SIGNAL NAME TYPE FUNCTION

47 P10 MST_RESET O Scaler reset

PROTECT I Short circuit detection

48 P11 TV_RXD I IDTV UART receive signal

49 P12 TV_TXD O IDTV UART transmit signal

50 P13 IRQ O IDTV interrupt request signal

51 P14 KEY I Keyboard function select

52 P15 SC_PIN8 I Scart function select

53 P16 DVD_IR_ON/OFF O DVD infrared signal on/off control

54 P17 POWCON O Standby on/off control

PORT

NAME

SIGNAL NAME TYPE FUNCTION

55 P20 HDMI_HP_INV O HDMI hot plug signal

56 P21 CS O Switching control for Mstar bus and system I2C

62 Safety VCTI_HS O VCTI composite sync output

78 FBIN DVD_SENSE I DVD module detection

85 Vert+ TV/DVB_SW O IDTV/TV I2C and AGC switch control for tuner

27 P22 WP O Write protection control for NVM

28 P23 IR I Infrared input

Table 4.1 VCTI port configuration

5 SIDE BOARDS & CONNECTORS

5.1 Keyboard

A four-pin connector is used between 17mb29 and the keyboard:

KEY signal is sent directly to microcontroller ADC port and depending on the voltage level of

KEY signal, microcontroller performs one of these actions: menu, program+, program-, volume+,

volume- and source.

SOFT_SW signal is used to switch between “power-off” and “standby” modes.

5.2 Infra-red & LED

A five-pin connector is used between 17MB29 and the LED board: Pin2 and pin3 carry the control

signals for the LED. Pin4 carries the infra-red signal to the microcontroller. Pin5 is used to power up the

LED board.

5.3 DVB-T module board

DVB-T module board (TDM1300) is used to receive digital terrestrial broadcast signals. Three

cables are used to connect 17MB29 and TDM1300: power, data and IF.

12V (500mA) is sent to TDM1300 by power cable:

Analog RGB(YPbPr), CVBS, stereo audio, tuner control (SCL, SDA, AGC), and three GPIO port

outputs of TDM1300, together with UART ports (TV_RXD, TV_TXD, IRQ) are carried by data cable.

TDM1300 board has no tuner on it. Instead, the tuner of 17MB29 is used for both analogue and

digital reception. Tuner is controlled by either the 17MB29 microcontroller (VCTI), or TDM1300 board

microcontroller. The IF (intermediate frequency) output of the tuner is sent to TDM1300 board for digital

reception.

5.4 DVD module board

DVD module board has two parts: a loader and an electronic card. Electronic card controls the

loader and has connections with 17MB29 and DVD keypad.

Three cables are used to connect 17MB29 and DVD electronic card: power, data and sense.

12V (500mA) is sent to DVD electronic card by power cable:

Y/C and/or CVBS video, stereo audio outputs and infra-red input of DVD module board is carried on

data cable:

When a DVD is inserted into the loader, the DVD electronic card sends an interrupt signal

(DVD_SENSE) to the 17MB29 microcontroller:

Autres manuels pour L22DP03C

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Hitachi TV

Hitachi

Hitachi 40C311 Manuel utilisateur

Hitachi

Hitachi Ultravision C55M6 Manuel utilisateur

Hitachi

Hitachi CL2848TAN Manuel utilisateur

Hitachi

Hitachi C24W430N Manuel utilisateur

Hitachi

Hitachi CP2155TA Manuel utilisateur

Hitachi

Hitachi C2125T/S Manuel utilisateur

Hitachi

Hitachi 31CX4B, 31UX5B Manuel utilisateur

Hitachi

Hitachi 27CX01B Manuel utilisateur

Hitachi

Hitachi ULTRAVISION LE22S314 Instructions de montage

Hitachi

Hitachi 31KX39K, 31GX31B, 31DX21B, 31D Manuel utilisateur

Hitachi

Hitachi CMT2988-981 Manuel utilisateur

Hitachi

Hitachi C1421R Manuel utilisateur

Hitachi

Hitachi 50HB6T72U Manuel utilisateur

Hitachi

Hitachi 48hk6t64u Manuel utilisateur

Hitachi

Hitachi 51F510 DP43 Manuel utilisateur

Hitachi

Hitachi C1422R Manuel utilisateur

Hitachi

Hitachi C29-F880SN Manuel utilisateur

Hitachi

Hitachi 55DMX01W Manuel utilisateur

Hitachi

Hitachi CG1426T Manuel utilisateur

Hitachi

Hitachi 32C11 Manuel utilisateur

$Hitachi 36UX52B\CZ77 Manuel utilisateur$

Hitachi

Hitachi 36UX52B\CZ77 Manuel utilisateur

Hitachi

Hitachi 27CX0B Manuel utilisateur

Hitachi

Hitachi C2524T Manuel utilisateur

Hitachi

Hitachi 31GX31B/CY35 Manuel utilisateur

Manuels TV populaires d'autres marques

Philips

Philips Colour Television Manuel utilisateur

Toshiba

Toshiba 27A10 Manuel utilisateur

Philips

Philips 42PF9630A/37 Manuel utilisateur

DAEWOO ELECTRONICS

DAEWOO ELECTRONICS DTQ-14V1FC Manuel utilisateur

Changhong Electric

Changhong Electric uhd55b6000is Manuel utilisateur

Philips

Philips Matchline 21CE7551 Manuel utilisateur

Panasonic

Panasonic Genus TX-G10 Manuel utilisateur

Toshiba

Toshiba 19A20 Manuel utilisateur

Philips

Philips 25PT4523-16 Manuel utilisateur

Sony

Sony XBR-100Z9D Manuel utilisateur

Philips

Philips PR0930X3 Manuel utilisateur

Philips

Philips Brilliance 231P4QPY Manuel utilisateur

Samsung

Samsung 55S9 B Series Manuel utilisateur

Philips

Philips 32HF9385D Guide de dépannage

Sharp

Sharp LC-40FI5012E Manuel utilisateur

Loewe

Loewe Table Stand Reference 55 Manuel utilisateur

Philips

Philips 32PFH5300 Manuel utilisateur

Sylvania

Sylvania 6427FB Manuel utilisateur