Hiland SPOA Manuel utilisateur
1
Quesons, problems, missing parts? Before returning to your retailer, call our customer
service department at 1-888-775-1330, 8 a.m. - 4 p.m., PST, Monday - Friday.
TABLE OF CONTENTS
Safety Information .................................................................................................. 3
Expanded Diagram.......................................................................... 5
Assembly Instructions.................................................................................... 7
Parts List ........................................................................................................ 6
Gas Cylinder Use............................................................................................14
Operating Instructions.................................................................................... 15
Care and Maintenance................................................................................................. 17
Warranty......................................................................................................................19
2
SAFETY INFORMATION
Please read and understand this enre manual before aempng to assemble,
operate or install the product.
1. The installaon of this appliance must conform with local codes or, in the absence
of local codes, with either the Naonal Fuel Gas Code, ANSI Z223.1/NFPA 54, or
Natural Gas and Propane Installaon Code, CSA/CGA-B149.1.
2. This oven is intended for use outdoors and should not be used in a building,
garage or any other enclosed or covered area.
3. This outdoor oven is not intended for installaon in or on recreaon vehicles and
/or boats.
4. A minimum clearance of 61 cm (24 inches) from combusble construcons to the
sides of the grill and 61 cm (24 inches) from the back of the grill to combusble
construcons must be maintained.This outdoor cooking gas appliance must not be
placed under overhead combusble construcon.
5. The use of an electrical source requires that when installed, the grill must be
electrically grounded in accordance with local codes or, in the absence of local
codes.
6. Inspect the hoses before each use for excessive abrasion or wear, or cuts that may
affect safe operaon of the grill. If there is evidence of excessive abrasion or wear, or
the hose is cut, it must be replaced prior to the grill being put into operaon. The
replacement hose assembly must be those specified by the manufacturer.
7. Keep your oven in an area clear and free from combusble materials gasoline and
other flammable vapors and liquids.
8. DO NOT obstruct the flow of combuson and venlaon air to this appliance.
9. Keep the venlaon openings of the tank enclosure free and clear from debris.
10. Check all gas connecons for leaks with a soapy water soluon and brush. Never
use an open flame to check for leaks.
11. Never use charcoal in the oven.
12. Never use the grill in windy areas.
13. Never use the grill without the drip tray installed and hung under the burner box.
Without the drip tray, hot grease and debris could leak downward and produce a fire
hazard.
14. Use only the gas pressure regulator supplied with this appliance.
15. The cylinder used must include a collar to protect the cylinder valve.
16. Do not store a spare LP-gas cylinder under or near the appliance.
17. Never fill the cylinder beyond 80 percent full.
18. If the informaon in “17”and “18”is not followed exactly, a fire causing death or
serious injury may occur.
19. The outdoor cooking gas appliance must be isolated from the gas supply piping
system by closing its individual manual shut off valve during any pressure tesng of
3
the gas supply system at test pressures equal to or less than 1/2 psi (3.5 kPa).
20. CALIFORNIA PROPOSITION 65 WARNING: The burning of gas cooking fuel
generates some by products that are on the list of substances known by the State of
California to cause cancer, reproducve harm, or other birth defects. To reduce
exposure to these substances, always operate this unit according to the use and care
manual, ensuring you provide good venlaon when cooking with gas.
——————————————————————————————————
IMPORTANT: We urge you to read this manual carefully and follow the
recommendaons enclosed. This will ensure you receive the most enjoyable and
trouble-free operaon of your new gas grill. We also advise you retain this manual
for future reference.
——————————————————————————————————
WARNING: Your grill has been designed to operate using only the gas specified by
the manufacturer on the rang plate. Do not aempt to operate your grill on other
gases. Failure to follow this warning could lead to a fire hazard and bodily harm and
will void your warranty.
——————————————————————————————————
WARNING: Make certain your LP (propane) tank is filled by a reputable propane
dealer. An incorrectly filled or an overfilled LP tank can be dangerous. The overfilled
condion combined with the warming of the LP tank (a hot summer day, tank lein
the sun, etc.) can cause LP gas to be released by the pressure relief valve on the tank
since the temperature increase causes the propane to expand. LP gas released from
the tank is flammable and can be explosive. Refer to your Owner’s Manual for more
informaon concerning filling your LP tank.
4
5
Expanded Diagram
Parts List
NO
PART NAME
QTY
1
CHIMNEY
1
2
OVEN DOOR HINGE
2
3
HEAT SPACER
4
4
BACK HEAT-SHIELD
1
5
BACK PANEL
1
6
EXTERIOR
1
7
INTERIOR ASSEMBLY
1
8
LATCH
1
9
GAS PIPE JOINT
1
10
GAS PIPE
1
11
WHEEL
2
12
CART SUPPORT
1
13
WHEEL AXLE
1
14
CHECK NUT
2
15
CART BOTTOM PLATE
1
16
CART FRONT PLATE
1
17
LEG R
2
18
RUBBER FOOT
2
19
LEG L
2
20
GREASE TRAY HOLDER
1
21
GREASE TRAY
1
22
HANDLE
1
23
GLASS DOOR HANDLE
1
24
KNOB
1
25
KNOB BEZEL
1
26
THERMOMETER
1
27
IGNITER
1
28
GLASS DOOR
1
29
VALVE
1
30
CONTROL PANEL
1
31
OVEN FRONT PANEL
1
32
HEAT SHIELD
1
33
PIZZA STONE
1
34
BOTTOM GRILL
1
35
BURNER
1
36
FLAME TEMPER
1 (oponal accessories)
37
COOKING GRILL
2
38
SMOKER BOX ASSEMBLY
1 (oponal accessories)
6
ASSEMBLY INSTRUCTIONS
Before beginning assembly of product, make sure all parts are present. Compare
parts with package contents list and hardware contents list. If any part is missing or
damaged, do not aempt to assemble the product.
Assembly p! (Please lightly ghten the screws during assembly of the cart. When
the cart is completed THEN TIGHTEN ALL THE screws. This will make it easier to
align the holes properly)
STEP 1
Use 16 M6*10 Screws and 16 M6 nuts to aach the 4 Legs to the Cart boom
plate as shown.
Put 2 Rubber feet on le legs.
7
STEP 2
Use 2pcs check nut to assemble the wheel and wheel axle as shown.
8
STEP 4
Use 4 M6*10 screws and 4 M6 nuts to assemble the handle as shown.
9
STEP 3
Use 6 M6*10 screws and 6 M6 nuts to assemble the Cart Front Panel to the Cart Legs.
STEP 6
Use 3 M4*12 screws to assemble the chimney as shown.
10
STEP 5
Use 4 M6*10 screws and 4 M6 nuts to assemble the body and the cart as shown,
use bolt to ghten.
Ce manuel convient aux modèles suivants
2
Table des matières
