Harmar Mobility AL030 Mode d'emploi

Read and understand this manual thoroughly before

attempting to install or operate the lift. If you have any

questions, please contact your Authorized Harmar Dealer or

Harmar’s Technical Service Department.

1]']5&$)!)"3."3$0.

Dealer Name & Contact Information:

Serial # of Your Lift:

0VUTJEF-JGUT

Installation & Owner’s Manual XXXIBSNBSDPN]

"-1PXFS5PUF'PMEJOH

.BOVBM8IFFMDIBJS-JGU

Capacity: 100 lbs

"-.JDSP

1PXFS$IBJS4DPPUFS-JGU

Capacity: 135 lbs

"-.JDSP4DPPUFS-JGU

Capacity: 100 lbs

"-6OJWFSTBM-JGU

Capacity: 350 lbs

"--PX1SPMF

6OJWFSTBM4DPPUFS-JGU

Capacity: 350 lbs

"-6OJWFSTBM

4DPPUFS1PXFS$IBJS-JGU

Capacity: 350 lbs

"-3737-JGU

4DPPUFS1PXFS$IBJS-JGU

Capacity: 350 lbs

"-

6OJWFSTBM1PXFS$IBJS-JGU

Capacity: 350 lbs

"-9-&YUSB8JEF

6OJWFSTBM1PXFS$IBJS-JGU

Capacity: 350 lbs

"-"VUP)PME%PXO

1PXFS$IBJS-JGU

Capacity: 350 lbs

"-9-"VUPNBUJD

&YUSB-BSHF1PXFS

$IBJS-JGU

Capacity: 350 lbs

"-"VUP

1PXFS$IBJS-JGU

Capacity: 350 lbs

"-&YUSB-BSHF

1PXFS$IBJS-JGU

Capacity: 350 lbs

"-1PXFS$IBJS-JGU

Capacity: 350 lbs

"-9-&YUSB-BSHF

1PXFS$IBJS-JGU

Capacity: 350 lbs

"-4&-

1PXFS$IBJS-JGU

Capacity: 250 lbs

"-44

1PXFS$IBJS-JGU

Capacity: 250 lbs

"-)%)FBWZ%VUZ

4DPPUFS-JGU

Capacity: 400lbs

"-)%)FBWZ%VUZ4DPPUFS

1PXFS$IBJS-JGU

Capacity: 400 lbs

"-)%)FBWZ%VUZ

1PXFS$IBJS-JGU

Capacity: 400 lbs

"-9-)%&YUSB8JEF

)FBWZ%VUZ1PXFS$IBJS-JGU

Capacity: 400 lbs

TEC0093 160406 P/N: 610-00045 Rev B

| www.harmar.com | 800-833-0478



$POUFOUT

/05&The following symbols indicate areas where you should take

special care to avoid danger to individuals or property.

4FDUJPO0XOFS

OPERATING YOUR LIFT

General Operation.................................3

AL010/050 and AL030 Micro Lifts .....6

AL570 & AL570XL Lifts..........................7

Using a Swing-Away..............................8

Manual Override.................................. 10

SAFETY & MAINTENANCE 11

4FDUJPO*OTUBMMFS

PREPARATION

Tools Required............................................13

Unpacking the Lift.....................................14

Installation Overview ...............................15

INSTALLATION

Wiring the Vehicle .....................................17

Vehicle Hitch................................................19

Hitch Adapters...........................................2

Lift Installation

Hitch Post Mount .........................2

AL030 Bumper Mount......................2

Swing-Away ........................................2

AL030 Power Tote Ball Mount........2

CHAIR PREPARATION 27

Anchor Plate .........................................2

U-Bolt Kit................................................2

LIFT ADJUSTMENTS

AL015/AL100/AL100HD/AL160

AL010/050 and AL030 .........................3

AL560 & AL560XL................................3

AL560 & AL580 Hold-Down Arm...3

AL570 & AL570XL Chair Plow ..........3

Dock ‘N’ Lock: AL570 & AL570 XL3

TROUBLESHOOTING 3

EXPLODED VIEWS

AL030 ......................................................

AL010/050 ..............................................4

AL015 ........................................................4

AL100.......................................................

AL160.......................................................4

AL300 ......................................................4

AL300RV.................................................4

AL301XL..................................................4

AL500 ......................................................4

AL560 ......................................................4

AL560XL .................................................

AL570 ......................................................5

AL570XL..................................................5

AL580 ......................................................5

AL580XL .................................................5

AL585SEL................................................5

AL585SS..................................................5

AL100HD ................................................5

AL300HD................................................5

AL301XLHD............................................5

AL500HD................................................

ELECTRICAL HARDWARE 6

WARRANTY 63

WARNING

Hazardous situation. If not avoided,

could result in serious injury to

installer or user.

CAUTION!

Hazardous situation. If not

avoided, could result in serious

damage to property.

TEC0093 160406 P/N: 610-00045 Rev B

0VUTJEF-JGUT*OTUBMMBUJPO0XOFST.BOVBM 

SECTION 1 : OWNER 0QFSBUJOH:PVS-JG

(&/&3"-01&3"5*0/

 -08&3*/(5)&-*'5

Insert key and switch to ‘ON’ position.Press

‘DOWN’ on toggle switch. The platform will

unfold. Continue to lower until platform reaches

the ground and becomes level. <'JHVSF>

%0/05 over-lower to the point where the

vehicle begins to rise. This will damage the lift.

*.1035"/5

Positioning the chair properly on the platform is

critical to ensure it is properly locked onto the lift.

Always verify wheels are captured by cradles

or bars. Please consult your dealer on the specics

of your application.

'JHVSF

'JHVSF

 %3*7&$)"*30/501-"5'03.

Drive slowly, stopping when the drive wheels fall

between the platform bars on the side or center

depending on the lift and chair model. <'JHVSF>

TEC0093 160406 P/N: 610-00045 Rev B

| www.harmar.com | 800-833-0478



SECTION 1 : OWNER

0QFSBUJOH:PVS-JGU

 4&$63*/(5)&$)"*3

Depending on your lift model and the type of securement device it uses, you may

wish to raise the platform halfway, using the ‘UP’ toggle switch, in order to avoid

having to bend over while you attach straps or ip the chair’s armrest out of the way

of the hold-down arm. <'JHVSF>

'JHVSF

'JHVSF

 3"*4*/(5)&-*'5

When the chair is secure, use the ‘UP’ toggle

switch to continue raising the lift. Stop when

it reaches the top of travel when you hear the

clutch sound. Twist the key to remove.

<'JHVSF>

TEC0093 160406 P/N: 610-00045 Rev B

0VUTJEF-JGUT*OTUBMMBUJPO0XOFST.BOVBM 

SECTION 1 : OWNER 0QFSBUJOH:PVS-JG

'JHVSF

$"65*0/

These are general

instructions. Specics may

vary based on your chair

model and lift combination.

Please follow the specic

instruction suggested by

your dealer.

$"65*0/

"MXBZT verify the chair or

scooter is held rmly in place

prior to transport.

t"MXBZT run the lift fully to the top

for transport. The lift will make a

ratcheting sound which indicates

that all mechanisms are locked and

prepared for travel.

t/FWFS attempt to move the vehicle

without the lift being in the full up or

stowed position. This may damage the lift.

t%SJWFTMPXMZ over rough terrain such as

pot holes, unpaved roads, railroad tracks.

Excessive loads from rough driving will

damage your lift and is not covered by

the warranty.

t*GZPVOPUJDFBOZEBNBHFTUPQVTJOH

UIFMJGUJNNFEJBUFMZ Do not attempt

to transport a chair or scooter with a

compromised lift. Damage to your chair,

lift, vehicle may occur. Take the lift to

your nearest dealer and have it evaluated

prior to further use.

 6/-0"%*/(5)&$)"*3

Insert the key and switch to ‘ON’ position.

Press ‘DOWN’ to lower the lift. Do NOT

continue travel to the point where the

vehicle rises; that will damage the lift.

<'JHVSF>

Drive the chair o the platform carefully.

When the chair is unloaded, press ‘UP’ and

the platform will automatically fold. (Except

AL010/050 and AL030).

TEC0093 160406 P/N: 610-00045 Rev B

KEEPER PLATE

KEEPER PLAT

ATE

ATAT

KEEPE

| www.harmar.com | 800-833-0478



SECTION 1 : OWNER

0QFSBUJOH:PVS-JGU

"-"/%"-

.*$30-*'54

'JHVSF

'JHVSF

.*$30-*'54'0-%*/(

"- and "- models require the

platform to be folded and unfolded manually.

The locking mechanism consists of a pin and

keeper plate, which must be disengaged before

unfolding. Simply hold the platform rmly and

lower it approximately 2” to allow the platform to

disengage and unfold.<'JHVSF>

8"3/*/(

Hold platform rmly

while lowering the lift

to its down position.

To lock in the upright position, lift platform

up before the pin engages the keeper plate.

<'JHVSF>

8"3/*/(

Hold platform rmly while

raising the lift until the pin has

engaged the keeper plate.

TEC0093 160406 P/N: 610-00045 Rev B

Autres manuels pour AL030

Ce manuel convient aux modèles suivants

Autres manuels Harmar Mobility Système de levage

Harmar Mobility

Harmar Mobility AL350 Mode d'emploi

Harmar Mobility

Harmar Mobility Pinnacle SL600 Manuel utilisateur

Harmar Mobility

Harmar Mobility HIGHLANDER II Supplément

Harmar Mobility

Harmar Mobility AL625 Mode d'emploi

Harmar Mobility

Harmar Mobility HELIX Manuel utilisateur

Harmar Mobility

Harmar Mobility AL6000 Manuel utilisateur

Harmar Mobility

Harmar Mobility MODRAMP Manuel utilisateur

Harmar Mobility

Harmar Mobility AL600 Pioneer Instructions d'installation

Harmar Mobility

Harmar Mobility VPL400-X Manuel utilisateur

Harmar Mobility

Harmar Mobility Pinnacle SL600 Supplément

Harmar Mobility

Harmar Mobility AL030 Mode d'emploi

Harmar Mobility

Harmar Mobility IL500 Sierra Inclined Platform Lift Supplément

Harmar Mobility

Harmar Mobility AL215 Axis I Mode d'emploi

Harmar Mobility

Harmar Mobility AL001 Manuel utilisateur

Harmar Mobility

Harmar Mobility AL815CC Mode d'emploi

Harmar Mobility

Harmar Mobility PARAGON OUTLANDER FULL Mode d’emploi

Harmar Mobility

Harmar Mobility Pride Outlander Series Manuel utilisateur

Harmar Mobility

Harmar Mobility Single-Fold Ramp Instructions d'installation

Harmar Mobility

Harmar Mobility AL055 Mode d'emploi

Harmar Mobility

Harmar Mobility VPL400-X Supplément

Harmar Mobility

Harmar Mobility Highlander RPL400 Manuel utilisateur

Harmar Mobility

Harmar Mobility AL600 Pioneer Instructions d'installation

Harmar Mobility

Harmar Mobility IL500 Sierra Inclined Platform Lift Mode d’emploi

Harmar Mobility

Harmar Mobility CPLP400 Instructions d'installation

Manuels Système de levage populaires d'autres marques

morse

morse 82H-124 Manuel utilisateur

Braun

Braun NL955 Series Manuel utilisateur

haacon

haacon 1889.10 Manuel utilisateur

Protekt

Protekt AT 252 Manuel utilisateur

R. Beck Maschinenbau

R. Beck Maschinenbau HS 600 Manuel utilisateur

Nova Technology International, LLC

Nova Technology International, LLC NAS Series Manuel utilisateur

Genie

Genie Z-60/34 Manuel utilisateur

Screen Technics

Screen Technics INTERFIT Vertical Up Lift Manuel utilisateur

Mortuary Lift

Mortuary Lift ULTIMATE 1000 Manuel utilisateur

Custom Equipment

Custom Equipment Hy-Brid 3 Series Manuel de programmation

Custom Equipment

Custom Equipment Hy-Brid Lifts 2 Series Manuel de programmation

Hy-Brid Lifts

Hy-Brid Lifts HB-P3.6 Manuel de programmation

BERG

BERG BeNomic EasyLeaf Manuel utilisateur

Powermate

Powermate LiftGate LG-3 Manuel utilisateur

Snorkel

Snorkel TM12 Series Manuel utilisateur

Terberg

Terberg OMNIDEKA Manuel utilisateur

Rotary

Rotary SPO16 Manuel utilisateur

Ricon

Ricon Mirage F9T Manuel utilisateur